Important!

This replacement procedure can be used for:
VW Caddy II Estate (9K9B) 1.9 D, VW Caddy II Estate (9K9B) 1.9 SDI … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Control Arm for Caddy II Estate (9K9B) and other VW models

Suspension arm

Suspension arm for Caddy II Estate (9K9B) Diesel (64 hp)

Simple DIY car repair steps – Replacing Suspension arm on Caddy II Estate (9K9B)

Suspension arm for Caddy II Estate (9K9B) Diesel (64 hp)

Replacement: front lower arm – VW CADDY II Estate (9K9B). List of the tools you'll need:

                        Wire brush
                      
                        WD-40 spray
                      
                        Brake cleaner 
                      
                        Copper grease 
                      
                        Combination spanner #16
                      
                        Combination spanner #18
                      
                        Drive socket # 16 
                      
                        Drive socket # 18 
                      
                        Wheel impact socket #17
                      
                        Ratchet wrench
                      
                        Torque wrench
                      
                        Tap wrench
                      
                        Hydraulic transmission jack
                      
                        Wheel chock

Buy tools

Replacement: front lower arm – VW CADDY II Estate (9K9B). AUTODOC experts recommend:

The replacement procedure is identical for the left and right lower control arms.
All work should be done with the engine stopped.

Replacement: front lower arm – VW CADDY II Estate (9K9B). Use the following procedure:

Step 1

Secure the wheels with chocks.
Step 2

Loosen the wheel mounting bolts. Use wheel impact socket #17.
Step 3

Raise the front of the car and secure on supports.

Step 4

Unscrew the wheel bolts.

Replacement: front lower arm – VW CADDY II Estate (9K9B). Tip:
To avoid injury, hold up the wheel when unscrewing the bolts.
Step 5

Remove the wheel.

Step 6

Clean all joints of the arm. Use a wire brush. Use WD-40 spray.

AUTODOC recommends:
Replacement: front lower arm – VW CADDY II Estate (9K9B). After applying the spray, wait a few minutes.Wear protective goggles.
Step 7

Unscrew the fastener connecting the ball joint to the suspension control arm. Use a drive socket #16. Use a tap wrench.
Step 8

Unscrew the front arm fastener. Use a drive socket #18. Use a tap wrench.
Step 9

Unscrew the rear fastener connecting the control arm to the car body. Use a drive socket #18. Use a tap wrench.
Step 10

Unscrew the rear fastener connecting the control arm to the subframe. Use a drive socket #16. Use a tap wrench.
Step 11

Remove the fastening bolts. Use a drive socket #18. Use a drive socket #16.
Step 12

Remove the arm.
Step 13

Clean the mounting seats and the thread of the suspension arm. Use a wire brush. Use WD-40 spray.
Step 14

Install a new arm.

Replacement: front lower arm – VW CADDY II Estate (9K9B). AUTODOC recommends:
During the installation process, use only new bolts and nuts.
Step 15

Install the front fastener of the arm.
Step 16

Screw the fasteners of the ball joint. Use a drive socket #16. Use a ratchet wrench.
Step 17

Install the rear fastener of the arm.
Step 18

Screw the rear fastener connecting the control arm to the car body. Use a combination spanner #18. Use a drive socket #18. Use a ratchet wrench.
Step 19

Install the rear fastener of the arm.
Step 20

Screw the rear fastener connecting the control arm to the subframe. Use a combination spanner #16. Use a drive socket #16. Use a ratchet wrench.
Step 21

Screw the front arm fastener. Use a drive socket #18. Use a ratchet wrench.
Step 22

Support the arm. Use a hydraulic transmission jack.
Step 23

Tighten the front fastener connecting the control arm to the subframe. Use a drive socket #18. Use a torque wrench. Tighten it to 70 Nm torque.+180°

AUTODOC recommends:
Important! Be sure to use new fasteners.
Step 24

Tighten the ball joint fastener. Use a drive socket #16. Use a torque wrench. Tighten it to 60 nm torque.
Step 25

Tighten the rear fastener connecting the arm to the body subframe. Use a drive socket #16. Use a torque wrench. Tighten it to 50 Nm torque.+90°

AUTODOC recommends:
Important! Be sure to use new fasteners.
Step 26

Tighten the rear fastener connecting the arm to the car body. Use a drive socket #18. Use a torque wrench. Tighten it to 70 Nm torque.+90°

AUTODOC recommends:
Important! Be sure to use new fasteners.
Step 27

Remove the support from under the arm.

AUTODOC recommends:
Replacement: front lower arm – VW CADDY II Estate (9K9B). Lower the transmission jack smoothly, without jerks, to avoid damaging components and mechanisms.
Step 28

Treat all joints of the arm. Use copper grease.
Step 29

Treat the surface where the brake disc contacts the wheel rim. Use copper grease.
Step 30

Clean the brake disk surface. Use a brake cleaner.

Replacement: front lower arm – VW CADDY II Estate (9K9B). Professionals recommend:
After applying the spray, wait a few minutes.
Step 31

Install the wheel.

Replacement: front lower arm – VW CADDY II Estate (9K9B). Tip from AUTODOC:
To avoid injury, hold up the wheel when screwing in the fastening bolts.
Step 32

Screw in the wheel bolts. Use wheel impact socket #17.
Step 33

Lower the car and working in a cross order, tighten the wheel bolts. Use wheel impact socket #17. Use a torque wrench. Tighten it to 120 nm torque.
Step 34

Remove the jacks and chocks.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Searching for the right tyres?

Find out which tyre and wheel sizes are compatible with the VW Caddy II Estate (9K9B) model.

VW Caddy II Estate tyre size

How to change track rod end on VW Caddy II Estate (9K9B) – replacement guide

Free download PDF
1.28 MB
How to change rear wheel bearing on VW Caddy II Estate (9K9B) – replacement guide

Free download PDF
1.98 MB
How to change front wheel bearing on VW Caddy II Estate (9K9B) – replacement guide

Free download PDF
4.06 MB
How to change front strut mount on VW Caddy II Estate (9K9B) – replacement guide

Free download PDF
2.5 MB
How to change serpentine belt on VW Caddy II Estate (9K9B) – replacement guide

Free download PDF
1.36 MB
How to change spark plugs on VW Caddy II Estate (9K9B) – replacement guide

Free download PDF
1003.52 KB

How to change front lower arm on VW Caddy III Van (2KA, 2KH, 2CA, 2CH) – replacement guide

Free download PDF
2.53 MB
How to change front lower arm on VW Caddy 3 Kombi – replacement guide

Free download PDF
2.53 MB
How to change front lower arm on VW Caddy III MPV (6K9, 9E7, 9E9) – replacement guide

Free download PDF
1.89 MB
How to change control arm on a car – replacement tutorial

Universal

Free download PDF
1.07 MB
How to change front lower arm on VW Polo 9N – replacement guide

Free download PDF
2.45 MB
How to change front lower arm on VW Golf 5 – replacement guide

Free download PDF
2.89 MB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

Top 5 brake repair mistakes | AUTODOC tips

184K views

Published on: 27/10/2022
How to find and change a fuse | AUTODOC

2K views

Published on: 15/08/2020
How to Make a DIY Foam Sprayer | AUTODOC tips

210K views

Published on: 23/06/2022
DIY brake caliper restoration | AUTODOC tips

562K views

Published on: 02/06/2022