Recommended replacement interval for the part category Spark plug : 18 month / 30000 km

Important!

This replacement procedure can be used for:
TOYOTA Carina II Estate (_T17_) 2.0 (ST171_), TOYOTA Carina II Estate (_T17_) 1.6 (AT171_), TOYOTA Carina II Estate (_T17_) 1.6 (AT171_) … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Spark Plug for Carina II Estate (_T17_) and other TOYOTA models

Alternative products

Spark plug

Replacement: spark plugs – TOYOTA CARINA II Station Wagon (_T17_). List of the tools you'll need:

                      Electronic spray
                    
                      High-temperature anti-seize lubricant
                    
                      Torque wrench
                    
                      Drive socket # 10
                    
                      Spark plug socket # 16
                    
                      Ratchet wrench
                    
                      Microfibre towel
                    
                      Fender cover

Buy tools

Replacement: spark plugs – TOYOTA CARINA II Station Wagon (_T17_). Tip from AUTODOC:

The replacement procedure is the same for all spark plugs.
Please note: all work on the car – TOYOTA CARINA II Station Wagon (_T17_) – should be done with the engine switched off.

Carry out replacement in the following order:

Step 1

Open the bonnet.

Step 2

Use a fender protection cover to prevent damaging paintwork and plastic parts of the car.

Step 3

Release the air filter cover clips.
Step 4

Disconnect the air intake pipe from the air filter housing.
Step 5

Take off the filter lid.
Step 6

Cover the air intake hose with a microfibre towel to prevent dust and dirt from getting into the system.
Step 7

Clean the ignition coils.
Step 8

Unscrew the fasteners of the wiring harness bracket. Use a drive socket #10. Use a ratchet wrench.
Step 9

Remove the fastening bolts.
Step 10

Remove the oil dipstick.
Step 11

Move the wiring harness bracket aside.
Step 12

Insert the oil dipstick.
Step 13

Unplug the connectors from the ignition coils.
Step 14

Unscrew the fasteners of the ignition coils. Use a drive socket #10. Use a ratchet wrench.
Step 15

Remove the fastening bolts.
Step 16

Take out the ignition coils from the spark plug wells.

Replacement: spark plugs – TOYOTA CARINA II Station Wagon (_T17_). Professionals recommend:
Remember the sequence of steps for ignition coil demounting.
Step 17

Clean dirt, dust and debris from inside the spark plug wells.
Step 18

Unscrew the spark plugs. Use the spark plug socket #16. Use a ratchet wrench.
Step 19

Take out the spark plugs.
Step 20

Apply a thin layer of a special high temperature anti-seize lubricant to the threads of the new spark plugs.
Step 21

Install the new spark plugs into their mounting seats.

AUTODOC recommends:
Lower the spark plugs into the wells carefully, making sure not to damage the electrode gap.
Step 22

Screw new spark plugs and tighten them. Use the spark plug socket #16. Use a torque wrench. Tighten it to 18 nm torque.

Replacement: spark plugs – TOYOTA CARINA II Station Wagon (_T17_). Tip from AUTODOC:
Don't tighten the plugs with excessive force. Exceeding tightening torque can damage the thread connection. Be careful when working with a spark plug wrench. Its skewing can cause damage to the threaded connection.
Step 23

Install the ignition coils to the spark plug wells.
Step 24

Install the fastening bolts.
Step 25

Tighten the ignition coil fasteners. Use a drive socket #10. Use a torque wrench. Tighten it to 9 Nm torque.
Step 26

Treat the ignition coil connector with electronic spray. The spray will protect the electrical contacts from corrosion, oxidation, and will reduce the contact resistance.
Step 27

Plug in the connectors of the ignition coils.
Step 28

Remove the oil dipstick.
Step 29

Reinstall the wiring harness bracket.
Step 30

Insert the oil dipstick.
Step 31

Install the fastening bolts.
Step 32

Tighten the fasteners of the wiring harness bracket. Use a drive socket #10. Use a torque wrench. Tighten it to 9 Nm torque.
Step 33

Clean the air filter cover and housing.
Step 34

Remove the microfibre towel from the air intake hose.
Step 35

Connect the air intake pipe to the air filter housing.
Step 36

Reinstall the air filter cover. Fasten it.
Step 37

Press the air filter cover clips into place.

Step 38

Run the engine for a few minutes. This is necessary in order to make sure that the component operates properly.

Step 39

Shut off the engine.

Step 40

Remove the fender protection cover.

Step 41

Close the hood.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Need New Tyres?

Find out which tyre and wheel sizes are compatible with the TOYOTA Carina II Estate (T170) model

TOYOTA CARINA II Station Wagon (_T17_) tyre size

How to change front windshield wipers on TOYOTA Carina II Estate (_T17_) – replacement guide

Free download PDF
542.72 KB
How to change rear windshield wipers on TOYOTA Carina II Estate (T170) – replacement guide

Free download PDF
1.45 MB
How to change engine oil and filter on TOYOTA Carina II Estate (T170) – replacement guide

Free download PDF
2.04 MB
How to change fuel filter on TOYOTA Carina II Estate (_T17_) – replacement guide

Free download PDF
2.11 MB
How to change engine oil and filter on Toyota Aygo AB1 – replacement guide

Free download PDF
2.32 MB
How to change front brake pads on Toyota Prado J120 – replacement guide

Free download PDF
2.08 MB

How to change spark plugs on TOYOTA CARINA E (_T19_) – replacement guide

Free download PDF
2.08 MB
How to change spark plugs on TOYOTA CARINA E Saloon (_T19_) – replacement guide

Free download PDF
2.08 MB
How to change spark plugs on TOYOTA CARINA II (_T17_) – replacement guide

Free download PDF
2.08 MB
How to change spark plugs on TOYOTA Carina II Saloon (_T17_) – replacement guide

Free download PDF
2.08 MB
How to change spark plugs on TOYOTA CARINA E Sportswagon (_T19_) – replacement guide

Free download PDF
2.08 MB
How to change spark plugs on a car – replacement tutorial

Universal

Free download PDF
1.74 MB

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

Revive Your Vehicle's Look | How to Restore Wheel Rims Yourself!

6K views

Published on: 13/05/2021
DIY car soundproofing | AUTODOC tips

104K views

Published on: 15/04/2021
TOP 5 mistakes when replacing shock absorbers | AUTODOC tips

13K views

Published on: 15/06/2023
Top 5 Car Interior Cleaning Mistakes You Should Avoid | AUTODOC Tips

7K views

Published on: 26/05/2022