Recommended replacement interval for the part category Brake pad set : 30000 km

Important!

This replacement procedure can be used for:
AUDI A4 Avant (8E5, B6) 1.6, AUDI A4 Avant (8E5, B6) 2.0, AUDI A4 Avant (8E5, B6) 1.8 T, AUDI A4 Avant (8E5, B6) 3.0, AUDI A4 Avant (8E5, B6) 1.9 TDI, AUDI A4 Avant (8E5, B6) 2.4, AUDI A4 Avant (8E5, B6) 2.5 TDI quattro, AUDI A4 Avant (8E5, B6) 2.5 TDI, AUDI A4 Avant (8E5, B6) 3.0 quattro, AUDI A4 Avant (8E5, B6) 1.9 TDI quattro, AUDI A4 Avant (8E5, B6) 2.0 FSI, AUDI A4 Avant (8E5, B6) 1.8 T, AUDI A4 Avant (8E5, B6) 1.8 T quattro, AUDI A4 Avant (8E5, B6) 2.5 TDI, AUDI A4 Avant (8E5, B6) 2.4, AUDI A4 Avant (8E5, B6) 1.8 T, AUDI A4 Avant (8E5, B6) 1.8 T quattro, AUDI A4 Avant (8E5, B6) S4 quattro, AUDI A4 Avant (8E5, B6) 1.9 TDI, AUDI A4 Avant (8E5, B6) 1.8 T quattro, AUDI A4 Avant (8E5, B6) 3.0, AUDI A4 Avant (8E5, B6) 3.0 quattro, AUDI A4 Avant (8E5, B6) 1.8 T quattro … View more

The steps may slightly vary depending on the car design.

How to change front brake pads / front brake pad set on AUDI A4 B6 (8E5) [TUTORIAL AUTODOC]

Alternative products

Brake pad set

Replacement: brake pads – Audi A4 B6 Avant. Tools you'll need:

                      Wire brush
                    
                      WD-40 spray
                    
                      Brake cleaner 
                    
                      Anti-squeal paste
                    
                      Copper grease 
                    
                      Combination spanner #13
                    
                      Combination spanner #15
                    
                      Wheel impact socket #17
                    
                      Brake caliper wind back tool
                    
                      Torque wrench
                    
                      Crow bar
                    
                      Wheel chock

Buy tools

Replacement: brake pads – Audi A4 B6 Avant. Professionals recommend:

Perform the replacement of brake pads in complete set for each axis. This provides effective braking.
The replacement procedure is identical for all brake pads on the same axle.
All work should be done with the engine stopped.

Replacement: brake pads – Audi A4 B6 Avant. Use the following procedure:

Step 1

Open the bonnet. Unscrew the brake fluid reservoir cap.
Step 2

Secure the wheels with chocks.
Step 3

Loosen the wheel mounting bolts. Use wheel impact socket #17.
Step 4

Raise the front of the car and secure on supports.
Step 5

Unscrew the wheel bolts.

Replacement: brake pads – Audi A4 B6 Avant. Tip:
To avoid injury, hold up the wheel when unscrewing the bolts.
Step 6

Remove the wheel.
Step 7

Clean the brake caliper fasteners. Use a wire brush. Use WD-40 spray.
Step 8

Unscrew the brake caliper fastening. Use a combination spanner #13. Use a combination spanner #15.
Step 9

Disconnect the brake pads wear sensor. Use a crowbar.

Please note!
Some cars are not equipped with the brake pad wear sensor.
Step 10

Spread the brake pads. Use a crowbar.
Step 11

Remove the brake caliper.

Replacement: brake pads – Audi A4 B6 Avant. AUTODOC recommends:
Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
Step 12

Remove the brake pads.

Replacement: brake pads – Audi A4 B6 Avant. AUTODOC experts recommend:
Measure the brake disc thickness. Upon reaching the wear limit the part must be replaced.
Step 13

Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.

AUTODOC recommends:
Replacement: brake pads – Audi A4 B6 Avant. After applying the spray, wait a few minutes.
Step 14

Treat the brake caliper piston. Use a brake cleaner.

Replacement: brake pads – Audi A4 B6 Avant. Tip from AUTODOC:
After applying the spray, wait a few minutes.
Step 15

Press in the brake caliper piston. Use brake caliper wind back tool.
Step 16

Treat the brake pads in the area where their surface comes into contact with the brake caliper bracket. Use anti-squeal paste.

Replacement: brake pads – Audi A4 B6 Avant. Tip:
Make sure the disc surface is clean before installing the pads.
Step 17

Install new brake pads.

Replacement: brake pads – Audi A4 B6 Avant. Tip from AUTODOC:
Make sure the pads are installed with linings facing the disc.
Step 18

Install the brake caliper and fix it. Use a combination spanner #13. Use a combination spanner #15. Use a torque wrench. Tighten it to 30 Nm torque.
Step 19

Connect the brake pads wear sensor.
Step 20

Treat the surface where the brake disc contacts the wheel rim. Use copper grease.
Step 21

Clean the brake disk surface. Use a brake cleaner.

Replacement: brake pads – Audi A4 B6 Avant. AUTODOC recommends:
After applying the spray, wait a few minutes.
Step 22

Install the wheel.

AUTODOC recommends:
Warning! To avoid injury, hold the wheel while screwing in the fastening bolts on the car. Audi A4 B6 Avant
Step 23

Screw in the wheel bolts. Use wheel impact socket #17.
Step 24

Lower the car and working in a cross order, tighten the wheel bolts. Use a torque wrench. Tighten it to 120 Nm torque.
Step 25

Remove the jacks and chocks.

AUTODOC recommends:
Important! Replacement: brake pads – Audi A4 B6 Avant. Check the brake fluid level in the reservoir and top up if necessary.
Step 26

Tighten the brake fluid reservoir cap.

AUTODOC recommends:
Audi A4 B6 Avant – Without starting the engine, press the brake pedal several times until it feels firm.
Step 27

Close the hood.

Replacement: brake pads – Audi A4 B6 Avant. AUTODOC experts recommend:
Slow down smoothly for first 150-200 km after the brake pads replacement. Avoid unneccessary and sharp braking to a stop.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Need New Tyres?

Find out which tyre and wheel sizes are compatible with the AUDI A4 B6 Avant (8E5) model

Audi A4 B6 Avant tyre size

How to change front brake discs on Audi A4 B6 Avant – replacement guide

Free download PDF
2.05 MB
How to change rear brake discs on Audi A4 B6 Avant – replacement guide

Free download PDF
2.05 MB
How to change rear brake pads on Audi A4 B6 Avant – replacement guide

Free download PDF
1.64 MB
How to change front brake caliper on AUDI A4 Avant (8E5, B6) – replacement guide

Free download PDF
2.34 MB
How to change rear brake caliper on AUDI A4 Avant (8E5, B6) – replacement guide

Free download PDF
1.5 MB
How to change rear wheel bearing on Audi A4 B6 Avant – replacement guide

Free download PDF
2.18 MB

How to change front brake pads on Audi A4 B8 – replacement guide

Free download PDF
1.79 MB
How to change rear brake pads on Audi A4 B8 – replacement guide

Free download PDF
1.81 MB
How to change rear brake pads on AUDI A4 Avant (8K5, B8) – replacement guide

Free download PDF
1.61 MB
How to change front brake pads on AUDI A4 Avant (8K5, B8) – replacement guide

Free download PDF
1.59 MB
How to change front brake pads on AUDI A4 Convertible (8H7, B6, 8HE, B7) – replacement guide

Free download PDF
1.6 MB
How to change rear brake pads on AUDI A4 Convertible (8H7, B6, 8HE, B7) – replacement guide

Free download PDF
1.54 MB

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

Revive Your Vehicle's Look | How to Restore Wheel Rims Yourself!

7K views

Published on: 13/05/2021
Why Checking Your Oil is Crucial for Engine Performance

6K views

Published on: 23/02/2023
What to do if the ABS light comes on: DIY Diagnostics Tips

8K views

Published on: 11/03/2021
Top 5 mistakes when replacing spark plugs | AUTODOC tips

37K views

Published on: 13/07/2023