Recommended replacement interval for the part category Fuel filter : 2 year / 60000 km

Important!

This replacement procedure can be used for:
FORD Tourneo Courier MPV 1.5 EcoBlue, FORD Tourneo Courier MPV 1.6 TDCi, FORD Tourneo Courier MPV 1.5 TDCi … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

Alternative products

Fuel filter

Replacement: fuel filter – FORD TOURNEO COURIER Kombi. List of the tools you'll need:

                      All-purpose cleaning spray
                    
                      Drive socket # 8
                    
                      Torx bit T15
                    
                      Ratchet wrench
                    
                      Torque wrench
                    
                      Bleeder kit
                    
                      Flat Screwdriver
                    
                      Fender cover

Buy tools

Replacement: fuel filter – FORD TOURNEO COURIER Kombi. AUTODOC experts recommend:

Ensure adequate ventilation of the workplace. Fuel vapors are poisonous.
All work should be done with the engine stopped.

Replacement: fuel filter – FORD TOURNEO COURIER Kombi. Use the following procedure:

Step 1

Open the hood.

Step 2

Use a fender protection cover to prevent damaging paintwork and plastic parts of the car.

Step 3

Remove the engine cover.

Replacement: fuel filter – FORD TOURNEO COURIER Kombi. Tip from AUTODOC:
Raise the engine cover, holding it on two sides simultaneously.Do not apply excessive force when removing the part. Otherwise you may damage it.
Step 4

Unscrew the fuel filter bracket fixing bolts. Use a drive socket #8. Use a ratchet wrench.
Step 5

Clean the fasteners of the fuel supply lines. Use all-purpose cleaning spray.
Step 6

Detach the fuel pressure sensor connector.
Step 7

Squeeze the clips and detach the fuel supply lines from the fuel filter housing. Use a flat screwdriver.

AUTODOC recommends:
Be careful! Fuel may leak from the filter housing and hoses.
Step 8

Detach the fuel pressure sensor connector.
Step 9

Loosen the fuel filter mounting. Use a drive socket #8. Use a ratchet wrench.
Step 10

Remove the fuel filter.
Step 11

Clean the fuel filter. Use all-purpose cleaning spray.
Step 12

Unscrew the fasteners of the fuel filter housing cover. Use Torx T15. Use a ratchet wrench.
Step 13

Remove the fuel filter housing cover.
Step 14

Clean the fuel filter housing and the cover. Use all-purpose cleaning spray.
Step 15

Install and tighten the cap of the fuel filter housing. Use Torx T15. Use a ratchet wrench.
Step 16

Install a new fuel filter.

Replacement: fuel filter – FORD TOURNEO COURIER Kombi. AUTODOC experts recommend:
Take care to only use quality filters.
Step 17

Screw in the fuel filter mounting bracket. Use a drive socket #8. Use a ratchet wrench.
Step 18

Attach the fuel pressure sensor connector.
Step 19

Connect the fuel lines to the fuel filter and lock the fastening clips.
Step 20

Connect the bleeder kit to the fuel filter bleeder screw.
Step 21

Fill the new filter with fuel.
Step 22

Remove the bleeder kit.
Step 23

Connect the fuel lines to the fuel filter and lock the fastening clips.
Step 24

Attach the fuel pressure sensor connector.
Step 25

Clean the fasteners of the fuel supply lines. Use all-purpose cleaning spray.
Step 26

Screw the fixing bolts of the fuel filter bracket. Use a drive socket #8. Use a ratchet wrench.
Step 27

Install the engine cover and secure it.

Replacement: fuel filter – FORD TOURNEO COURIER Kombi. Professionals recommend:
Make sure the engine cover is properly seated. It should not be displaced with respect to the guiding fasteners.Do not apply excessive force when installing the part. Otherwise you may damage the fasteners.
Step 28

Switch on the ignition. This should be done to activate the fuel pump to make it pump fuel through the fuel system.

Step 29

Run the engine for a few minutes. This is necessary in order to make sure that the component operates properly.

Step 30

Shut off the engine.

Step 31

Remove the fender protection cover.

Step 32

Close the hood.

Replacement: fuel filter – FORD TOURNEO COURIER Kombi. AUTODOC recommends:
To protect the environment from pollution, be sure to dispose of the used filters at special collection points.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Need New Tyres?

Find out which tyre and wheel sizes are compatible with the FORD Tourneo Courier MPV model

FORD TOURNEO COURIER Kombi tyre size

How to change pollen filter on FORD Tourneo Courier MPV – replacement guide

Free download PDF
1.11 MB
How to change air filter on FORD TOURNEO COURIER Kombi – replacement guide

Free download PDF
972.8 KB
How to change engine oil and filter on FORD Tourneo Courier – replacement guide

Free download PDF
2.56 MB
How to change front brake pads on FORD TOURNEO COURIER Kombi – replacement guide

Free download PDF
1.44 MB
How to change front brake discs on FORD TOURNEO COURIER Kombi – replacement guide

Free download PDF
1.71 MB
How to change front wheel bearing on FORD Tourneo Courier – replacement guide

Free download PDF
4.22 MB

How to change fuel filter on a car – replacement tutorial

Universal

Free download PDF
2 MB
How to change fuel filter on Ford Focus MK2 – replacement guide

Free download PDF
1.58 MB
How to change fuel filter on Ford Fiesta JA8 – replacement guide

Free download PDF
2.02 MB
How to change fuel filter on Ford Fiesta V JH JD – replacement guide

Free download PDF
1.7 MB
How to change fuel filter on Ford Mondeo BWY – replacement guide

Free download PDF
1.05 MB
How to change fuel filter on Ford Mondeo Mk3 saloon – replacement guide

Free download PDF
1.5 MB

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

How to Fix a Squealing Belt: Causes & Solutions | AUTODOC Expert Tips

5K views

Published on: 04/03/2021
TOP 8 mistakes car owners make | AUTODOC tips

14K views

Published on: 09/12/2021
Initial Car Inspection: What to Check Before You Buy

5K views

Published on: 24/10/2020
DIY brake caliper restoration | AUTODOC tips

821K views

Published on: 02/06/2022