Recommended replacement interval for the part category Fuel filter : 60000 km

Important!

This replacement procedure can be used for:
FIAT Doblo Estate (119_, 223_) 1.3 D Multijet, FIAT Doblo Estate (119_, 223_) 1.3 JTD, FIAT Doblo Estate (119_, 223_) 1.3 JTD 16V … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Fuel Filter for Doblo Estate (119_, 223_) and other FIAT models

Fuel filter

        Fuel filter for Doblo I Estate (119, 223) Diesel (84 hp)
      
        Fuel filter for Doblo I Estate (119, 223) Diesel (75 hp)
      
        Fuel filter for Doblo I Estate (119, 223) Diesel (70 hp)

Replacement: fuel filter – FIAT DOBLO (119). Tools you need:

                        Electronic spray
                      
                        Fluid container
                      
                        Fender cover

Buy tools

Replacement: fuel filter – FIAT DOBLO (119). Tip from AUTODOC experts:

Ensure adequate ventilation of the workplace. Fuel vapors are poisonous.
Warning! Shut down the engine before starting any work – FIAT DOBLO (119)

Carry out replacement in the following order:

Step 1

Open the bonnet.

Step 2

Use a fender protection cover to prevent damaging paintwork and plastic parts of the car.

Step 3

Detach the fuel pressure sensor connector.
Step 4

Unscrew the fuel filter cover.
Step 5

Prepare a container for fluids.
Step 6

Unscrew the filter housing cap together with the old filter element. Put the old filter cartridge in the container.
Step 7

Remove the rubber strip.

Step 8

Take the fuel filter out of the bracket.
Step 9

Fasten the fuel filter in the holder.
Step 10

Install the rubber strip.
Step 11

Install a new fuel filter.

Replacement: fuel filter – FIAT DOBLO (119). AUTODOC recommends:
Make sure that the fuel filter is positioned correctly. Consider the fuel flow direction mark.During installation, take care to prevent dust and dirt from getting into the fuel filter housing.Attention! Use quality filters – FIAT DOBLO (119).
Step 12

Install and tighten the cap of the fuel filter housing.
Step 13

Clean the connector of the fuel pressure sensor. Use electronic spray.
Step 14

Attach the fuel pressure sensor connector.

AUTODOC recommends:
Before starting off, switch the ignition on and off several times. This should be done to activate the fuel pump to make it pump fuel through the fuel system.
Step 15

Run the engine for a few minutes. This is necessary in order to make sure that the component operates properly.

Step 16

Shut off the engine.

Step 17

Remove the fender protection cover.

Step 18

Close the hood.

Replacement: fuel filter – FIAT DOBLO (119). AUTODOC recommends:
To protect the environment from pollution, be sure to dispose of the used filters at special collection points.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Searching for the right tyres?

Find out which tyre and wheel sizes are compatible with the FIAT Doblo I Estate (119, 223) model.

Browse tyres

How to change air filter on FIAT Doblo I Estate (119, 223) – replacement guide

Free download PDF
1.56 MB
How to change engine oil and filter on FIAT Doblo Estate (119_, 223_) – replacement guide

Free download PDF
1.88 MB
How to change pollen filter on FIAT Doblo Estate (119_, 223_) – replacement guide

Free download PDF
757.76 KB
How to change front brake pads on FIAT Doblo Estate (119_, 223_) – replacement guide

Free download PDF
1.61 MB
How to change front brake discs on FIAT Doblo Estate (119_, 223_) – replacement guide

Free download PDF
1.88 MB
How to change rear wheel bearing on FIAT Doblo Estate (119_, 223_) – replacement guide

Free download PDF
2.44 MB

How to change fuel filter on Fiat Doblo Cargo – replacement guide

Free download PDF
2.14 MB
How to change fuel filter on FIAT DOBLO Box Body / Estate (263) – replacement guide

Free download PDF
1.15 MB
How to change fuel filter on FIAT Doblo Estate (263_) – replacement guide

Free download PDF
1.16 MB
How to change fuel filter on FIAT DOBLO Platform/Chassis (263) – replacement guide

Free download PDF
1.16 MB
How to change fuel filter on a car – replacement tutorial

Universal

Free download PDF
2 MB
How to change fuel filter on Fiat Punto 188 diesel – replacement guide

Free download PDF
1.67 MB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

How to remove rust | AUTODOC tips

25K views

Published on: 16/09/2021
How to replace a wheel stud | AUTODOC tips

8K views

Published on: 08/12/2020
Important differences between car tools | AUTODOC tips

7K views

Published on: 16/12/2021
How to replace the suspension on a BMW E30 Turbo | SUPERCAR AUTODOC

1K views

Published on: 04/03/2021