Recommended replacement interval for the part category Fuel filter : 12 month / 15000 km

Important!

This replacement procedure can be used for:
FORD MONDEO III (B5Y) 2.0 16V, FORD MONDEO III Estate (BWY) 2.0 16V, FORD MONDEO III Saloon (B4Y) 2.0 16V, FORD MONDEO III Saloon (B4Y) 2.0, CITROËN C5 I (DC_) 2.0 16V (DCRFNC, DCRFNF)

The steps may slightly vary depending on the car design.

How to change fuel filter FORD MONDEO MK3 Saloon [TUTORIAL AUTODOC]

All the parts you need to replace – Fuel Filter for MONDEO III Saloon (B4Y) and other FORD models

Fuel filter

      FORD MONDEO III (B5Y) 2.0 16V
    
      FORD MONDEO III Estate (BWY) 2.0 16V
    
      FORD MONDEO III Saloon (B4Y) 2.0 16V
    
      FORD MONDEO III Saloon (B4Y) 2.0
    
      CITROËN C5 I (DC_) 2.0 16V (DCRFNC, DCRFNF)

Replacement: fuel filter – Ford Mondeo Mk3 saloon. List of the tools you'll need:

                        Wire brush
                      
                        Nylon cleaning brush
                      
                        WD-40 spray
                      
                        All-purpose cleaning spray
                      
                        Drive socket # 8
                      
                        Drive socket # 10
                      
                        Fluid container
                      
                        Ratchet wrench

Buy tools

Replacement: fuel filter – Ford Mondeo Mk3 saloon. AUTODOC experts recommend:

Ensure adequate ventilation of the workplace. Fuel vapors are poisonous.
All work should be done with the engine stopped.

Replacement: fuel filter – Ford Mondeo Mk3 saloon. Use the following procedure:

Step 1

Open the fuel door.
Step 2

Unscrew the fuel filler cap.
Step 3

Lift the car using a jack or place it over an inspection pit.
Step 4

Clean the fuel filter mounting bracket.Use a wire brush.Use WD-40 spray.
Step 5

Unscrew the fastening bolts of the fuel filter bracket.Use a drive socket #10.Use a ratchet wrench.
Step 6

Clean the fuel filter mounting bracket.Use a wire brush.Use WD-40 spray.
Step 7

Unscrew the fuel filter bracket.Use a drive socket #8.Use a ratchet wrench.
Step 8

Remove the fuel filter fastening bracket.

Step 9

Prepare a container for fluids.
Step 10

Clean the fasteners of the fuel supply lines. Use a nylon cleaning brush. Use all-purpose cleaning spray.
Step 11

Disconnect the fuel supply lines from the fuel filter.
Step 12

Remove the fuel filter.

Replacement: fuel filter – Ford Mondeo Mk3 saloon. AUTODOC experts recommend:

Be careful! Fuel may leak from the filter housing and hoses.
Step 13

Clean the fuel lines.Use all-purpose cleaning spray.
Step 14

Install a new fuel filter.

Replacement: fuel filter – Ford Mondeo Mk3 saloon. AUTODOC recommends:

Remember, it is important not to mix up the input and output of the filter. Arrows on the filter indicate the direction of fuel flow.During installation, take care to prevent dust and dirt from getting into the fuel filter housing.Attention! Use quality filters – Ford Mondeo Mk3 saloon.
Step 15

Install the fuel line.
Step 16

Install the fuel filter fastening bracket.
Step 17

Install the fuel line.
Step 18

Screw in the fuel filter mounting bracket.Use a drive socket #8.Use a ratchet wrench.
Step 19

Screw in the fastening bolts of the fuel filter bracket.Use a drive socket #10.Use a ratchet wrench.
Step 20

Clean the fuel filter.Use all-purpose cleaning spray.
Step 21

Take the fluid container away from under the fuel filter.
Step 22

Lower the car.
Step 23

Tighten the fuel filler cap.
Step 24

Close the fuel door.

Replacement: fuel filter – Ford Mondeo Mk3 saloon. Tip from AUTODOC experts:

Before starting off, switch the ignition on and off several times. This should be done to activate the fuel pump to make it pump fuel through the fuel system.
Step 25

Run the engine for a few minutes.This is necessary in order to make sure that the component operates properly.

Comment

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

How to change fuel filter on Ford Mondeo BWY – replacement guide

Free download PDF

5.02 MB
How to change engine oil and filter on Ford Mondeo BWY – replacement guide

Free download PDF

8.02 MB
How to change air filter on Ford Mondeo BWY – replacement guide

Free download PDF

4.33 MB
How to change pollen filter on Ford Mondeo BWY – replacement guide

Free download PDF

3.93 MB
How to change front suspension strut on Ford Mondeo BWY – replacement guide

Free download PDF

18.48 MB
How to change front wheel bearing on Ford Mondeo BWY – replacement guide

Free download PDF

12.47 MB
How to change front brake pads on Ford Mondeo BWY – replacement guide

Free download PDF

7.03 MB
How to change front lower arm on Ford Mondeo BWY – replacement guide

Free download PDF

9.49 MB
How to change front brake discs on Ford Mondeo BWY – replacement guide

Free download PDF

8.21 MB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

Tips & tricks for your FORD MONDEO III Saloon (B4Y)

DIY car soundproofing | AUTODOC tips

17K views

Published on: 15/04/2021
Checking the starter without removing it | AUTODOC tips

2K views

Published on: 01/12/2020
How to replace the suspension on a BMW E30 Turbo | SUPERCAR AUTODOC

738 views

Published on: 09/03/2021
What to check when buying a used car | AUTODOC tips

4K views

Published on: 24/10/2020