Recommended replacement interval for the part category Brake pad set : 30000 km

Important!

This replacement procedure can be used for:
TOYOTA HILUX Pickup (GUN1_) 2.4 D (GUN112_, GUN122_, GUN135_, GUN120_), TOYOTA HILUX Pickup (GUN1_) 2.4 D 4WD (GUN125_), TOYOTA HILUX Pickup (GUN1_) 2.7 (TGN111_, TGN121_, TGN136_), TOYOTA HILUX Pickup (GUN1_) 2.8 D 4WD (GUN126_), TOYOTA HILUX Pickup (GUN1_) 2.7 4WD (TGN126_), TOYOTA HILUX Pickup (GUN1_) 2.5 D 4WD (KUN125_), TOYOTA HILUX Pickup (GUN1_) 2.7 4WD (TGN126_), TOYOTA HILUX Pickup (GUN1_) 2.4 D (GUN112_, GUN122_, GUN135_), TOYOTA HILUX Pickup (GUN1_) 2.8 D 4WD (GUN126_), TOYOTA HILUX Pickup (GUN1_) 2.4 D 4WD (GUN125_), TOYOTA HILUX Pickup (GUN1_) 2.7 (TGN111_, TGN121_, TGN136_, TGN138_), TOYOTA HILUX Pickup (GUN1_) 2.5 D 4WD (KUN125_), TOYOTA HILUX Pickup (GUN1_) 2.5 D 4WD (KUN125_) … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Brake Pads for HILUX Pickup (GUN1_) and other TOYOTA models

Alternative products

Brake pad set

Replacement: brake pads – TOYOTA HILUX Pickup (GUN1_). Tools you need:

                      Wire brush
                    
                      Brake cleaner 
                    
                      Copper grease 
                    
                      Anti-squeal paste
                    
                      Wheel impact socket #21
                    
                      Torque wrench
                    
                      Flat Screwdriver
                    
                      Pin punch
                    
                      Rubber mallet
                    
                      Crow bar
                    
                      Wheel chock

Buy tools

Replacement: brake pads – TOYOTA HILUX Pickup (GUN1_). Tip from AUTODOC experts:

Perform the replacement of brake pads in complete set for each axis. This provides effective braking.
The replacement procedure is identical for all brake pads on the same axle.
All work should be done with the engine stopped.

Replacement: brake pads – TOYOTA HILUX Pickup (GUN1_). Take the following steps:

Step 1

Open the bonnet. Unscrew the brake fluid reservoir cap.

Step 2

Secure the wheels with chocks.
Step 3

Loosen the wheel mounting bolts. Use wheel impact socket #21.
Step 4

Raise the front of the car and secure on supports.

Step 5

Unscrew the wheel bolts.

Replacement: brake pads – TOYOTA HILUX Pickup (GUN1_). AUTODOC recommends:
To avoid injury, hold up the wheel when unscrewing the bolts.
Step 6

Remove the wheel.
Step 7

Clean the brake pads fasteners. Use a wire brush. Use a brake cleaner.

AUTODOC recommends:
Replacement: brake pads – TOYOTA HILUX Pickup (GUN1_). After applying the spray, wait a few minutes.
Step 8

Remove the brake pads retaining clips. Use a crowbar. Use a flat screwdriver.
Step 9

Remove the retainer of the brake pads. Use a pin punch. Use a rubber mallet.
Step 10

Remove the retaining spring of the brake pads.
Step 11

Spread the brake pads. Use a crowbar.
Step 12

Remove the brake pads.

Replacement: brake pads – TOYOTA HILUX Pickup (GUN1_). AUTODOC experts recommend:
Measure the brake disc thickness. Upon reaching the wear limit the part must be replaced.
Step 13

Clean the brake caliper surface. Use a wire brush. Use a brake cleaner.

Replacement: brake pads – TOYOTA HILUX Pickup (GUN1_). Tip:
After applying the spray, wait a few minutes.
Step 14

Treat the brake pads in the area where their surface comes into contact with the brake caliper bracket. Use anti-squeal paste.

Replacement: brake pads – TOYOTA HILUX Pickup (GUN1_). Professionals recommend:
Make sure the disc surface is clean before installing the pads.
Step 15

Install new brake pads.

Replacement: brake pads – TOYOTA HILUX Pickup (GUN1_). AUTODOC recommends:
Make sure the pads are installed with linings facing the disc.
Step 16

Install the retainer of the brake pads. Use a crowbar.
Step 17

Install the retaining spring of the brake pads.
Step 18

Install the brake pads retaining clips.
Step 19

Treat the surface where the brake disc contacts the wheel rim. Use copper grease.
Step 20

Clean the brake disk surface. Use a brake cleaner.

AUTODOC recommends:
Replacement: brake pads – TOYOTA HILUX Pickup (GUN1_). After applying the spray, wait a few minutes.
Step 21

Install the wheel.

Replacement: brake pads – TOYOTA HILUX Pickup (GUN1_). Tip from AUTODOC experts:
To avoid injury, hold up the wheel when screwing in the fastening bolts.
Step 22

Screw in the wheel bolts. Use wheel impact socket #21.
Step 23

Lower the car and working in a cross order, tighten the wheel bolts. Use a torque wrench. Tighten it to 112 Nm torque.
Step 24

Remove the jacks and chocks.

AUTODOC recommends:
Important! Replacement: brake pads – TOYOTA HILUX Pickup (GUN1_). Check the brake fluid level in the reservoir and top up if necessary.
Step 25

Tighten the brake fluid reservoir cap.

AUTODOC recommends:
TOYOTA HILUX Pickup (GUN1_) – Press the brake pedal several times with the engine shut down until you feel the resistance built up.
Step 26

Close the hood.

Replacement: brake pads – TOYOTA HILUX Pickup (GUN1_). AUTODOC experts recommend:
Slow down smoothly for first 150-200 km after the brake pads replacement. Avoid unneccessary and sharp braking to a stop.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Need New Tyres?

Find out which tyre and wheel sizes are compatible with the TOYOTA Hilux VIII Pickup model

Toyota Hilux Mk8 tyre size

How to change front windshield wipers on TOYOTA HILUX Pickup (GUN1_) – replacement guide

Free download PDF
706.56 KB
How to change rear windshield wipers on TOYOTA HILUX Pickup (GUN1_) – replacement guide

Free download PDF
542.72 KB
How to change front anti roll bar links on TOYOTA HILUX Pickup (GUN1_) – replacement guide

Free download PDF
1.66 MB
How to change pollen filter on TOYOTA HILUX Pickup (GUN1_) – replacement guide

Free download PDF
665.6 KB
How to change engine oil and filter on Toyota Aygo AB1 – replacement guide

Free download PDF
2.32 MB
How to change rear brake shoes on Toyota Yaris P1 – replacement guide

Free download PDF
2.32 MB

How to change front brake pads on TOYOTA HILUX III Pickup (TGN1_, GGN2_, GGN1_, KUN2_, KUN1_) – replacement guide

Free download PDF
1.84 MB
How to change rear brake pads on TOYOTA HILUX III Pickup (TGN1_, GGN2_, GGN1_, KUN2_, KUN1_) – replacement guide

Free download PDF
1.7 MB
How to change front brake pads on TOYOTA HILUX III Platform/Chassis (KUN1_, TGN3_, TGN2_, TGN1_, KUN2 – replacement guide

Free download PDF
1.83 MB
How to change front brake pads on TOYOTA HILUX VIII Platform/Chassis (_N1_) – replacement guide

Free download PDF
1.83 MB
How to change brake pads on a car – replacement tutorial

Universal

Free download PDF
2.84 MB
How to change front brake pads on Toyota Prado J120 – replacement guide

Free download PDF
2.08 MB

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

#DIY Guide: How to Fix a Cracked Windscreen Without a Garage Visit

8K views

Published on: 14/12/2023
Reviving Your Car: How to Start After Extended Idle Time | AUTODOC Tips

7K views

Published on: 20/05/2021
How to restore a steering wheel | AUTODOC tips

57K views

Published on: 17/02/2022
DIY jack restoration | AUTODOC tips

20K views

Published on: 22/09/2022