Recommended replacement interval for the part category Brake pad set : 30000 km

Important!

This replacement procedure can be used for:
TOYOTA Fortuner (_N15_, _N16_) 2.8 D 4x4 (GUN156), TOYOTA Fortuner (_N15_, _N16_) 2.7 4x4 (TGN156_), TOYOTA Fortuner (_N15_, _N16_) 2.4 D (GUN165_), TOYOTA Fortuner (_N15_, _N16_) 2.8 D 4x4 (GUN156_), TOYOTA Fortuner (_N15_, _N16_) 4.0 4x4 (GGN155_), TOYOTA Fortuner (_N15_, _N16_) 2.7 4x4 (TGN156_), TOYOTA Fortuner (_N15_, _N16_) 2.7 (TGN166_, TGN168_) … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Brake Pads for Fortuner (_N15_, _N16_) and other TOYOTA models

Brake pad set

        Brake pad set for Fortuner II (AN150, AN160) Diesel (177 hp)
      
        Brake pad set for Fortuner II (AN150, AN160) Petrol (163 hp)
      
        Brake pad set for Fortuner II (AN150, AN160) Petrol (164 hp)
      
        Brake pad set for Fortuner II (AN150, AN160) Petrol (235 hp)
      
        Brake pad set for Fortuner II (AN150, AN160) Diesel (174 hp)
      
        Brake pad set for Fortuner II (AN150, AN160) Diesel (147 hp)
      
        Brake pad set for Fortuner II (AN150, AN160) Petrol (163 hp)

Replacement: brake pads – TOYOTA FORTUNER. List of the tools you'll need:

                        Wire brush
                      
                        WD-40 spray
                      
                        Brake cleaner 
                      
                        Copper grease 
                      
                        Anti-squeal paste
                      
                        Drive socket # 17 
                      
                        Wheel impact socket #21
                      
                        Brake caliper wind back tool
                      
                        Torque wrench
                      
                        Tap wrench
                      
                        Crow bar
                      
                        Wheel chock

Buy tools

Replacement: brake pads – TOYOTA FORTUNER. AUTODOC experts recommend:

Perform the replacement of brake pads in complete set for each axis. This provides effective braking.
The replacement procedure is identical for all brake pads on the same axle.
All work should be done with the engine stopped.

Replacement: brake pads – TOYOTA FORTUNER. Use the following procedure:

Step 1

Open the bonnet. Unscrew the brake fluid reservoir cap.

Step 2

Secure the wheels with chocks.
Step 3

Loosen the wheel mounting bolts. Use wheel impact socket #21.
Step 4

Raise the rear of the car and secure on supports.

Step 5

Unscrew the wheel bolts.

AUTODOC recommends:
Important! Hold the wheel while unscrewing the fastening bolts. TOYOTA FORTUNER
Step 6

Remove the wheel.
Step 7

Clean the brake caliper fasteners. Use a wire brush. Use WD-40 spray.
Step 8

Spread the brake pads. Use a crowbar.
Step 9

Unscrew the brake caliper fastening. Use a drive socket #17. Use a tap wrench.
Step 10

Remove the brake caliper.

Replacement: brake pads – TOYOTA FORTUNER. AUTODOC recommends:
Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
Step 11

Remove the brake pads. Use a crowbar.

Replacement: brake pads – TOYOTA FORTUNER. Tip from AUTODOC:
Measure the brake disc thickness. Upon reaching the wear limit the part must be replaced.
Step 12

Remove the retaining springs of the brake pads.

Step 13

Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.

Replacement: brake pads – TOYOTA FORTUNER. Professionals recommend:
After applying the spray, wait a few minutes.
Step 14

Install the retaining springs of the brake pads.
Step 15

Treat the brake caliper piston. Use a wire brush. Use a brake cleaner.

AUTODOC recommends:
Replacement: brake pads – TOYOTA FORTUNER. After applying the spray, wait a few minutes.
Step 16

Press in the brake caliper piston. Use brake caliper wind back tool.
Step 17

Treat the brake pads in the area where their surface comes into contact with the brake caliper bracket. Use anti-squeal paste.

Replacement: brake pads – TOYOTA FORTUNER. Tip:
Make sure the disc surface is clean before installing the pads.
Step 18

Install new brake pads.

Replacement: brake pads – TOYOTA FORTUNER. Tip from AUTODOC experts:
Make sure the pads are installed with linings facing the disc.
Step 19

Install the brake caliper and fix it. Use a drive socket #17. Use a torque wrench. Tighten it to 88 Nm torque.
Step 20

Treat the surface where the brake disc contacts the wheel rim. Use copper grease.
Step 21

Clean the brake disk surface. Use a brake cleaner.

AUTODOC recommends:
Replacement: brake pads – TOYOTA FORTUNER. After applying the spray, wait a few minutes.
Step 22

Install the wheel.

Replacement: brake pads – TOYOTA FORTUNER. AUTODOC experts recommend:
To avoid injury, hold up the wheel when screwing in the fastening bolts.
Step 23

Screw in the wheel bolts. Use wheel impact socket #21.
Step 24

Lower the car and working in a cross order, tighten the wheel bolts. Use a torque wrench. Tighten it to 112 Nm torque.
Step 25

Remove the jacks and chocks.

Replacement: brake pads – TOYOTA FORTUNER. AUTODOC experts recommend:
Check the brake fluid level in the expansion tank and refill if necessary.
Step 26

Tighten the brake fluid reservoir cap.

AUTODOC recommends:
TOYOTA FORTUNER – Without starting the engine, press the brake pedal several times until it feels firm.
Step 27

Close the hood.

Replacement: brake pads – TOYOTA FORTUNER. Tip from AUTODOC:
Slow down smoothly for first 150-200 km after the brake pads replacement. Avoid unneccessary and sharp braking to a stop.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Searching for the right tyres?

Find out which tyre and wheel sizes are compatible with the TOYOTA Fortuner II (AN150, AN160) model.

Browse tyres

How to change front brake discs on TOYOTA Fortuner (_N15_, _N16_) – replacement guide

Free download PDF
2.55 MB
How to change rear windshield wipers on TOYOTA Fortuner (_N15_, _N16_) – replacement guide

Free download PDF
542.72 KB
How to change pollen filter on TOYOTA Fortuner (_N15_, _N16_) – replacement guide

Free download PDF
655.36 KB
How to change engine oil and filter on Toyota Aygo AB1 – replacement guide

Free download PDF
2.32 MB
How to change rear brake shoes on Toyota Yaris P1 – replacement guide

Free download PDF
2.32 MB
How to change serpentine belt on Toyota Aygo AB1 – replacement guide

Free download PDF
2.36 MB

How to change front brake pads on TOYOTA FORTUNER Closed Off-Road Vehicle (TGN6_, KUN6_, GGN6_, TGN5_ – replacement guide

Free download PDF
1.84 MB
How to change brake pads on a car – replacement tutorial

Universal

Free download PDF
2.84 MB
How to change front brake pads on Toyota Prado J120 – replacement guide

Free download PDF
2.08 MB
How to change rear brake pads on Toyota Auris E15 – replacement guide

Free download PDF
1.53 MB
How to change rear brake pads on Toyota RAV4 III – replacement guide

Free download PDF
1.96 MB
How to change front brake pads on Toyota Aygo AB1 – replacement guide

Free download PDF
2.47 MB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

3 things to know before buying summer tyres | AUTODOC tips

3K views

Published on: 18/05/2023
How to remove rust | AUTODOC tips

25K views

Published on: 16/09/2021
5 car tips for a winter's day | AUTODOC tips

5K views

Published on: 05/02/2024
Causes of a worn car boot damper | AUTODOC

3K views

Published on: 04/07/2021