Recommended replacement interval for the part category Fuel filter : 12 month / 15000 km

Important!

This replacement procedure can be used for:
OPEL VECTRA B Hatchback (38_) 1.6 i 16V (F68), OPEL VECTRA B (36_) 1.6 i 16V (F19), OPEL VECTRA B Estate (31_) 1.6 i 16V (F35), OPEL Astra G CC (T98) 1.6 16V (F08, F48), OPEL Astra G Caravan (T98) 1.6 16V (F35), OPEL Astra G Saloon (T98) 1.6 16V (F69), OPEL Zafira A (T98) 1.6 16V (F75), OPEL Astra G Coupe (T98) 1.6 16V (F07), OPEL ASTRA G Convertible (F67) 1.6 16V (F67), OPEL Vectra C Saloon (Z02) 1.6 16V (F69), OPEL Vectra C CC (Z02) 1.6 (F68), OPEL Meriva A (X03) 1.6 16V (E75), OPEL Vectra C Caravan (Z02) 1.6 16V (F35)

The steps may slightly vary depending on the car design.

How to change fuel filter OPEL MERIVA A [TUTORIAL AUTODOC]

Replacement: fuel filter – Opel Meriva X03. List of the tools you'll need:

                        All-purpose cleaning spray
                      
                        Nylon cleaning brush
                      
                        Phillips Screwdriver
                      
                        Crow bar
                      
                        Fluid container
                      
                        Fuel line pliers

All the parts you need to replace – Fuel Filter for Meriva A (X03) and other OPEL models

 
    OPEL VECTRA B Hatchback (38_) 1.6 i 16V (F68)
  
    OPEL VECTRA B (36_) 1.6 i 16V (F19)
  
    OPEL VECTRA B Estate (31_) 1.6 i 16V (F35)
  
    OPEL Astra G CC (T98) 1.6 16V (F08, F48)
  
    OPEL Astra G Caravan (T98) 1.6 16V (F35)
  
    OPEL Astra G Coupe (T98) 1.6 16V (F07)
  
    OPEL Astra G Saloon (T98) 1.6 16V (F69)
  
    OPEL Zafira A (T98) 1.6 16V (F75)
  
    OPEL ASTRA G Convertible (F67) 1.6 16V (F67)
  
    OPEL Meriva A (X03) 1.6 16V (E75)
  
    OPEL Vectra C Saloon (Z02) 1.6 16V (F69)
  
    OPEL Vectra C CC (Z02) 1.6 (F68)
  
    OPEL Vectra C Caravan (Z02) 1.6 16V (F35)

Replacement: fuel filter – Opel Meriva X03. AUTODOC recommends:

Ensure adequate ventilation of the workplace. Fuel vapors are poisonous.
All work should be done with the engine stopped.

Replacement: fuel filter – Opel Meriva X03. Recommended sequence of steps:

Step 1

Open the fuel door.
Step 2

Unscrew the fuel filler cap.
Step 3

Lift the car using a jack or place it over an inspection pit.

Step 4

Prepare a container for fluids.
Step 5

Clean the fasteners of the fuel supply lines. Use a nylon cleaning brush. Use all-purpose cleaning spray.
Step 6

Disconnect the fuel supply lines from the fuel filter.Use fuel line pliers.Use a crowbar.

Replacement: fuel filter – Opel Meriva X03. Tip from AUTODOC experts:

Be careful! Fuel may leak from the filter housing and hoses.
Step 7

Unscrew the fuel filter bracket.Use a Phillips screwdriver.
Step 8

Remove the fuel filter.Use a crowbar.
Step 9

Put the old filter cartridge in the container.
Step 10

Install a new fuel filter.

Replacement: fuel filter – Opel Meriva X03. AUTODOC experts recommend:

Remember, it is important not to mix up the input and output of the filter. Arrows on the filter indicate the direction of fuel flow.During installation, take care to prevent dust and dirt from getting into the fuel filter housing.Opel Meriva X03 – It's important to only use high-quality filters.
Step 11

Connect the fuel supply lines to the fuel filter.
Step 12

Screw in the fuel filter mounting bracket.Use a Phillips screwdriver.
Step 13

Clean the fasteners of the fuel supply lines. Use all-purpose cleaning spray.
Step 14

Take the fluid container away from under the fuel filter.
Step 15

Lower the car.

Step 16

Tighten the fuel filler cap.
Step 17

Close the fuel door.

Replacement: fuel filter – Opel Meriva X03. Professionals recommend:

Before starting off, switch the ignition on and off several times. This should be done to activate the fuel pump to make it pump fuel through the fuel system.
Step 18

Run the engine for a few minutes.This is necessary in order to make sure that the component operates properly.

Step 19

Shut off the engine.

Replacement: fuel filter – Opel Meriva X03. Tip:

To protect the environment from pollution, be sure to dispose of the used filters at special collection points.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

How to replace rear brake pads of disc brake on Opel Astra G

Free download PDF

1.18 MB
How to change headlight bulb on Opel Astra G F48 – replacement guide

Free download PDF

7.21 MB
How to change: Opel Zafira F75 fuel filter – replacement guide

Free download PDF

7.11 MB
How to replace the tie rod end on Opel Astra G

Free download PDF

1.07 MB
How to change: Opel Zafira F75 pollen filter – replacement guide

Free download PDF

5.7 MB
How to change engine thermostat on Opel Meriva X03 – replacement guide

Free download PDF

11.11 MB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

Tips & tricks for your OPEL Meriva A (X03)

How to remove a broken bolt without welding | AUTODOC tips

260K views

Published on: 11/03/2020
Noise from under the hood | AUTODOC TIPS

198K views

Published on: 25/08/2019
How to fix a knocking and creaking suspension | AUTODOC

181K views

Published on: 08/09/2019
6 SIGNS OF A BAD FUEL FILTER | AUTODOC

163K views

Published on: 24/07/2019