Recommended replacement interval for the part category Brake disc : 50000 km

Important!

This replacement procedure can be used for:
PEUGEOT 206 Saloon 1.6 16V … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Brake Discs for 206 Saloon and other PEUGEOT models

Alternative products

Brake disc

Replacement: brake discs – PEUGEOT 206 Saloon. List of the tools you'll need:

                      Wire brush
                    
                      WD-40 spray
                    
                      Brake cleaner 
                    
                      Copper grease 
                    
                      Drive socket # 19 
                    
                      Torx bit T30
                    
                      Wheel impact socket #19
                    
                      Brake caliper wind back tool
                    
                      Ratchet wrench
                    
                      Torque wrench
                    
                      Rubber mallet
                    
                      Round-nose pliers
                    
                      Impact screwdriver
                    
                      Crow bar
                    
                      Wheel chock

Buy tools

Replacement: brake discs – PEUGEOT 206 Saloon. AUTODOC experts recommend:

Replace the brake disks on the car PEUGEOT 206 Saloon in complete set for each axis. Regardless of the state of components. This will ensure even braking.
The replacement procedure is identical for both brake disks on the same axle.
When changing the brake discs, always replace the brake pads.
Warning! Shut down the engine before starting any work – PEUGEOT 206 Saloon.

Carry out replacement in the following order:

Step 1

Open the bonnet. Unscrew the brake fluid reservoir cap.

Step 2

Secure the wheels with chocks.
Step 3

Loosen the wheel mounting bolts. Use wheel impact socket #19.
Step 4

Raise the rear of the car and secure on supports.

Step 5

Unscrew the wheel bolts.

Replacement: brake discs – PEUGEOT 206 Saloon. Tip:
To avoid injury, hold up the wheel when unscrewing the bolts.
Step 6

Remove the wheel.
Step 7

Remove the retaining springs of the brake pads. Use a crowbar.
Step 8

Remove the brake pad retaining pin. Use round-nose pliers.
Step 9

Clean the brake caliper fasteners. Use a wire brush. Use WD-40 spray.
Step 10

Remove the retainer of the brake pads. Use a crowbar. Use a rubber mallet.
Step 11

Remove the brake pads. Use a crowbar.
Step 12

Clean the brake caliper fasteners. Use a wire brush. Use WD-40 spray.
Step 13

Unscrew the brake caliper fastening. Use a drive socket #19. Use a ratchet wrench.
Step 14

Remove the brake caliper.

Replacement: brake discs – PEUGEOT 206 Saloon. AUTODOC experts recommend:
Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
Step 15

Clean the brake disc fasteners. Use a wire brush. Use WD-40 spray.
Step 16

Unscrew the brake disc fastening. Use Torx T30. Use an impact screwdriver.
Step 17

Remove the brake disc.
Step 18

Clean the hub. Use a wire brush. Treat the contacting surface. Use copper grease.
Step 19

Treat the brake caliper piston. Use a brake cleaner.

AUTODOC recommends:
Replacement: brake discs – PEUGEOT 206 Saloon. After applying the spray, wait a few minutes.
Step 20

Press in the brake caliper piston. Use brake caliper wind back tool.
Step 21

Install the brake disc.
Step 22

Tighten the brake disc fastening. Use Torx T30. Use a torque wrench. Tighten it to 9 Nm torque.
Step 23

Install the brake caliper and fix it. Use a drive socket #19. Use a torque wrench. Tighten it to 110 Nm torque.
Step 24

Install the brake pads.
Step 25

Install the retainer of the brake pads. Use a crowbar.
Step 26

Install the brake pad retaining pin.
Step 27

Install the retaining springs of the brake pads.
Step 28

Treat the surface where the brake disc contacts the wheel rim. Use copper grease.
Step 29

Clean the brake disk surface. Use a brake cleaner.

Replacement: brake discs – PEUGEOT 206 Saloon. Tip from AUTODOC experts:
After applying the spray, wait a few minutes.
Step 30

Install the wheel.

AUTODOC recommends:
Important! Hold the wheel while screwing in the fastening bolts. PEUGEOT 206 Saloon
Step 31

Screw in the wheel bolts. Use wheel impact socket #19.
Step 32

Lower the car and working in a cross order, tighten the wheel bolts. Use a torque wrench. Tighten it to 100 Nm torque.
Step 33

Remove the jacks and chocks.

AUTODOC recommends:
PEUGEOT 206 Saloon – Press the brake pedal several times with the engine shut down until you feel the resistance built up.Check the brake fluid level in the expansion tank and refill if necessary.
Step 34

Tighten the brake fluid reservoir cap. Close the hood.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Need New Tyres?

Find out which tyre and wheel sizes are compatible with the PEUGEOT 206 Saloon model

Peugeot 206 Saloon tyre size

How to change front brake discs on PEUGEOT 206 Saloon – replacement guide

Free download PDF
2.3 MB
How to change rear brake pads on PEUGEOT 206 Saloon – replacement guide

Free download PDF
1.46 MB
How to change front brake pads on PEUGEOT 206 Saloon – replacement guide

Free download PDF
1.25 MB
How to change rear wheel bearing on PEUGEOT 206 Saloon – replacement guide

Free download PDF
2.21 MB
How to change front wheel bearing on PEUGEOT 206 Saloon – replacement guide

Free download PDF
3.38 MB
How to change serpentine belt on PEUGEOT 206 Saloon – replacement guide

Free download PDF
1.46 MB

How to change front brake discs on PEUGEOT 206 Hatchback (2A/C) – replacement guide

Free download PDF
2.84 MB
How to change rear brake discs on PEUGEOT 206 Hatchback (2A/C) – replacement guide

Free download PDF
1.99 MB
How to change front brake discs on Peugeot 206 CC 2D – replacement guide

Free download PDF
2.05 MB
How to change rear brake discs on Peugeot 206 CC 2D – replacement guide

Free download PDF
2.16 MB
How to change front brake discs on PEUGEOT 206 SW (2E/K) – replacement guide

Free download PDF
2.3 MB
How to change rear brake discs on PEUGEOT 206 SW (2E/K) – replacement guide

Free download PDF
1.98 MB

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

Unveiling the secrets: Detecting vacuum leaks with a Smoke Machine | AUTODOC

19K views

Published on: 23/07/2020
TOP 6 WD-40 lifehacks | AUTODOC tips

13K views

Published on: 15/07/2021
What causes engine misfire? | AUTODOC

6K views

Published on: 10/07/2020
Drive with Care: 8 Common Bad Driving Habits Explained | AUTODOC

4K views

Published on: 01/04/2021