Important!

This replacement procedure can be used for:
TOYOTA Yaris Hatchback (_P1_) 1.3 (NCP10_, SCP12_)

The steps may slightly vary depending on the car design.

How to change rear springs on TOYOTA YARIS XP10 TUTORIAL | AUTODOC

Replacement: coil springs – Toyota Yaris P1. List of the tools you'll need:

                        Wire brush
                      
                        WD-40 spray
                      
                        Brake cleaner 
                      
                        Copper grease 
                      
                        Drive socket # 17 
                      
                        Wheel impact socket #21
                      
                        Ratchet wrench
                      
                        Torque wrench
                      
                        Crow bar
                      
                        Hydraulic transmission jack
                      
                        Wheel chock

All the parts you need to replace – Springs for Yaris Hatchback (_P1_) and other TOYOTA models

TOYOTA Yaris Hatchback (_P1_) 1.3 (NCP10_, SCP12_)

Replacement: coil springs – Toyota Yaris P1. Tip from AUTODOC experts:

Both coil springs of the rear suspension should be replaced simultaneously.
The replacement procedure is identical for the left and right coil springs of the rear suspension.
All work should be done with the engine stopped.

Replacement: coil springs – Toyota Yaris P1. Recommended sequence of steps:

Step 1

Secure the wheels with chocks.
Step 2

Loosen the wheel mounting bolts.Use wheel impact socket #21.
Step 3

Raise the rear of the car and secure on supports.

Step 4

Unscrew the wheel bolts.

AUTODOC recommends:

Warning! To avoid injury, hold the wheel while unscrewing the fastening bolts. Toyota Yaris P1
Step 5

Remove the wheel.
Step 6

Support the rear suspension beam. Use a hydraulic transmission jack.
Step 7

Clean the shock absorber fasteners.Use a wire brush.Use WD-40 spray.
Step 8

Unscrew the lower fastener of the shock absorber.Use a drive socket #17.Use a ratchet wrench.
Step 9

Detach the lower part of the shock absorber.

Step 10

Remove the mounting from under the rear axle beam.

Replacement: coil springs – Toyota Yaris P1. AUTODOC recommends:

Lower the hydraulic transmission jack smoothly, without jerks, to avoid damaging assemblies and mechanisms.
Step 11

Pull down the rear suspension beam.Use a crowbar.

Step 12

Take out the spring.

Replacement: coil springs – Toyota Yaris P1. Professionals recommend:

Examine suspension spring rubber spacers. Replace them if needed.
Step 13

Clean the coil spring mounting seats.Use a wire brush.Use WD-40 spray.
Step 14

Pull down the rear suspension beam.Use a crowbar.

Step 15

Install the coil spring together with the rubber mounts into the mounting seats.
Step 16

Support the rear suspension beam. Use a hydraulic transmission jack.
Step 17

Attach the lower part of the shock absorber.

Step 18

Tighten the lower fastener of the shock absorber. Use a drive socket #17.Use a torque wrench.Tighten it to 65 Nm torque.
Step 19

Remove the mounting from under the rear axle beam.

AUTODOC recommends:

Replacement: coil springs – Toyota Yaris P1. Lower the transmission jack smoothly, without jerks, to avoid damaging components and mechanisms.
Step 20

Treat the surface where the wheel rim contacts the brake drum.Use copper grease.
Step 21

Clean the wheel rim mounting seat. Use a brake cleaner.

Replacement: coil springs – Toyota Yaris P1. Tip from AUTODOC experts:

After applying the spray, wait a few minutes.

Step 22

Install the wheel.

Replacement: coil springs – Toyota Yaris P1. Tip from AUTODOC:

To avoid injury, hold up the wheel when screwing in the fastening bolts.
Step 23

Screw in the wheel bolts.Use wheel impact socket #21.
Step 24

Lower the car and working in a cross order, tighten the wheel bolts.Use wheel impact socket #21.Use a torque wrench.Tighten it to 120 Nm torque.
Step 25

Remove the jacks and chocks.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

Tips & tricks for your TOYOTA Yaris Hatchback (_P1_)

How to remove a broken bolt without welding | AUTODOC tips

260K views

Published on: 11/03/2020
Noise from under the hood | AUTODOC TIPS

198K views

Published on: 25/08/2019
How to fix a knocking and creaking suspension | AUTODOC

181K views

Published on: 08/09/2019
6 SIGNS OF A BAD FUEL FILTER | AUTODOC

163K views

Published on: 24/07/2019