How to carry out replacement: Brake Pads 4.2 TDI quattro Audi A8 D4
Disclaimer
Change Audi A8 D4 S8 4.0 quattro Brake Pads yourself – manuals and video tutorials

How to change rear brake pads on AUDI A8 (4H2, 4H8, 4HC, 4HL) – replacement guide

downloads: 30
Views: 376
Download your free tutorial and fix AUDI A8 (4H2, 4H8, 4HC, 4HL) 3.0 TDI quattro problems yourself Download for free 1.64 MB Brake Pads for Audi A8 D4 Shop now
Leave a comment Open in a new tab
When to replace the Brake Pads on your AUDI A8
Recommended replacement interval for the part category Brake pad set : 30000 km
Important!
This replacement procedure can be used for:
AUDI A8 (4H2, 4H8, 4HC, 4HL) 4.2 TDI quattro, AUDI A8 (4H2, 4H8, 4HC, 4HL) 3.0 TDI quattro, AUDI A8 (4H2, 4H8, 4HC, 4HL) 4.2 FSI quattro … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Brake Pads for A8 (4H2, 4H8, 4HC, 4HL) and other AUDI models
Alternative products
How to change Brake pad set on Audi A8 D4 4.2 TDI quattro – step-by-step instructions for straightforward car repair Brake pad set
Tools
Replacement: brake pads – AUDI A8 (4H_). List of the tools you'll need:
Wire brush
Nylon cleaning brush
WD-40 spray
Brake cleaner
Anti-squeal paste
Ceramic grease
Copper grease
Torque wrench
Drive socket # 12
Wheel impact socket #19
Ratchet wrench
Brake caliper wind back tool
Crow bar
Wheel chock
Buy tools
Replacement: brake pads – AUDI A8 (4H_). Professionals recommend:
  • Perform the replacement of brake pads in complete set for each axis. This provides effective braking.
  • The replacement procedure is identical for all brake pads on the same axle.
  • All work should be done with the engine stopped.
Replacement: brake pads – AUDI A8 (4H_). Take the following steps:
  1. Step 1
    Open the bonnet. Unscrew the brake fluid reservoir cap.
    Step 2
    How to change Brake Pads on Audi A8 D4 2009 - free PDF and video manuals
    Secure the wheels with chocks.
  2. Step 3
    How to replace AUDI A8 (4H2, 4H8, 4HC, 4HL) 4.2 TDI quattro 2010 Brake Pads - step-by-step manuals and video guides
    Loosen the wheel mounting bolts. Use wheel impact socket #19.
  3. Step 4
    Raise the rear of the car and secure on supports.
    Step 5
    Audi A8 D4 3.0 TDI quattro 2011 Brake Pads replacement: free workshop manuals
    Unscrew the wheel bolts.
    AUTODOC recommends:
    Warning! To avoid injury, hold the wheel while unscrewing the fastening bolts. AUDI A8 (4H_)
  4. Step 6
    Changing Brake Pads on AUDI A8 (4H2, 4H8, 4HC, 4HL) 4.2 FSI quattro 2012 by yourself
    Remove the wheel.
  5. Step 7
    How to remove AUDI A8 6.3 W12 quattro 2013 Brake Pads - online easy-to-follow instructions
    Clean the brake caliper fasteners. Use a wire brush. Use WD-40 spray.
  6. Step 8
    How to replace Brake Pads on AUDI A8 (4H2, 4H8, 4HC, 4HL) 2014: download PDF manuals and video instructions
    Unscrew the brake caliper fasteners. Use a drive socket #12. Use a ratchet wrench.
  7. Step 9
    How hard is it to do yourself: Brake Pads replacement on Audi A8 D4 4.2 TDI quattro 2015 - download illustrated guide
    Spread the brake pads. Use a crowbar.
  8. Step 10
    Need to know how to renew Brake Pads on AUDI A8 2016? This free workshop manual will help you to do it yourself
    Remove the brake caliper. Use a crowbar.
    Replacement: brake pads – AUDI A8 (4H_). AUTODOC recommends:
    Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
  9. Step 11
    Changing of Brake Pads on Audi A8 D4 2017 won't be an issue if you follow this illustrated step-by-step guide
    Detach the connector of the brake pad wear sensor. Use a crowbar.
  10. Step 12
    AUDI A8 S8 4.0 quattro Brake Pads replacement: online guides and video tutorials
    Remove the brake pads. Use a crowbar.
    Replacement: brake pads – AUDI A8 (4H_). Tip:
    Measure the brake disc thickness. Upon reaching the wear limit the part must be replaced.
  11. Step 13
    Remove the brake pad wear sensor from the brake pad. Use a crowbar.
    Step 14
    Replacing Brake Pads on Audi A8 D4 2009 4.2 TDI quattro by yourself
    Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.
    AUTODOC recommends:
    Replacement: brake pads – AUDI A8 (4H_). After applying the spray, wait a few minutes.
  12. Step 15
    A8 (4H2, 4H8, 4HC, 4HL) 6.3 W12 quattro 2010 Brake Pads DIY replacement workshop manual
    Install the wear sensor on the brake pads.
  13. Step 16
    How to change Brake Pads on AUDI A8 (4H2, 4H8, 4HC, 4HL) 2011 - tips and tricks
    Treat the brake pads in the area where their surface comes into contact with the brake caliper bracket. Use anti-squeal paste.
    Replacement: brake pads – AUDI A8 (4H_). AUTODOC experts recommend:
    Make sure the disc surface is clean before installing the pads.
  14. Step 17
    Step-by-step recommendations for DIY replacement Audi A8 D4 2012 6.3 W12 quattro Brake Pads
    Install new brake pads.
    Replacement: brake pads – AUDI A8 (4H_). AUTODOC recommends:
    Make sure the pads are installed with linings facing the disc.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
Users voted – 0
Need New Tyres?

Find out which tyre and wheel sizes are compatible with the AUDI A8 D4 (4H2, 4H8, 4HC, 4HL) model

Audi A8 D4 tyre size

Popular maintenance tutorials for Audi A8 D4

More manuals for Audi A8 D4

Complete guides for changing the Brake pad set on different AUDI A8 models

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

DIY AUDI A8 (4H2, 4H8, 4HC, 4HL) Brake Pads replacement - online guide
Tips & tricks for your AUDI A8 (4H2, 4H8, 4HC, 4HL)
View more
  • How to change Brake pad set on AUDI A8 (4H2, 4H8, 4HC, 4HL) S8 4.0 quattro - replacement tricks
    Extend your engine's life: Avoid these 3 damaging factors | AUTODOC tips
    9K views
    Published on: 07/10/2021
  • Changing Disc pads Audi A8 D4 4.2 TDI quattro - Replacement Tips
    Motorcycle fuel tank restoration
    3K views
    Published on: 03/07/2025
  • Maintenance Hacks - AUDI A8 (4H2, 4H8, 4HC, 4HL) 3.0 TDI quattro Brake pad kit replacement guide
    The Fast and Easy Way to Fix a Broken Wheel Stud | AUTODOC tips
    9K views
    Published on: 08/12/2020
  • Replace Disc brake pads on Audi A8 D4 - free video tips
    Fuse Replacement Made Simple: Step-by-Step Guide | AUTODOC
    3K views
    Published on: 15/08/2020

Most commonly replaced car parts on AUDI A8

Professional manuals for the most common AUDI models

ОЕ number
Autodoc CLUB App icon
Time to replace parts? Get even better deals in our Shop app.
AUDI A8 (4H2, 4H8, 4HC, 4HL) Brake Pads replace by yourself - Scan QR-code and download AUTODOC CLUB app
SCAN ME