How to carry out replacement: Brake Discs 1.9 TDI Audi A4 B6 Avant
Disclaimer
Change Audi A4 B6 Avant 1.9 TDI Brake Discs yourself – manuals and video tutorials

How to change rear brake discs on Audi A4 B6 Avant – replacement guide

downloads: 7
Views: 78
Download your free tutorial and fix AUDI A4 Avant (8E5, B6) S4 4.2 quattro problems yourself Download for free 2.05 MB Brake Discs for Audi A4 B6 Avant Shop now
Leave a comment Open in a new tab
When to replace the Brake Discs on your AUDI A4
Recommended replacement interval for the part category Brake disc : 50000 km
Important!
This replacement procedure can be used for:
AUDI A4 Avant (8E5, B6) 1.6, AUDI A4 Avant (8E5, B6) 2.0, AUDI A4 Avant (8E5, B6) 1.8 T, AUDI A4 Avant (8E5, B6) 1.9 TDI, AUDI A4 Avant (8E5, B6) 2.5 TDI quattro, AUDI A4 Avant (8E5, B6) 2.5 TDI, AUDI A4 Avant (8E5, B6) 1.8 T quattro, AUDI A4 Avant (8E5, B6) 1.9 TDI quattro, AUDI A4 Avant (8E5, B6) 2.0 FSI, AUDI A4 Avant (8E5, B6) 1.8 T, AUDI A4 Avant (8E5, B6) 1.8 T quattro, AUDI A4 Avant (8E5, B6) 2.5 TDI, AUDI A4 Avant (8E5, B6) 1.8 T, AUDI A4 Avant (8E5, B6) 1.8 T quattro, AUDI A4 Avant (8E5, B6) 1.9 TDI, AUDI A4 Avant (8E5, B6) 1.8 T quattro … View more

The steps may slightly vary depending on the car design.

How to change rear brake discs / rear brake rotors on AUDI A4 B6 (8E5) [TUTORIAL AUTODOC]

video
Published on: 19/12/2019
5K views
All the parts you need to replace – Brake Discs for A4 Avant (8E5, B6) and other AUDI models
Alternative products
How to change Brake disc on Audi A4 B6 Avant 1.9 TDI – step-by-step instructions for straightforward car repair Brake disc
Tools
Replacement: brake discs – Audi A4 B6 Avant. Tools you might need:
Wire brush
WD-40 spray
Brake cleaner
Copper grease
Drive socket # 13
Combination spanner #13
Combination spanner #15
HEX bit no.H8.
Wheel impact socket #17
Brake caliper wind back tool
Torque wrench
Crow bar
Wheel chock
Buy tools
Replacement: brake discs – Audi A4 B6 Avant. AUTODOC recommends:
  • Replace the brake disks on the car Audi A4 B6 Avant in complete set for each axis. Regardless of the state of components. This will ensure even braking.
  • The replacement procedure is identical for both brake disks on the same axle.
  • When changing the brake discs, always replace the brake pads.
  • All work should be done with the engine stopped.
Replacement: brake discs – Audi A4 B6 Avant. Take the following steps:
  1. Step 1
    How to change Brake Discs on Audi A4 B6 Avant 2001 - free PDF and video manuals
    Open the bonnet.
  2. Step 2
    How to replace AUDI A4 Avant (8E5, B6) 1.9 TDI 2002 Brake Discs - step-by-step manuals and video guides
    Unscrew the brake fluid reservoir cap.
  3. Step 3
    Audi A4 B6 Avant 2.5 TDI quattro 2003 Brake Discs replacement: free workshop manuals
    Secure the wheels with chocks.
  4. Step 4
    Changing Brake Discs on AUDI A4 Avant (8E5, B6) 1.8 T 2004 by yourself
    Loosen the wheel mounting bolts. Use wheel impact socket #17.
  5. Step 5
    How to remove AUDI A4 2.5 TDI 2001 Brake Discs - online easy-to-follow instructions
    Raise the rear of the car and secure on supports.
  6. Step 6
    How to replace Brake Discs on AUDI A4 Avant (8E5, B6) 2002: download PDF manuals and video instructions
    Unscrew the wheel bolts.
    AUTODOC recommends:
    Important! Hold the wheel while unscrewing the fastening bolts. Audi A4 B6 Avant
  7. Step 7
    How hard is it to do yourself: Brake Discs replacement on Audi A4 B6 Avant 1.8 T quattro 2003 - download illustrated guide
    Remove the wheel.
  8. Step 8
    Need to know how to renew Brake Discs on AUDI A4 2004? This free workshop manual will help you to do it yourself
    Clean the brake caliper fasteners. Use a wire brush. Use WD-40 spray.
  9. Step 9
    Changing of Brake Discs on Audi A4 B6 Avant 2001 won't be an issue if you follow this illustrated step-by-step guide
    Unscrew the brake caliper fastening. Use a combination spanner #13. Use a combination spanner #15.
  10. Step 10
    AUDI A4 1.9 TDI Brake Discs replacement: online guides and video tutorials
    Remove the brake caliper. Use a crowbar.
    Replacement: brake discs – Audi A4 B6 Avant. AUTODOC experts recommend:
    Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
  11. Step 11
    Replacing Brake Discs on Audi A4 B6 Avant 2003 1.9 TDI by yourself
    Remove the brake pads. Use a crowbar.
  12. Step 12
    A4 Avant (8E5, B6) 2.5 TDI 2004 Brake Discs DIY replacement workshop manual
    Clean the brake caliper bracket fasteners. Use a wire brush. Use WD-40 spray.
  13. Step 13
    How to change Brake Discs on AUDI A4 Avant (8E5, B6) 2001 - tips and tricks
    Unscrew the caliper bracket fastening. Use HEX No.H8.
  14. Step 14
    Step-by-step recommendations for DIY replacement Audi A4 B6 Avant 2002 2.5 TDI Brake Discs
    Remove the caliper bracket.
  15. Step 15
    DIY replacement of Brake Discs on AUDI A4 Avant (8E5, B6) 1.9 TDI quattro 2003 is not an issue anymore with our step-by-step tutorial
    Clean the brake disc fasteners. Use a wire brush. Use WD-40 spray.
  16. Step 16
    How to change Brake Discs on Audi A4 B6 Avant 2001 - free PDF and video manuals
    Remove the retaining ring. Use a crowbar.
  17. Step 17
    How to replace AUDI A4 Avant (8E5, B6) 1.9 TDI 2002 Brake Discs - step-by-step manuals and video guides
    Remove the brake disc.
  18. Step 18
    Audi A4 B6 Avant 2.5 TDI quattro 2003 Brake Discs replacement: free workshop manuals
    Clean the hub. Use a wire brush. Treat the contacting surface. Use copper grease.
  19. Step 19
    Changing Brake Discs on AUDI A4 Avant (8E5, B6) 1.8 T 2004 by yourself
    Install the brake disc. Install the retaining ring.
  20. Step 20
    How to remove AUDI A4 2.5 TDI 2001 Brake Discs - online easy-to-follow instructions
    Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.
    Replacement: brake discs – Audi A4 B6 Avant. Tip:
    After applying the spray, wait a few minutes.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
Users voted – 0
Need New Tyres?

Find out which tyre and wheel sizes are compatible with the AUDI A4 B6 Avant (8E5) model

Audi A4 B6 Avant tyre size

Popular maintenance tutorials for Audi A4 B6 Avant

More manuals for Audi A4 B6 Avant

Complete guides for changing the Brake rotors on different AUDI A4 models

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

DIY AUDI A4 Avant (8E5, B6) Brake Discs replacement - online guide
Tips & tricks for your AUDI A4 Avant (8E5, B6)
View more
  • How to change Brake rotors on AUDI A4 Avant (8E5, B6) 1.9 TDI quattro - replacement tricks
    How to Fix P0401 ✅ error code Insufficient EGR flow
    7K views
    Published on: 08/05/2025
  • Changing Brake disc Audi A4 B6 Avant 1.9 TDI - Replacement Tips
    The Ultimate Guide to Engine Bay Cleaning | AUTODOC
    6K views
    Published on: 11/09/2020
  • Maintenance Hacks - AUDI A4 Avant (8E5, B6) 2.5 TDI quattro Rotors replacement guide
    Understanding Car Tools: The Key Differences You Need to Know | AUTODOC tips
    8K views
    Published on: 16/12/2021
  • Replace Disc brakes on Audi A4 B6 Avant - free video tips
    3 essential tips for choosing summer tyres | Get ready for warmer weather
    4K views
    Published on: 18/05/2023

Most commonly replaced car parts on AUDI A4

Professional manuals for the most common AUDI models

ОЕ number
Autodoc CLUB App icon
Time to replace parts? Get even better deals in our Shop app.
AUDI A4 Avant (8E5, B6) Brake Discs replace by yourself - Scan QR-code and download AUTODOC CLUB app
SCAN ME