How to carry out replacement: Springs 1.9 TDI Skoda Octavia 1u
Disclaimer
Change Skoda Octavia 1u RS 1.8 T Springs yourself – manuals and video tutorials

How to change rear coil springs on Skoda Octavia 1U – replacement guide

downloads: 5
Views: 59
Download your free tutorial and fix SKODA OCTAVIA (1U2) 1.6 problems yourself Download for free 1.3 MB Springs for Skoda Octavia 1u Shop now
Leave a comment Open in a new tab
Important!
This replacement procedure can be used for:
SKODA OCTAVIA (1U2) 1.6, SKODA OCTAVIA (1U2) 1.8, SKODA OCTAVIA (1U2) 1.9 TDI, SKODA OCTAVIA (1U2) 1.6, SKODA OCTAVIA (1U2) 1.9 SDI, SKODA OCTAVIA (1U2) 1.9 TDI, SKODA OCTAVIA (1U2) 1.8 T, SKODA OCTAVIA (1U2) 2.0, SKODA OCTAVIA (1U2) 1.4, SKODA OCTAVIA (1U2) 1.4 16V, SKODA OCTAVIA (1U2) 1.9 TDI, SKODA OCTAVIA (1U2) 1.9 TDI … View more

The steps may slightly vary depending on the car design.

How to change Rear Springs on SKODA OCTAVIA 1U TUTORIAL | AUTODOC

video
Published on: 14/12/2016
17K views
All the parts you need to replace – Springs for OCTAVIA (1U2) and other SKODA models
Alternative products
How to change Coil spring on Skoda Octavia 1u 1.9 TDI – step-by-step instructions for straightforward car repair Coil spring
Tools
Replacement: coil springs – Skoda Octavia 1U. Tools you need:
Wire brush
WD-40 spray
Brake cleaner
Copper grease
High-temperature ceramic grease
Torque wrench
Combination spanner #16
Drive socket # 16
Wheel impact socket #17
Ratchet wrench
Hydraulic transmission jack
Crow bar
Hammer
Wheel chock
Buy tools
Replacement: coil springs – Skoda Octavia 1U. AUTODOC recommends:
  • Both coil springs of the rear suspension should be replaced simultaneously.
  • The replacement procedure is identical for the left and right coil springs of the rear suspension.
  • Please note: all work on the car – Skoda Octavia 1U – should be done with the engine switched off.
Carry out replacement in the following order:
  1. Step 1
    How to change Springs on Skoda Octavia 1u 1996 - free PDF and video manuals
    Secure the wheels with chocks.
  2. Step 2
    How to replace SKODA OCTAVIA (1U2) 1.9 TDI 1997 Springs - step-by-step manuals and video guides
    Loosen the wheel mounting bolts. Use wheel impact socket #17.
  3. Step 3
    Skoda Octavia 1u 1.6 1998 Springs replacement: free workshop manuals
    Raise the rear of the car and secure on supports.
  4. Step 4
    Changing Springs on SKODA OCTAVIA (1U2) 1.8 T 1999 by yourself
    Unscrew the wheel bolts.
    AUTODOC recommends:
    Warning! To avoid injury, hold the wheel while unscrewing the fastening bolts. Skoda Octavia 1U
  5. Step 5
    How to remove SKODA OCTAVIA 2.0 2000 Springs - online easy-to-follow instructions
    Remove the wheel.
  6. Step 6
    How to replace Springs on SKODA OCTAVIA (1U2) 2001: download PDF manuals and video instructions
    Support the rear suspension beam. Use a hydraulic transmission jack.
  7. Step 7
    Clean the shock absorber fasteners. Use a wire brush. Use WD-40 spray.
    Step 8
    How hard is it to do yourself: Springs replacement on Skoda Octavia 1u 1.9 TDI 2002 - download illustrated guide
    Unscrew the lower fastener of the shock absorber. Use a combination spanner #16. Use a drive socket #16. Use a ratchet wrench.
  8. Step 9
    Remove the fastening bolt.
    Step 10
    Remove the mounting from under the rear axle beam.
    AUTODOC recommends:
    Lower the hydraulic transmission jack smoothly, without jerks, to avoid damaging assemblies and mechanisms.
    Step 11
    Pull down the rear suspension beam. Use a crowbar.
    Step 12
    Need to know how to renew Springs on SKODA OCTAVIA 2003? This free workshop manual will help you to do it yourself
    Take out the spring.
  9. Step 13
    Changing of Springs on Skoda Octavia 1u 2004 won't be an issue if you follow this illustrated step-by-step guide
    Remove the rubber spring spacer.
    Replacement: coil springs – Skoda Octavia 1U. Professionals recommend:
    Inspect the rubber mounts of the suspension spring. Replace if necessary.
  10. Step 14
    SKODA OCTAVIA RS 1.8 T Springs replacement: online guides and video tutorials
    Install the rubber spacer on the new coil spring.
  11. Step 15
    Pull down the rear suspension beam. Use a crowbar.
    Step 16
    Replacing Springs on Skoda Octavia 1u 2006 1.9 TDI by yourself
    Install the coil spring together with the rubber mounts into the mounting seats.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
Users voted – 0
Need New Tyres?

Find out which tyre and wheel sizes are compatible with the SKODA Octavia I Hatchback (1U2) model

Skoda Octavia 1u tyre size

Popular maintenance tutorials for Skoda Octavia 1u

More manuals for Skoda Octavia 1u

Complete guides for changing the Springs on different SKODA OCTAVIA models

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

DIY SKODA OCTAVIA (1U2) Springs replacement - online guide
Tips & tricks for your SKODA OCTAVIA (1U2)
View more
  • How to change Springs on SKODA OCTAVIA (1U2) RS 1.8 T - replacement tricks
    How to Get the Best Deals on Car Parts | Save Money with AUTODOC
    2K views
    Published on: 03/02/2022
  • Changing Coil springs Skoda Octavia 1u 1.9 TDI - Replacement Tips
    BMW E30 Turbo Suspension Swap: Boost Your Handling | AUTODOC project
    2K views
    Published on: 04/03/2021
  • Maintenance Hacks - SKODA OCTAVIA (1U2) 1.6 Spring replacement guide
    Can You Hear Your Brakes Squeaking? Learn the Causes and DIY Solutions! | AUTODOC Tips
    7K views
    Published on: 19/01/2021
  • Replace Suspension spring on Skoda Octavia 1u - free video tips
    3 essential tips for choosing summer tyres | Get ready for warmer weather
    4K views
    Published on: 18/05/2023

Most commonly replaced car parts on SKODA OCTAVIA

Professional manuals for the most common SKODA models

Autodoc CLUB App icon
Time to replace parts? Get even better deals in our Shop app.
SKODA OCTAVIA (1U2) Springs replace by yourself - Scan QR-code and download AUTODOC CLUB app
SCAN ME