
Disclaimer
How to change front brake pads on AUDI A4 Avant (8K5, B8) – replacement guide
downloads:
7
Views:
140

Recommended replacement interval for the part category Brake pad set : 30000 km
Important!
This replacement procedure can be used for:
AUDI A4 Avant (8K5, B8) 3.0 TFSI quattro, AUDI A4 Avant (8K5, B8) 3.0 TDI quattro, AUDI A4 Avant (8K5, B8) 3.0 TDI, AUDI A4 Avant (8K5, B8) 3.2 FSI quattro, AUDI A4 Avant (8K5, B8) 3.0 TDI quattro, AUDI A4 Avant (8K5, B8) 2.7 TDI, AUDI A4 Avant (8K5, B8) 2.0 TFSI, AUDI A4 Avant (8K5, B8) 2.0 TFSI, AUDI A4 Avant (8K5, B8) 2.0 TFSI quattro, AUDI A4 Avant (8K5, B8) S4 quattro, AUDI A4 Avant (8K5, B8) 2.7 TDI, AUDI A4 Avant (8K5, B8) 3.2 FSI, AUDI A4 Avant (8K5, B8) 2.0 TFSI flexible fuel, AUDI A4 Avant (8K5, B8) 2.0 TFSI flexible fuel quattro, AUDI A4 Avant (8K5, B8) 3.0 TDI quattro, AUDI A4 Avant (8K5, B8) 2.0 TFSI, AUDI A4 Avant (8K5, B8) 2.0 TFSI quattro … View more
The steps may slightly vary depending on the car design.
AUDI A4 Avant (8K5, B8) 3.0 TFSI quattro, AUDI A4 Avant (8K5, B8) 3.0 TDI quattro, AUDI A4 Avant (8K5, B8) 3.0 TDI, AUDI A4 Avant (8K5, B8) 3.2 FSI quattro, AUDI A4 Avant (8K5, B8) 3.0 TDI quattro, AUDI A4 Avant (8K5, B8) 2.7 TDI, AUDI A4 Avant (8K5, B8) 2.0 TFSI, AUDI A4 Avant (8K5, B8) 2.0 TFSI, AUDI A4 Avant (8K5, B8) 2.0 TFSI quattro, AUDI A4 Avant (8K5, B8) S4 quattro, AUDI A4 Avant (8K5, B8) 2.7 TDI, AUDI A4 Avant (8K5, B8) 3.2 FSI, AUDI A4 Avant (8K5, B8) 2.0 TFSI flexible fuel, AUDI A4 Avant (8K5, B8) 2.0 TFSI flexible fuel quattro, AUDI A4 Avant (8K5, B8) 3.0 TDI quattro, AUDI A4 Avant (8K5, B8) 2.0 TFSI, AUDI A4 Avant (8K5, B8) 2.0 TFSI quattro … View more
The steps may slightly vary depending on the car design.
This video shows the replacement procedure of a similar car part on another vehicle
All the parts you need to replace – Brake Pads for A4 Avant (8K5, B8) and other AUDI models
Brake pad set
Alternative products

Wire brush
Nylon cleaning brush
WD-40 spray
Brake cleaner
Anti-squeal paste
Copper grease
Drive socket # 13
Wheel impact socket #17
Ratchet wrench
Torque wrench
Brake caliper wind back tool
Flat Screwdriver
Crow bar
Wheel chock
Replacement: brake pads – AUDI A4 Avant (8K5, B8). AUTODOC experts recommend:
- Perform the replacement of brake pads in complete set for each axis. This provides effective braking.
- The replacement procedure is identical for all brake pads on the same axle.
- All work should be done with the engine stopped.
Replacement: brake pads – AUDI A4 Avant (8K5, B8). Use the following procedure:
- Step 1Open the bonnet. Unscrew the brake fluid reservoir cap.Step 2Secure the wheels with chocks.
- Step 3Loosen the wheel mounting bolts. Use wheel impact socket #17.
- Step 4Raise the front of the car and secure on supports.Step 5Unscrew the wheel bolts.AUTODOC recommends:Important! Hold the wheel while unscrewing the fastening bolts. AUDI A4 Avant (8K5, B8)
- Step 6Remove the wheel.
- Step 7Clean the brake caliper fasteners. Use a wire brush. Use WD-40 spray.
- Step 8Unscrew the brake caliper fastening. Use a drive socket #13. Use a ratchet wrench.
- Step 9Spread the brake pads. Use a crowbar.
- Step 10Detach the brake caliper retaining spring. Use a crowbar. Use a flat screwdriver.
- Step 11Remove the brake caliper.Replacement: brake pads – AUDI A4 Avant (8K5, B8). AUTODOC recommends:Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
- Step 12Remove the brake pads.Replacement: brake pads – AUDI A4 Avant (8K5, B8). Tip:Measure the brake disc thickness. Upon reaching the wear limit the part must be replaced.
- Step 13Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.AUTODOC recommends:Replacement: brake pads – AUDI A4 Avant (8K5, B8). After applying the spray, wait a few minutes.
- Step 14Treat the brake caliper piston. Use a nylon cleaning brush. Use a brake cleaner.Replacement: brake pads – AUDI A4 Avant (8K5, B8). Tip from AUTODOC:After applying the spray, wait a few minutes.
- Step 15Press in the brake caliper piston. Use brake caliper wind back tool.
- Step 16Treat the brake pads in the area where their surface comes into contact with the brake caliper bracket. Use anti-squeal paste.Replacement: brake pads – AUDI A4 Avant (8K5, B8). Tip from AUTODOC experts:Make sure the disc surface is clean before installing the pads.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
Users voted – 0
Need New Tyres?
Find out which tyre and wheel sizes are compatible with the AUDI A4 B8 Avant (8K5) model
Popular maintenance tutorials for Audi A4 B8 Avant
Complete guides for changing the Brake pad set on different AUDI A4 models
Unlock your car maintenance assistant!
Track expenses, manage logs, schedule replacements, and more.
Tips & tricks for your AUDI A4 Avant (8K5, B8)
View more
- Kolbenschmidt plastic gauge overview
- Top 5 car noises you shouldn't ignore
- How to fix your car with AUTODOC CLUB
- Deep interior cleaning | Car transformation by detailing
Most commonly replaced car parts on AUDI A4
Time to replace parts? Get even better deals in our Shop app.

SCAN ME