Recommended replacement interval for the part category Fuel filter : 12 month / 15000 km

Important!

This replacement procedure can be used for:
FORD MONDEO III Saloon (B4Y) 1.8 16V, FORD MONDEO III (B5Y) 1.8 16V, FORD MONDEO III Estate (BWY) 1.8 16V

The steps may slightly vary depending on the car design.

How to change fuel filter on FORD MONDEO 3 TUTORIAL | AUTODOC

Replacement: fuel filter – Ford Mondeo BWY. Tools you might need:

                        Nylon cleaning brush 
                      
                        All-purpose cleaning spray
                      
                        Drive socket # 8
                      
                        Ratchet wrench
                      
                        Torque wrench
                      
                        Flat Screwdriver
                      
                        Round-nose pliers
                      
                        Fuel line pliers
                      
                        Fluid container

All the parts you need to replace – Fuel Filter for MONDEO III Estate (BWY) and other FORD models

 
    FORD MONDEO III Saloon (B4Y) 1.8 16V
  
    FORD MONDEO III (B5Y) 1.8 16V
  
    FORD MONDEO III Estate (BWY) 1.8 16V

Replacement: fuel filter – Ford Mondeo BWY. AUTODOC recommends:

Ensure adequate ventilation of the workplace. Fuel vapors are poisonous.
All work should be done with the engine stopped.

Replacement: fuel filter – Ford Mondeo BWY. Use the following procedure:

Step 1

Lift the car using a jack or place it over an inspection pit.
Step 2

Clean the fasteners of the fuel supply lines. Use a nylon cleaning brush. Use all-purpose cleaning spray.
Step 3

Prepare a container for fluids.
Step 4

Squeeze the clips and detach the fuel supply lines from the fuel filter housing.Use round-nose pliers.Use a flat screwdriver.

Replacement: fuel filter – Ford Mondeo BWY. Tip:

Be careful! Fuel may leak from the filter housing and hoses.
Step 5

Unscrew the fuel filter bracket fixing bolts.Use a drive socket #8.Use a ratchet wrench.
Step 6

Remove the fuel filter together with its bracket.
Step 7

Unscrew the fuel filter bracket.Use a drive socket #8.Use a ratchet wrench.
Step 8

Remove the fuel filter.
Step 9

Install a new fuel filter.

AUTODOC recommends:

Make sure that the fuel filter is positioned correctly. Consider the fuel flow direction mark.During installation, take care to prevent dust and dirt from getting into the fuel filter housing.Ford Mondeo BWY – It's important to only use high-quality filters.
Step 10

Screw in the fuel filter mounting bracket.Use a drive socket #8.Use a ratchet wrench.
Step 11

Install the new fuel filter together with its bracket.
Step 12

Screw the fixing bolts of the fuel filter bracket.Use a drive socket #8.Use a torque wrench.Tighten it to 9 nm torque.
Step 13

Connect the fuel lines to the fuel filter and lock the fastening clips.
Step 14

Take the fluid container away from under the fuel filter.

Step 15

Lower the car.

Replacement: fuel filter – Ford Mondeo BWY. AUTODOC experts recommend:

Before starting off, switch the ignition on and off several times. This should be done to activate the fuel pump to make it pump fuel through the fuel system.
Step 16

Run the engine for a few minutes.This is necessary in order to make sure that the component operates properly.

Step 17

Shut off the engine.

Replacement: fuel filter – Ford Mondeo BWY. Tip from AUTODOC:

To protect the environment from pollution, be sure to dispose of the used filters at special collection points.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

How to change front suspension strut on Ford Mondeo BWY – replacement guide

Free download PDF

18.48 MB
How to change front wheel bearing on Ford Mondeo BWY – replacement guide

Free download PDF

12.47 MB
How to change front brake pads on Ford Mondeo BWY – replacement guide

Free download PDF

7.03 MB
How to change front brake caliper on Ford Mondeo BWY – replacement guide

Free download PDF

8.4 MB
How to change engine oil and filter on Ford Mondeo BWY – replacement guide

Free download PDF

8.02 MB
How to change rear coil springs on Ford Mondeo BWY – replacement guide

Free download PDF

7.14 MB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

Tips & tricks for your FORD MONDEO III Estate (BWY)

How to remove a broken bolt without welding | AUTODOC TIPS

259K views

Published on: 11/03/2020
Noise from under the hood | AUTODOC TIPS

198K views

Published on: 25/08/2019
How to fix a knocking and creaking suspension | AUTODOC

181K views

Published on: 08/09/2019
6 SIGNS OF A BAD FUEL FILTER | AUTODOC

163K views

Published on: 24/07/2019