Recommended replacement interval for the part category Spark plug : 90000 km

Important!

This replacement procedure can be used for:
TOYOTA PRIUS (_W5_) 1.8 Hybrid (ZVW50_, ZVW51_), TOYOTA PRIUS (_W5_) 1.8 Hybrid (ZVW50, ZVW50_, ZVW51_) … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Spark Plug for PRIUS (_W5_) and other TOYOTA models

Spark plug

Spark plug for Prius IV Liftback (XW50) Petrol/Electro (98 hp)

Simple DIY car repair steps – Replacing Spark plug on Prius IV Liftback (XW50)

Spark plug for Prius IV Liftback (XW50) Petrol/Electro (122 hp)

Replacement: spark plugs – TOYOTA PRIUS (_W5_). Tools you might need:

                        Electronic spray
                      
                        High-temperature anti-seize lubricant
                      
                        Drive socket # 10 
                      
                        Spark plug socket # 16
                      
                        Ratchet wrench
                      
                        Torque wrench
                      
                        Fender cover

Buy tools

Replacement: spark plugs – TOYOTA PRIUS (_W5_). Tip from AUTODOC:

The replacement procedure is the same for all spark plugs.
All work should be done with the engine stopped.

Replacement: spark plugs – TOYOTA PRIUS (_W5_). Take the following steps:

Step 1

Open the hood.

Step 2

Use a fender protection cover to prevent damaging paintwork and plastic parts of the car.

Step 3

Unscrew the engine cover fastener. Use a drive socket #10. Use a ratchet wrench.
Step 4

Remove the engine cover.
Step 5

Unplug the connectors from the ignition coils.
Step 6

Unscrew the ignition coil bracket. Use a drive socket #10.
Step 7

Remove the fastening bolts.
Step 8

Take out the ignition coil from the spark plug well.

Replacement: spark plugs – TOYOTA PRIUS (_W5_). Tip:
Remember the sequence of steps for ignition coil demounting.
Step 9

Clean dirt, dust and debris from inside the spark plug wells.
Step 10

Unscrew the spark plugs. Use the spark plug socket #16. Use a ratchet wrench.
Step 11

Take out the spark plugs.
Step 12

Apply a thin layer of a special high temperature anti-seize lubricant to the threads of the new spark plugs. Treat the surface of the terminals of the new spark plugs. Use high-temperature grease.
Step 13

Install the new spark plugs into their mounting seats.
Step 14

Screw new spark plugs and tighten them. Use the spark plug socket #16. Use a torque wrench. Tighten it to 25 nm torque.

Replacement: spark plugs – TOYOTA PRIUS (_W5_). Tip from AUTODOC experts:
Don't tighten the plugs with excessive force. Exceeding tightening torque can damage the thread connection. Be careful when working with a spark plug wrench. Its skewing can cause damage to the threaded connection.
Step 15

Install the ignition coils to the spark plug wells. Make sure you hear a click indicating that it is locked in place.

AUTODOC recommends:
Replacement: spark plugs – TOYOTA PRIUS (_W5_). Follow the installation steps.
Step 16

Install the fastening bolts.
Step 17

Tighten the fasteners of the ignition coils. Use a drive socket #10. Use a torque wrench. Tighten it to 8 nm torque.
Step 18

Treat the ignition coil connector with electronic spray. The spray will protect the electrical contacts from corrosion, oxidation, and will reduce the contact resistance.
Step 19

Plug in the connectors of the ignition coils. Make sure you hear a click indicating that it is locked in place.
Step 20

Install the engine cover and secure it.
Step 21

Screw in the engine cover fasteners. Use a drive socket #10. Use a ratchet wrench.

AUTODOC recommends:
Make sure the engine cover is properly seated. It should not be displaced with respect to the guiding fasteners.Replacement: spark plugs – TOYOTA PRIUS (_W5_). Do not use excessive force during installation. This may damage the fasteners.
Step 22

Run the engine for a few minutes. This is necessary in order to make sure that the component operates properly.

Step 23

Shut off the engine.

Step 24

Remove the fender protection cover.

Step 25

Close the hood.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Searching for the right tyres?

Find out which tyre and wheel sizes are compatible with the TOYOTA Prius IV Liftback (XW50) model.

Browse tyres

How to change rear brake pads on TOYOTA PRIUS (_W5_) – replacement guide

Free download PDF
1.41 MB
How to change front windshield wipers on TOYOTA PRIUS (_W5_) – replacement guide

Free download PDF
542.72 KB
How to change engine oil and filter on TOYOTA Prius IV Liftback (XW50) – replacement guide

Free download PDF
2.04 MB
How to change pollen filter on TOYOTA PRIUS (_W5_) – replacement guide

Free download PDF
655.36 KB
How to change engine oil and filter on Toyota Aygo AB1 – replacement guide

Free download PDF
2.32 MB
How to change rear brake shoes on Toyota Yaris P1 – replacement guide

Free download PDF
2.32 MB

How to change spark plugs on TOYOTA PRIUS PLUS (ZVW4_) – replacement guide

Free download PDF
1.06 MB
How to change spark plugs on Toyota Prius 2 – replacement guide

Free download PDF
1.91 MB
How to change spark plugs on TOYOTA PRIUS Saloon (NHW11_) – replacement guide

Free download PDF
1.68 MB
How to change spark plugs on TOYOTA PRIUS Saloon (_W1_) – replacement guide

Free download PDF
1.68 MB
How to change spark plugs on a car – replacement tutorial

Universal

Free download PDF
1.74 MB
How to change spark plugs on Toyota Auris E15 – replacement guide

Free download PDF
1.31 MB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

TOP 5 mistakes when replacing shock absorbers | AUTODOC tips

8K views

Published on: 15/06/2023
3 things to know before buying summer tyres | AUTODOC tips

3K views

Published on: 18/05/2023
3 things that cause engine damage | AUTODOC tips

9K views

Published on: 07/10/2021
Top 5 mistakes when replacing spark plugs | AUTODOC tips

9K views

Published on: 13/07/2023