Recommended replacement interval for the part category Fuel filter : 6 year / 120000 km

Important!

This replacement procedure can be used for:
FORD Fiesta Mk5 Hatchback (JH1, JD1, JH3, JD3) 1.4 16V, FORD Fiesta Mk5 Hatchback (JH1, JD1, JH3, JD3) 1.3, FORD Fiesta Mk5 Hatchback (JH1, JD1, JH3, JD3) 1.3, FORD Fiesta Mk5 Hatchback (JH1, JD1, JH3, JD3) 1.6 16V, FORD Fiesta Mk5 Hatchback (JH1, JD1, JH3, JD3) 1.25 16V, FORD Fiesta Mk5 Hatchback (JH1, JD1, JH3, JD3) 1.25 16V, FORD Fiesta Mk5 Hatchback (JH1, JD1, JH3, JD3) ST150 … View more

The steps may slightly vary depending on the car design.

How to change fuel filter FORD FIESTA V JH, JD [TUTORIAL AUTODOC]

Alternative products

Fuel filter

Replacement: fuel filter – Ford Fiesta V JH JD. Tools you'll need:

                      Nylon cleaning brush 
                    
                      All-purpose cleaning spray
                    
                      Fluid container
                    
                      Fuel line pliers
                    
                      Crow bar

Buy tools

Replacement: fuel filter – Ford Fiesta V JH JD. AUTODOC recommends:

Ensure adequate ventilation of the workplace. Fuel vapors are poisonous.
All work should be done with the engine stopped.

Replacement: fuel filter – Ford Fiesta V JH JD. Recommended sequence of steps:

Step 1

Open the fuel door.

Step 2

Unscrew the fuel filler cap.

Step 3

Lift the car using a jack or place it over an inspection pit.
Step 4

Prepare a container for fluids.
Step 5

Clean the fasteners of the fuel supply lines. Use a nylon cleaning brush. Use all-purpose cleaning spray.
Step 6

Remove the fuel filter. Use a crowbar.
Step 7

Disconnect the fuel supply lines from the fuel filter. Use fuel line pliers.

Replacement: fuel filter – Ford Fiesta V JH JD. Tip:
Be careful! Fuel may leak from the filter housing and hoses.
Step 8

Put the old filter cartridge in the container.
Step 9

Connect the fuel supply lines to the fuel filter.
Step 10

Install a new fuel filter.

Replacement: fuel filter – Ford Fiesta V JH JD. Tip from AUTODOC:
Make sure that the fuel filter is positioned correctly. Consider the fuel flow direction mark.During installation, take care to prevent dust and dirt from getting into the fuel filter housing.Take care to only use quality filters.
Step 11

Take the fluid container away from under the fuel filter.
Step 12

Lower the car.
Step 13

Tighten the fuel filler cap.

Step 14

Close the fuel door.

Replacement: fuel filter – Ford Fiesta V JH JD. AUTODOC recommends:
Before starting off, switch the ignition on and off several times. This should be done to activate the fuel pump to make it pump fuel through the fuel system.
Step 15

Run the engine for a few minutes. This is necessary in order to make sure that the component operates properly.

Step 16

Shut off the engine.

AUTODOC recommends:
To protect the environment from pollution, be sure to dispose of the used filters at special collection points.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Need New Tyres?

Find out which tyre and wheel sizes are compatible with the FORD Fiesta Mk5 Hatchback (JH1, JD1, JH3, JD3) model

Ford Fiesta Mk5 tyre size

How to change engine oil and filter on Ford Fiesta V JH JD – replacement guide

Free download PDF
2.72 MB
How to change pollen filter on Ford Fiesta V JH JD – replacement guide

Free download PDF
931.84 KB
How to change air filter on Ford Fiesta V JH JD – replacement guide

Free download PDF
1.58 MB
How to change front brake pads on Ford Fiesta V JH JD – replacement guide

Free download PDF
1.74 MB
How to change rear brake pads on FORD Fiesta Mk5 Hatchback (JH1, JD1, JH3, JD3) – replacement guide

Free download PDF
1.56 MB
How to change front brake discs on Ford Fiesta V JH JD – replacement guide

Free download PDF
2.8 MB

How to change fuel filter on Ford Fiesta JA8 – replacement guide

Free download PDF
2.02 MB
How to change fuel filter on FORD Fiesta Mk6 Van – replacement guide

Free download PDF
1.67 MB
How to change fuel filter on FORD Fiesta Mk5 Van – replacement guide

Free download PDF
1.57 MB
How to change fuel filter on a car – replacement tutorial

Universal

Free download PDF
2 MB
How to change fuel filter on Ford Focus MK2 – replacement guide

Free download PDF
1.58 MB
How to change fuel filter on Ford Mondeo BWY – replacement guide

Free download PDF
1.05 MB

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

Reviving Your Car: How to Start After Extended Idle Time | AUTODOC Tips

7K views

Published on: 20/05/2021
When, why, and how to change engine oil | AUTODOC tips

7K views

Published on: 16/08/2024
Don’t Replace, Restore: Fixing Damaged Threads at Home

9K views

Published on: 04/05/2023
DIY rear axle restoration | Drivetrain restoration – Part 2

7K views

Published on: 07/11/2024