Recommended replacement interval for the part category Engine thermostat : 50000 km

Important!

This replacement procedure can be used for:
FORD Transit Custom V362 Minibus (F3) 2.2 TDCi, FORD Transit Custom V362 Minibus (F3) 2.2 TDCi, FORD Transit Custom V362 Minibus (F3) 2.2 TDCi … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Thermostat for Transit Custom V362 Minibus (F3) and other FORD models

Alternative products

Engine thermostat

TH26988G1 GATES Engine thermostat

10,52 GBP

Shop

V70-99-0002 VEMO Engine thermostat

11,24 GBP

Shop

8620 17588 TRISCAN Engine thermostat

12,07 GBP

Shop

23981 FEBI BILSTEIN Engine thermostat

12,46 GBP

Shop

1.880.412 EPS Engine thermostat

12,54 GBP

Shop

QTH321 QUINTON HAZELL Engine thermostat

15,33 GBP

Shop

820174 VALEO Engine thermostat

16,49 GBP

Shop

820542 VALEO Engine thermostat

19,76 GBP

Shop

3497.88D WAHLER Engine thermostat

23,94 GBP

Shop

3477.88D WAHLER Engine thermostat

29,25 GBP

Shop

Replacement: engine thermostat – FORD TRANSIT CUSTOM Bus. Tools you might need:

                      Wire brush
                    
                      All-purpose cleaning spray
                    
                      T25 Torx bit
                    
                      T30 Torx bit
                    
                      Ratchet wrench
                    
                      U-joint socket extension
                    
                      Slotted screwdriver
                    
                      Funnel
                    
                      Hose clamp pliers
                    
                      Fluid drain pan
                    
                      Paper towels
                    
                      Fender cover

Buy tools

Replacement: engine thermostat – FORD TRANSIT CUSTOM Bus. AUTODOC experts recommend:

All the work should be carried out with the engine cooled down and ignition switched off.

Replacement: engine thermostat – FORD TRANSIT CUSTOM Bus. Take the following steps:

Step 1

Open the bonnet.

Step 2

Use a fender protection cover to avoid damaging the paintwork and plastic parts of the car.

Step 3

Unscrew the coolant reservoir cap.
Step 4

Lift the vehicle using a vehicle lift or place it over an inspection pit.

Step 5

Prepare a fluid drain pan.
Step 6

Unscrew the coolant drain plug. Use a slotted screwdriver.
Step 7

Drain the coolant.

Replacement: engine thermostat – FORD TRANSIT CUSTOM Bus. AUTODOC recommends:
Wait until the coolant has completely flowed out of the drain hole.
Step 8

Screw in the coolant drain plug. Use a slotted screwdriver.
Step 9

Loosen the coolant hose clamp. Use hose clamp pliers.
Step 10

Detach the coolant hose and plug it with a paper towel.
Step 11

Clean the fasteners of the thermostat housing cover. Use a wire brush. Use an all-purpose cleaning spray.
Step 12

Unscrew the fasteners of the thermostat housing cover. Use a T25 Torx bit. Use a U-joint socket extension. Use a ratchet wrench.
Step 13

Remove the fastening bolts.
Step 14

Remove the thermostat housing cover.
Step 15

Remove the thermostat.
Step 16

Clean the mounting seat of the thermostat housing cover. Use an all-purpose cleaning spray.
Step 17

Install a new thermostat.
Step 18

Install the thermostat housing cover.
Step 19

Install the fastening bolts.
Step 20

Tighten the fasteners of the thermostat housing cover. Use a T30 Torx bit. Use a U-joint socket extension. Use a torque wrench. Tightening torque: 10 N·m.
Step 21

Remove the towel from the coolant hose and reattach it. Use hose clamp pliers.
Step 22

Remove the coolant reservoir cap.
Step 23

Insert the funnel.
Step 24

Pour coolant into the reservoir.

Warning!
Only use the coolant recommended by the manufacturer.The coolant level should be at the MAX mark on the reservoir.Wait until the air goes out of the system.
Step 25

Put the coolant reservoir cap back on and tighten it.

Step 26

Run the engine for a few minutes. This should be done in order to remove residual air from the cooling system and to check that the components are operating correctly and there are no leaks.

Step 27

Shut off the engine and let it cool down.

Step 28

Top up the coolant to the MAX mark without exceeding it.

Step 29

Remove the fender cover.

Step 30

Close the bonnet.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Searching for the right tyres?

Find out which tyre and wheel sizes are compatible with the FORD Transit Custom V362 Minibus (F3) model.

Ford Transit Custom Minibus tyre size

How to change the serpentine belt on the FORD Transit Custom V362 Minibus (F3) – replacement guide

Free download PDF
788.48 KB
How to change rear windshield wipers on FORD Transit Custom V362 Minibus (F3) – replacement guide

Free download PDF
593.92 KB
How to change the front anti-roll bar links on the FORD Transit Custom V362 Minibus (F3) – replacement guide

Free download PDF
1.45 MB
How to change engine oil and filter on FORD Transit Custom V362 Minibus (F3) – replacement guide

Free download PDF
1.47 MB
How to change tie rod ends on the FORD Transit Custom V362 Minibus (F3) – replacement guide

Free download PDF
1.57 MB
How to change water pump & timing belt kit on Ford Fiesta JA8 – replacement guide

Free download PDF
7.83 MB

How to change the engine thermostat on the FORD Transit Custom V362 Van (FY, FZ) – replacement guide

Free download PDF
1.35 MB
How to change engine thermostat on Ford Mondeo Mk3 saloon – replacement guide

Free download PDF
2.43 MB
How to change the engine thermostat on the Ford Transit Mk7 van – replacement guide

Free download PDF
1.64 MB
How to change engine thermostat on FORD MONDEO III Estate (BWY) – replacement guide

Free download PDF
2.54 MB
How to change engine thermostat on FORD MONDEO III (B5Y) – replacement guide

Free download PDF
2.56 MB
How to change the engine thermostat on the FORD Transit V363 Minibus (FAD, FBD) – replacement guide

Free download PDF
1.36 MB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

DIY brake caliper restoration | AUTODOC tips

584K views

Published on: 02/06/2022
Top 5 reasons why your car squeals | AUTODOC Tips

6K views

Published on: 26/10/2023
5 common car washing mistakes | AUTODOC tips

5K views

Published on: 23/09/2021
3 things to know before buying summer tyres | AUTODOC tips

4K views

Published on: 18/05/2023