Recommended replacement interval for the part category Brake pad set : 30000 km

Important!

This replacement procedure can be used for:
TOYOTA RAV 4 II (CLA2_, XA2_, ZCA2_, ACA2_) 1.8 (ZCA25_, ZCA26_), TOYOTA RAV 4 II (CLA2_, XA2_, ZCA2_, ACA2_) 2.0 D 4WD (CLA20_, CLA21_), TOYOTA RAV 4 II (CLA2_, XA2_, ZCA2_, ACA2_) 2.4 4WD (ACA23, ACA22), TOYOTA RAV 4 II (CLA2_, XA2_, ZCA2_, ACA2_) 2.0 (ACA26) … View more

The steps may slightly vary depending on the car design.

How to change front brake pads on TOYOTA RAV4 II [TUTORIAL AUTODOC]

All the parts you need to replace – Brake Pads for RAV 4 II (CLA2_, XA2_, ZCA2_, ACA2_) and other TOYOTA models

Brake pad set

        Brake pad set for RAV4 II Off-Road (XA20) Petrol (125 hp)
      
        Brake pad set for RAV4 II Off-Road (XA20) Diesel (116 hp)
      
        Brake pad set for RAV4 II Off-Road (XA20) Petrol (152 hp)
      
        Brake pad set for RAV4 II Off-Road (XA20) Petrol (150 hp)

Replacement: brake pads – Toyota RAV4 II. Tools you need:

                        Wire brush
                      
                        Nylon cleaning brush
                      
                        WD-40 spray
                      
                        Brake cleaner 
                      
                        Anti-squeal paste
                      
                        Ceramic grease
                      
                        Torque wrench
                      
                        Combination spanner #14
                      
                        Combination spanner #17
                      
                        Drive socket # 14
                      
                        Wheel impact socket #19
                      
                        Brake caliper wind back tool
                      
                        Crow bar
                      
                        Wheel chock

Buy tools

Replacement: brake pads – Toyota RAV4 II. Tip from AUTODOC:

Perform the replacement of brake pads in complete set for each axis. This provides effective braking.
The replacement procedure is identical for all brake pads on the same axle.
Please note: all work on the car – Toyota RAV4 II – should be done with the engine switched off.

Carry out replacement in the following order:

Step 1

Open the bonnet. Unscrew the brake fluid reservoir cap.
Step 2

Secure the wheels with chocks.

Step 3

Loosen the wheel mounting bolts. Use wheel impact socket #19.
Step 4

Raise the car.

Replacement: brake pads – Toyota RAV4 II. Tip from AUTODOC:
If you are using a jack, make sure it rests on a flat surface without any unevenness.Be sure to additionally secure the car with jack stands.
Step 5

Unscrew the wheel bolts.

AUTODOC recommends:
Warning! To avoid injury, hold the wheel while unscrewing the fastening bolts. Toyota RAV4 II
Step 6

Remove the wheel.
Step 7

Spread the brake pads. Use a crowbar.
Step 8

Clean the brake caliper fasteners. Use a wire brush. Use WD-40 spray.
Step 9

Unscrew the brake caliper fasteners. Use a combination spanner #14.
Step 10

Remove the fastening bolts.
Step 11

Remove the brake caliper.

Replacement: brake pads – Toyota RAV4 II. Tip:
Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur.
Step 12

Remove the brake pads.

Replacement: brake pads – Toyota RAV4 II. Professionals recommend:
Measure the brake disc thickness. Upon reaching the wear limit the part must be replaced.
Step 13

Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.

AUTODOC recommends:
Replacement: brake pads – Toyota RAV4 II. After applying the spray, wait a few minutes.Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
Step 14

Treat the brake pads in the area where their surface comes into contact with the brake caliper bracket. Use anti-squeal paste.

AUTODOC recommends:
Make sure the disc surface is clean before installing the pads.
Step 15

Install new brake pads.
Step 16

Treat the brake caliper pistons. Use a nylon cleaning brush. Use a brake cleaner.

Replacement: brake pads – Toyota RAV4 II. Tip from AUTODOC:
After applying the spray, wait a few minutes.
Step 17

Wind back the brake caliper pistons. Use brake caliper wind back tool.
Step 18

Install the brake caliper and fix it.
Step 19

Install the fastening bolts.
Step 20

Tighten the brake caliper fasteners. Use a combination spanner #17. Use a drive socket #14. Use a torque wrench. Tighten it to 26 Nm torque.
Step 21

Clean the wheel rim mounting seat. Use a wire brush.
Step 22

Treat the surface where the brake disc contacts the wheel rim. Use ceramic grease.
Step 23

Clean the brake disk surface. Use a brake cleaner.

AUTODOC recommends:
After applying the spray, wait a few minutes.
Step 24

Install the wheel.

AUTODOC recommends:
Warning! To avoid injury, hold the wheel while screwing in the fastening bolts on the car. Toyota RAV4 II
Step 25

Screw in the wheel bolts. Use wheel impact socket #19.
Step 26

Lower the car and working in a cross order, tighten the wheel bolts. Use wheel impact socket #19. Use a torque wrench. Tighten it to 103 Nm torque.
Step 27

Remove the jacks and chocks.

AUTODOC recommends:
Without starting the engine, press the brake pedal several times until you feel significant resistance.Check the brake fluid level in the expansion tank and refill if necessary.
Step 28

Tighten the brake fluid reservoir cap. Close the hood.

Replacement: brake pads – Toyota RAV4 II. Tip from AUTODOC experts:
Slow down smoothly for first 150-200 km after the brake pads replacement. Avoid unneccessary and sharp braking to a stop.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Searching for the right tyres?

Find out which tyre and wheel sizes are compatible with the TOYOTA RAV4 II Off-Road (XA20) model.

Browse tyres

How to change front brake discs on Toyota RAV4 II – replacement guide

Free download PDF
2.06 MB
How to change rear brake pads on Toyota RAV4 II – replacement guide

Free download PDF
1.79 MB
How to change rear brake discs on Toyota RAV4 II – replacement guide

Free download PDF
2.03 MB
How to change rear wheel bearing on Toyota RAV4 II – replacement guide

Free download PDF
3.01 MB
How to change front wheel bearing on Toyota RAV4 II – replacement guide

Free download PDF
4.27 MB
How to change serpentine belt on Toyota RAV4 II – replacement guide

Free download PDF
1.2 MB

How to change rear brake pads on Toyota RAV4 III – replacement guide

Free download PDF
1.96 MB
How to change front brake pads on Toyota RAV4 III – replacement guide

Free download PDF
1.88 MB
How to change rear brake pads on Toyota RAV4 II – replacement guide

Free download PDF
1.79 MB
How to change rear brake pads on TOYOTA RAV4 IV Off-Road (XA40) – replacement guide

Free download PDF
1.76 MB
How to change brake pads on a car – replacement tutorial

Universal

Free download PDF
2.84 MB
How to change front brake pads on Toyota Prado J120 – replacement guide

Free download PDF
2.08 MB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

How to remove scratches from car plastic | AUTODOC tips

100K views

Published on: 15/12/2022
How to remove rust | AUTODOC tips

25K views

Published on: 16/09/2021
4 reasons why your CHECK ENGINE light is on | AUTODOC tips

6K views

Published on: 30/03/2022
How do EGR valves work? | AUTODOC

18K views

Published on: 18/07/2020