Recommended replacement interval for the part category Fuel filter : 4 year / 60000 km

Important!

This replacement procedure can be used for:
OPEL Corsa B Hatchback (S93) 1.2 i (F08, F68, M68), OPEL Corsa B Hatchback (S93) 1.4 i (F08, F68, M68), OPEL Corsa B Hatchback (S93) 1.4 Si (F08, F68, M68), OPEL Corsa B Hatchback (S93) 1.6 GSI 16V (F08, F68, M68), OPEL Corsa B Hatchback (S93) 1.4 i 16V (F08, F68, M68), OPEL Corsa B Hatchback (S93) 1.6 i 16V (F08, F68, M68), OPEL Corsa B Hatchback (S93) 1.0 i 12V (F08, F68, M68), OPEL Corsa B Hatchback (S93) 1.2 i 16V (F08, F68, M68), OPEL Corsa B Hatchback (S93) 1.2 i (F08, F68, M68), OPEL Corsa B Hatchback (S93) 1.4 i 16V (F08, F68, M68), OPEL Corsa B Hatchback (S93) 1.6 i 16V (F08, F68, M68), OPEL Corsa B Hatchback (S93) 1.4 (F08, F68, M68) … View more

The steps may slightly vary depending on the car design.

How to change fuel filter OPEL CORSA S93 [TUTORIAL AUTODOC]

Alternative products

Fuel filter

Replacement: fuel filter – Opel Corsa S93. Tools you might need:

                      Wire brush
                    
                      Nylon cleaning brush
                    
                      All-purpose cleaning spray
                    
                      Fuel line pliers
                    
                      Phillips Screwdriver
                    
                      Fluid container

Buy tools

Replacement: fuel filter – Opel Corsa S93. AUTODOC experts recommend:

Ensure adequate ventilation of the workplace. Fuel vapors are poisonous.
Please note: all work on the car – Opel Corsa S93 – should be done with the engine switched off.

Carry out replacement in the following order:

Step 1

Open the fuel door.
Step 2

Unscrew the fuel filler cap.
Step 3

Raise the car.

Replacement: fuel filter – Opel Corsa S93. Professionals recommend:
If you are using a jack, make sure it rests on a flat surface without any unevenness.Be sure to additionally secure the car with jack stands.
Step 4

Prepare a container for fluids.
Step 5

Clean the fasteners of the fuel supply lines. Use a nylon cleaning brush. Use all-purpose cleaning spray.
Step 6

Clean the fuel filter mounting bracket. Use a wire brush. Use all-purpose cleaning spray.
Step 7

Unscrew the fuel filter bracket. Use a Phillips screwdriver.
Step 8

Remove the fuel filter.
Step 9

Disconnect the fuel supply lines from the fuel filter. Use fuel line pliers.

Replacement: fuel filter – Opel Corsa S93. AUTODOC recommends:
Be careful! Fuel may leak from the filter housing and hoses.
Step 10

Put the old filter cartridge in the container.

Step 11

Connect the fuel supply lines to the fuel filter.
Step 12

Install a new fuel filter.

Replacement: fuel filter – Opel Corsa S93. Tip:
Remember, it is important not to mix up the input and output of the filter. Arrows on the filter indicate the direction of fuel flow.During installation, take care to prevent dust and dirt from getting into the fuel filter housing.Take care to only use quality filters.
Step 13

Screw in the fuel filter mounting bracket. Use a Phillips screwdriver.
Step 14

Clean the fuel filter. Use all-purpose cleaning spray.
Step 15

Take the fluid container away from under the fuel filter.
Step 16

Lower the car.
Step 17

Tighten the fuel filler cap.
Step 18

Close the fuel door.

AUTODOC recommends:
Before starting off, switch the ignition on and off several times. This should be done to activate the fuel pump to make it pump fuel through the fuel system.
Step 19

Run the engine for a few minutes. This is necessary in order to make sure that the component operates properly.

Step 20

Shut off the engine.

Replacement: fuel filter – Opel Corsa S93. AUTODOC experts recommend:
To protect the environment from pollution, be sure to dispose of the used filters at special collection points.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Need New Tyres?

Find out which tyre and wheel sizes are compatible with the OPEL Corsa B Hatchback (S93) model

Opel Corsa S93 tyre size

How to change engine oil and filter on Opel Corsa S93 – replacement guide

Free download PDF
2.72 MB
How to change air filter on Opel Corsa S93 – replacement guide

Free download PDF
1.17 MB
How to change pollen filter on Opel Corsa S93 – replacement guide

Free download PDF
1.67 MB
How to change front brake pads on Opel Corsa S93 – replacement guide

Free download PDF
1.65 MB
How to change front brake discs on Opel Corsa S93 – replacement guide

Free download PDF
2.1 MB
How to change front wheel bearing on Opel Corsa S93 – replacement guide

Free download PDF
4.74 MB

How to change fuel filter on Opel Corsa D – replacement guide

Free download PDF
1.38 MB
How to change fuel filter on Opel Corsa C petrol – replacement guide

Free download PDF
870.4 KB
How to change fuel filter on Opel Corsa C diesel – replacement guide

Free download PDF
1.33 MB
How to change fuel filter on OPEL Corsa E Hatchback (X15) – replacement guide

Free download PDF
1.01 MB
How to change fuel filter on OPEL Corsa A CC (S83) petrol – replacement guide

Free download PDF
706.56 KB
How to change fuel filter on OPEL Corsa С Van (X01) – replacement guide

Free download PDF
1.58 MB

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

Revitalize Your Car Interior: DIY Steering Wheel Cover with AUTODOC Tips

7K views

Published on: 14/03/2024
5 possible reasons why your car heater isn't working

7K views

Published on: 21/11/2024
Engine Overheating? Replace Your Cooling Fan to Fix It

7K views

Published on: 15/11/2020
How to tighten cylinder head bolts

13K views

Published on: 06/03/2025