Disclaimer
How to change front brake discs on VW Golf 2 – replacement guide
downloads:
5
Views:
72
Recommended replacement interval for the part category Brake disc : 50000 km
Important!
This replacement procedure can be used for:
VW GOLF II (19E, 1G1) 1.6, VW GOLF II (19E, 1G1) 1.6, VW GOLF II (19E, 1G1) 1.8 Syncro, VW GOLF II (19E, 1G1) 1.8 i Cat, VW GOLF II (19E, 1G1) 1.8 Syncro, VW GOLF II (19E, 1G1) 1.8 GTI Cat, VW GOLF II (19E, 1G1) 1.6 TD, VW GOLF II (19E, 1G1) 1.6 TD, VW GOLF II (19E, 1G1) 1.6 TD, VW GOLF II (19E, 1G1) 1.8 GTI, VW GOLF II (19E, 1G1) 1.8, VW GOLF II (19E, 1G1) 1.8 i Cat Syncro, VW GOLF II (19E, 1G1) 1.6 D, VW GOLF II (19E, 1G1) 1.6 TD, VW GOLF II (19E, 1G1) 1.6, VW GOLF II (19E, 1G1) 1.8 Syncro, VW GOLF II (19E, 1G1) 1.8 … View more
The steps may slightly vary depending on the car design.
VW GOLF II (19E, 1G1) 1.6, VW GOLF II (19E, 1G1) 1.6, VW GOLF II (19E, 1G1) 1.8 Syncro, VW GOLF II (19E, 1G1) 1.8 i Cat, VW GOLF II (19E, 1G1) 1.8 Syncro, VW GOLF II (19E, 1G1) 1.8 GTI Cat, VW GOLF II (19E, 1G1) 1.6 TD, VW GOLF II (19E, 1G1) 1.6 TD, VW GOLF II (19E, 1G1) 1.6 TD, VW GOLF II (19E, 1G1) 1.8 GTI, VW GOLF II (19E, 1G1) 1.8, VW GOLF II (19E, 1G1) 1.8 i Cat Syncro, VW GOLF II (19E, 1G1) 1.6 D, VW GOLF II (19E, 1G1) 1.6 TD, VW GOLF II (19E, 1G1) 1.6, VW GOLF II (19E, 1G1) 1.8 Syncro, VW GOLF II (19E, 1G1) 1.8 … View more
The steps may slightly vary depending on the car design.
How to change front brake discs on VW GOLF 2 [TUTORIAL AUTODOC]
All the parts you need to replace – Brake Discs for GOLF II (19E, 1G1) and other VW models
Brake disc
Alternative products
Brake disc
Wire brush
Nylon cleaning brush
WD-40 spray
Brake cleaner
Copper grease
Torque wrench
Torx bit T30
HEX bit No.H6
Wheel impact socket #17
Ratchet wrench
Brake caliper wind back tool
Crow bar
Wheel chock
Replacement: brake discs – VW Golf 2. Tip from AUTODOC:
- Replace the brake disks on the car VW Golf 2 in complete set for each axis. Regardless of the state of components. This will ensure even braking.
- The replacement procedure is identical for both brake disks on the same axle.
- When changing the brake discs, always replace the brake pads.
- Please note: all work on the car – VW Golf 2 – should be done with the engine switched off.
Carry out replacement in the following order:
- Step 1
Open the bonnet. Unscrew the brake fluid reservoir cap. - Step 2Secure the wheels with chocks.Step 3
Loosen the wheel mounting bolts. Use wheel impact socket #17. - Step 4
Raise the front of the car and secure on supports. - Step 5
Unscrew the wheel bolts.AUTODOC recommends:Warning! To avoid injury, hold the wheel while unscrewing the fastening bolts. VW Golf 2 - Step 6
Remove the wheel. - Step 7Remove the dust boot caps of the brake caliper guide pins. Use a crowbar.Step 8
Clean the brake caliper fasteners. Use a wire brush. Use WD-40 spray. - Step 9
Unscrew the brake caliper fastening. Use HEX No.H6. Use a ratchet wrench. - Step 10
Spread the brake pads. Use a crowbar. - Step 11
Remove the brake caliper.Replacement: brake discs – VW Golf 2. Tip from AUTODOC experts:Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary. - Step 12
Remove the brake pads. - Step 13
Clean the brake disc fastener. Use a wire brush. Use WD-40 spray. - Step 14
Unscrew the brake disc fastening. Use Torx T30. Use an impact screwdriver. - Step 15
Remove the brake disc. - Step 16
Clean the hub. Use a wire brush. Treat the contacting surface. Use copper grease. - Step 17
Clean the brake caliper bracket of dirt and dust. Use a wire brush. Use a brake cleaner.AUTODOC recommends:Replacement: brake discs – VW Golf 2. After applying the spray, wait a few minutes. - Step 18
Install the brake disc.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
Users voted – 0
Searching for the right tyres?
Find out which tyre and wheel sizes are compatible with the VW Golf II Hatchback (19E, 1G1) model.
Popular maintenance tutorials for VW GOLF II (19E, 1G1)
Free download PDF
2 MB
Free download PDF2.05 MB
Free download PDF1.54 MB
Free download PDF1.3 MB
Free download PDF1.22 MB
Free download PDF1.4 MB
Complete guides for changing the Brake rotors on different VW GOLF models
Free download PDF2.1 MB
Free download PDF2.3 MB
Free download PDF2.52 MB
Free download PDF2.8 MB
Free download PDF2.24 MB
Free download PDF2.56 MB
Your profile is your personal assistant.
It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents
Install the AUTODOC CLUB app!
Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.
Scan
To download the app:
- - scan the QR code
- - download from App Store
- - download from Google Play
Tips & tricks for your VW GOLF II (19E, 1G1)
View more
How and why to check your oil | AUTODOC tips
How to prevent car windows from fogging up | AUTODOC tips
What to do if your car’s bonnet won’t open | AUTODOC tips
How to fix your car with AUTODOC CLUB
