Recommended replacement interval for the part category Brake pad set : 30000 km

Important!

This replacement procedure can be used for:
FORD Tourneo Courier MPV 1.5 EcoBlue, FORD Tourneo Courier MPV 1.5 TDCi, FORD Tourneo Courier MPV 1.6 TDCi, FORD Tourneo Courier MPV 1.5 TDCi, FORD Tourneo Courier MPV 1.0 EcoBoost … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

Alternative products

Brake pad set

Replacement: brake pads – FORD TOURNEO COURIER Kombi. Tools you need:

                      Wire brush
                    
                      Nylon cleaning brush
                    
                      WD-40 spray
                    
                      Brake cleaner
                    
                      Anti-squeal paste
                    
                      Copper grease
                    
                      Combination spanner #12
                    
                      Drive socket # 12
                    
                      Wheel impact socket #19
                    
                      Torque wrench
                    
                      Brake caliper wind back tool
                    
                      Crow bar
                    
                      Wheel chock

Buy tools

Replacement: brake pads – FORD TOURNEO COURIER Kombi. Tip from AUTODOC experts:

Perform the replacement of brake pads in complete set for each axis. This provides effective braking.
The replacement procedure is identical for all brake pads on the same axle.
All work should be done with the engine stopped.

Replacement: brake pads – FORD TOURNEO COURIER Kombi. Recommended sequence of steps:

Step 1

Open the hood. Unscrew the brake fluid reservoir cap.

Step 2

Secure the wheels with chocks.
Step 3

Loosen the wheel mounting bolts. Use wheel impact socket #19.
Step 4

Raise the front of the car and secure on supports.

Step 5

Unscrew the wheel bolts.

Replacement: brake pads – FORD TOURNEO COURIER Kombi. Tip:
To avoid injury, hold up the wheel when unscrewing the bolts.
Step 6

Remove the wheel.
Step 7

Clean the brake caliper fasteners. Use a wire brush. Use WD-40 spray.
Step 8

Unscrew the brake caliper fastening. Use a combination spanner #12.
Step 9

Spread the brake pads. Use a crowbar.
Step 10

Remove the brake caliper.

Replacement: brake pads – FORD TOURNEO COURIER Kombi. AUTODOC recommends:
Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
Step 11

Remove the brake pads. Use a crowbar.

Replacement: brake pads – FORD TOURNEO COURIER Kombi. AUTODOC experts recommend:
Measure the brake disc thickness. Upon reaching the wear limit the part must be replaced.
Step 12

Treat the brake caliper piston. Use a nylon cleaning brush. Use a brake cleaner.

AUTODOC recommends:
Replacement: brake pads – FORD TOURNEO COURIER Kombi. After applying the spray, wait a few minutes.
Step 13

Press in the brake caliper piston. Use brake caliper wind back tool.
Step 14

Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.

Replacement: brake pads – FORD TOURNEO COURIER Kombi. Tip from AUTODOC:
After applying the spray, wait a few minutes.
Step 15

Treat the brake pads in the area where their surface comes into contact with the brake caliper bracket. Use anti-squeal paste.

AUTODOC recommends:
Make sure the disc surface is clean before installing the pads.
Step 16

Install new brake pads.

Replacement: brake pads – FORD TOURNEO COURIER Kombi. Tip:
Make sure the pads are installed with linings facing the disc.
Step 17

Install the brake caliper and fix it. Use a drive socket #12. Use a torque wrench. Tighten it to 26 Nm torque.
Step 18

Treat the surface where the brake disc contacts the wheel rim. Use copper grease.
Step 19

Clean the brake disk surface. Use a brake cleaner.

AUTODOC recommends:
Replacement: brake pads – FORD TOURNEO COURIER Kombi. After applying the spray, wait a few minutes.
Step 20

Install the wheel.

Replacement: brake pads – FORD TOURNEO COURIER Kombi. AUTODOC recommends:
To avoid injury, hold up the wheel when screwing in the fastening bolts.
Step 21

Screw in the wheel bolts. Use wheel impact socket #19.
Step 22

Lower the car and working in a cross order, tighten the wheel bolts. Use wheel impact socket #19. Use a torque wrench. Tighten it to 110 Nm torque.
Step 23

Remove the jacks and chocks.

Replacement: brake pads – FORD TOURNEO COURIER Kombi. Tip from AUTODOC:
Check the brake fluid level in the expansion tank and refill if necessary.
Step 24

Tighten the brake fluid reservoir cap.

AUTODOC recommends:
FORD TOURNEO COURIER Kombi – Without starting the engine, press the brake pedal several times until it feels firm.
Step 25

Close the hood.

Replacement: brake pads – FORD TOURNEO COURIER Kombi. AUTODOC experts recommend:
Slow down smoothly for first 150-200 km after the brake pads replacement. Avoid unneccessary and sharp braking to a stop.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Need New Tyres?

Find out which tyre and wheel sizes are compatible with the FORD Tourneo Courier MPV model

FORD TOURNEO COURIER Kombi tyre size

How to change front brake discs on FORD TOURNEO COURIER Kombi – replacement guide

Free download PDF
1.71 MB
How to change front wheel bearing on FORD Tourneo Courier – replacement guide

Free download PDF
4.22 MB
How to change serpentine belt on FORD TOURNEO COURIER Kombi – replacement guide

Free download PDF
768 KB
How to change engine oil and filter on FORD Tourneo Courier – replacement guide

Free download PDF
2.56 MB
How to change front anti roll bar links on FORD TOURNEO COURIER Kombi – replacement guide

Free download PDF
1.26 MB
How to change air filter on FORD TOURNEO COURIER Kombi – replacement guide

Free download PDF
972.8 KB

How to change brake pads on a car – replacement tutorial

Universal

Free download PDF
2.84 MB
How to change rear brake pads on Ford Focus MK2 – replacement guide

Free download PDF
1.81 MB
How to change front brake pads on Ford Fiesta JA8 – replacement guide

Free download PDF
1.61 MB
How to change front brake pads on Ford Focus MK2 – replacement guide

Free download PDF
2.37 MB
How to change front brake pads on Ford Fiesta V JH JD – replacement guide

Free download PDF
1.74 MB
How to change front brake pads on Ford Focus DAW – replacement guide

Free download PDF
1.79 MB

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

How to Get the Best Deals on Car Parts | Save Money with AUTODOC

2K views

Published on: 03/02/2022
5 tools that make car repair incredibly simple | AUTODOC tips

49K views

Published on: 25/01/2024
Why does it burn oil? The main cause of oil consumption in EA888 Gen 1

118K views

Published on: 14/08/2025
How to remove scratches from car plastic | AUTODOC tips

187K views

Published on: 15/12/2022