How to change spark plugs on VW Bora Saloon (1J2) – replacement guide
downloads:
1
Views:
14
0
Users voted – 0
Recommended replacement interval for the part category Spark plug : 4year / 60000km
Important!
This replacement procedure can be used for:
VW Bora Saloon (1J2) 2.0 4motion,
VW Bora Saloon (1J2) 1.6,
VW Bora Saloon (1J2) 1.6 16V,
VW Bora Saloon (1J2) 1.8 4motion,
VW Bora Saloon (1J2) 1.4 16V,
VW Bora Saloon (1J2) 1.8,
VW Bora Saloon (1J2) 2.0,
VW Bora Saloon (1J2) 1.6
…
View more
The steps may slightly vary depending on the car design.
This video shows the replacement procedure of a similar car part on another vehicle
All the parts you need to replace – Spark Plug for Bora Saloon (1J2) and other VW models
Replacement: spark plugs – VW BORA (1J2). AUTODOC experts recommend:
Follow the terms, recommendations and requirements of the part operation provided by the manufacturer.
All work should be done with the engine stopped.
Replacement: spark plugs – VW BORA (1J2). Use the following procedure:
Step 1
Open the hood.
Step 2
Use a fender protection cover to prevent damaging paintwork and plastic parts of the car.
Step 3
Detach the crankcase ventilation hose from the engine cover at the left.
Step 4
Remove the engine cover.
Step 5
Cover the throttle body with a microfibre towel to prevent dust and dirt from getting into the system.
Step 6
Detach the crankcase ventilation hose from the oil filler neck.
Step 7
Unscrew the oil filler neck. Remove the oil filler neck.
Step 8
Cover the oil filler opening with a microfibre towel to prevent dirt and foreign objects from getting into the system.
Step 9
Pry up the ignition coil. Use a crowbar. Use a flat screwdriver.
Step 10
Undo the plastic locking tabs of the ignition coil connector. Use a flat screwdriver.
Step 11
Take out the ignition coil from the spark plug well.
Replacement: spark plugs – VW BORA (1J2). AUTODOC experts recommend:
Remember the sequence of steps for ignition coil demounting.
Step 12
Clean dirt, dust and debris from inside the spark plug wells.
Step 13
Unscrew the spark plugs. Use the spark plug socket #16. Use a ratchet wrench.
Step 14
Take out the spark plugs. Use a telescoping magnet.
Step 15
Apply a thin layer of a special high temperature anti-seize lubricant to the threads of the new spark plugs. Treat the surface of the terminals of the new spark plugs. Use electronic spray.
Step 16
Install the new spark plugs into their mounting seats.
Step 17
Screw new spark plugs and tighten them. Use the spark plug socket #16. Use a torque wrench. Tighten it to 25 nm torque.
Replacement: spark plugs – VW BORA (1J2). AUTODOC recommends:
Be careful when working with a spark plug wrench. Its skewing can cause damage to the threaded connection.Don't tighten the plugs with excessive force. Exceeding tightening torque can damage the thread connection.
Step 18
Install the ignition coils to the spark plug wells. Make sure you hear a click indicating that it is locked in place.
AUTODOC recommends:
Replacement: spark plugs – VW BORA (1J2). Follow the installation steps.
Step 19
Lock the connector.
Step 20
Remove the microfibre towel from the oil filler opening.
Step 21
Install the oil filler neck. Screw in the oil filler neck.
Step 22
Attach the crankcase ventilation hose to the oil filler neck.
Step 23
Remove the microfibre towel from the throttle body.
Step 24
Install the engine cover and secure it. Make sure you hear a click indicating that it is locked in place.
Replacement: spark plugs – VW BORA (1J2). Tip:
Make sure the engine cover is properly seated. It should not be displaced with respect to the guiding fasteners and the throttle body air intake hose.
Step 25
Attach the crankcase ventilation hose to the engine cover at the left.
Step 26
Run the engine for a few minutes. This is necessary in order to make sure that the component operates properly.
Step 27
Shut off the engine.
Step 28
Remove the fender protection cover.
Step 29
Close the hood.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents
Install the AUTODOC CLUB app!
Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.
Scan
To download the app:
- scan the QR code
- download from App Store
- download from Google Play
Tips & tricks for your VW Bora Saloon (1J2)
View more
Top 5 mistakes when replacing spark plugs | AUTODOC tips