Recommended replacement interval for the part category Fuel filter : 4 year / 70000 km

Important!

This replacement procedure can be used for:
FIAT BRAVO II (198) 1.6 D Multijet

The steps may slightly vary depending on the car design.

How to change fuel filter FIAT BRAVO 2 (198) [TUTORIAL AUTODOC]

Replacement: fuel filter – Fiat Bravo 2. Tools you might need:

                        All-purpose cleaning spray
                      
                        Combination spanner #12
                      
                        Drive socket # 10 
                      
                        Drive socket # 12 
                      
                        Ratchet wrench
                      
                        Fuel line pliers
                      
                        Bleeder kit
                      
                        Fender cover

All the parts you need to replace – Fuel Filter for BRAVO II (198) and other FIAT models

FIAT BRAVO II (198) 1.6 D Multijet

Replacement: fuel filter – Fiat Bravo 2. Professionals recommend:

Ensure adequate ventilation of the workplace. Fuel vapors are poisonous.
All work should be done with the engine stopped.

Replacement: fuel filter – Fiat Bravo 2. Recommended sequence of steps:

Step 1

Open the bonnet.
Step 2

Use a fender protection cover to prevent damaging paintwork and plastic parts of the car.
Step 3

Clean the fasteners of the fuel supply lines. Use all-purpose cleaning spray.
Step 4

Squeeze the clips and detach the fuel supply lines from the fuel filter housing.Use fuel line pliers.

Replacement: fuel filter – Fiat Bravo 2. Tip from AUTODOC:

Be careful! Fuel may leak from the filter housing and hoses.
Step 5

Loosen the fuel filter mounting.Use a drive socket #10.Use a ratchet wrench.
Step 6

Remove the fuel filter.
Step 7

Detach the fuel pressure sensor connector.
Step 8

Attach the fuel pressure sensor connector.
Step 9

Install a new fuel filter.
Step 10

Tighten the fuel filter fasteners. Use a drive socket #10.Use a ratchet wrench.

Replacement: fuel filter – Fiat Bravo 2. Professionals recommend:

Make sure that the fuel filter is positioned correctly. Consider the fuel flow direction mark.During installation, take care to prevent dust and dirt from getting into the fuel filter housing.Attention! Use quality filters – Fiat Bravo 2.
Step 11

Connect the fuel lines to the fuel filter and lock the fastening clips.
Step 12

Connect the bleeder kit to the fuel filter bleeder screw.
Step 13

Unscrew the fuel filter bleeder screw. Use a combination spanner #12.
Step 14

Switch on the ignition.This should be done to activate the fuel pump to make it pump fuel through the fuel system.
Step 15

Remove the bleeder kit.
Step 16

Screw in the fuel filter bleeder screw. Use a drive socket #12.Use a ratchet wrench.
Step 17

Run the engine for a few minutes.This is necessary in order to make sure that the component operates properly.
Step 18

Shut off the engine.
Step 19

Remove the fender protection cover.
Step 20

Close the hood.

Replacement: fuel filter – Fiat Bravo 2. Tip:

To protect the environment from pollution, be sure to dispose of the used filters at special collection points.

Comment

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

How to change pollen filter on Fiat Bravo 2 – replacement guide

Free download PDF

4.82 MB
How to change air filter on Fiat Bravo 2 – replacement guide

Free download PDF

3.95 MB
How to change engine oil and filter on Fiat Bravo 2 – replacement guide

Free download PDF

8.79 MB
How to change fuel filter on Fiat Punto 199 – replacement guide

Free download PDF

2.04 MB
How to change rear wheel bearing on Fiat Bravo 2 – replacement guide

Free download PDF

9.95 MB
How to change front brake discs on Fiat Bravo 2 – replacement guide

Free download PDF

9.87 MB
How to change rear brake discs on Fiat Bravo 2 – replacement guide

Free download PDF

9.08 MB
How to change front brake pads on Fiat Bravo 2 – replacement guide

Free download PDF

7.6 MB
How to change front strut mount on Fiat Bravo 2 – replacement guide

Free download PDF

13.16 MB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

Tips & tricks for your FIAT BRAVO II (198)

How to change an oxygen sensor | AUTODOC tips

5K views

Published on: 26/07/2020
Why do your brakes squeak? | AUTODOC tips

3K views

Published on: 19/01/2021
How to change automatic transmission fluid | AUTODOC tips

3K views

Published on: 16/09/2020
Coolant comparison test | AUTODOC tips

1K views

Published on: 18/02/2021