How to carry out replacement: Brake Discs 1.6 TDI Golf Mk6
Disclaimer
Change Golf Mk6 1.4 TSI Brake Discs yourself – manuals and video tutorials

How to change rear brake discs on VW Golf 6 – replacement guide

downloads: 63
Views: 1450
Download your free tutorial and fix VW GOLF VI (5K1) 2.0 TDI problems yourself Download for free 2.56 MB Brake Discs for Golf Mk6 Shop now
Leave a comment Open in a new tab
When to replace the Brake Discs on your VW GOLF
Recommended replacement interval for the part category Brake disc : 50000 km
Important!
This replacement procedure can be used for:
VW GOLF VI (5K1) 2.0 GTi, VW GOLF VI (5K1) 1.6 MultiFuel, VW GOLF VI (5K1) 1.2 TSI, VW GOLF VI (5K1) 2.0 GTi, VW GOLF VI (5K1) 1.4, VW GOLF VI (5K1) 1.6, VW GOLF VI (5K1) 1.4 TSI, VW GOLF VI (5K1) 1.4 TSI, VW GOLF VI (5K1) 2.0 TDI, VW GOLF VI (5K1) 2.0 TDI, VW GOLF VI (5K1) 2.0 TDI, VW GOLF VI (5K1) 1.6 BiFuel, VW GOLF VI (5K1) 2.0 GTi, VW GOLF VI (5K1) 1.6 TDI, VW GOLF VI (5K1) 2.0 TDI, VW GOLF VI (5K1) 1.2 TSI, VW GOLF VI (5K1) 1.6 TDI, VW GOLF VI (5K1) 1.8 TSI, VW GOLF VI (5K1) Blue E-Motion, VW GOLF VI (5K1) 2.5 … View more

The steps may slightly vary depending on the car design.

How to change rear brake discs / rear brake rotors on VW GOLF 6 (5K1) [TUTORIAL AUTODOC]

video
Published on: 11/03/2019
50K views
All the parts you need to replace – Brake Discs for GOLF VI (5K1) and other VW models
Alternative products
How to change Brake disc on Golf Mk6 1.6 TDI – step-by-step instructions for straightforward car repair Brake disc
Tools
Replacement: brake discs – VW Golf 6. List of the tools you'll need:
Wire brush
WD-40 spray
Multipurpose grease
Copper grease
XZN socket bit # 12
Drive socket # 13
Combination spanner #13
Combination spanner #19
Torx bit T30
Wheel impact socket #17
Tap wrench
Ratchet wrench
Torque wrench
Brake caliper wind back tool
Crow bar
Wheel chock
Buy tools
Replacement: brake discs – VW Golf 6. Tip from AUTODOC:
  • Replace the brake disks on the car VW Golf 6 in complete set for each axis. Regardless of the state of components. This will ensure even braking.
  • The replacement procedure is identical for both brake disks on the same axle.
  • When changing the brake discs, always replace the brake pads.
  • All work should be done with the engine stopped.
Replacement: brake discs – VW Golf 6. Recommended sequence of steps:
  1. Step 1
    How to change Brake Discs on Golf Mk6 2008 - free PDF and video manuals
    Open the bonnet. Unscrew the brake fluid reservoir cap.
  2. Step 2
    How to replace VW GOLF VI (5K1) 1.6 TDI 2009 Brake Discs - step-by-step manuals and video guides
    Secure the wheels with chocks.
  3. Step 3
    Golf Mk6 2.0 TDI 2010 Brake Discs replacement: free workshop manuals
    Loosen the wheel mounting bolts. Use wheel impact socket #17.
  4. Step 4
    Changing Brake Discs on VW GOLF VI (5K1) 2.0 GTi 2011 by yourself
    Raise the rear of the car and secure on supports.
  5. Step 5
    How to remove VW GOLF 1.4 2012 Brake Discs - online easy-to-follow instructions
    Unscrew the wheel bolts.
    Replacement: brake discs – VW Golf 6. Tip:
    To avoid injury, hold up the wheel when unscrewing the bolts.
  6. Step 6
    How to replace Brake Discs on VW GOLF VI (5K1) 2013: download PDF manuals and video instructions
    Remove the wheel.
  7. Step 7
    How hard is it to do yourself: Brake Discs replacement on Golf Mk6 1.6 TDI 2008 - download illustrated guide
    Spread the brake pads. Use a crowbar.
  8. Step 8
    Need to know how to renew Brake Discs on VW GOLF 2009? This free workshop manual will help you to do it yourself
    Unscrew the brake caliper fastening. Use a combination spanner #13. Use a combination spanner #19.
  9. Step 9
    Changing of Brake Discs on Golf Mk6 2010 won't be an issue if you follow this illustrated step-by-step guide
    Remove the brake caliper.
    Replacement: brake discs – VW Golf 6. Professionals recommend:
    Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur.
  10. Step 10
    VW GOLF 1.4 TSI Brake Discs replacement: online guides and video tutorials
    Remove the brake pads.
  11. Step 11
    Replacing Brake Discs on Golf Mk6 2012 1.6 TDI by yourself
    Clean the brake caliper bracket fasteners. Use WD-40 spray.
  12. Step 12
    GOLF VI (5K1) 1.4 2013 Brake Discs DIY replacement workshop manual
    Unscrew the caliper bracket fastening. Use XZN #12. Use a ratchet wrench. Use a tap wrench.
  13. Step 13
    How to change Brake Discs on VW GOLF VI (5K1) 2008 - tips and tricks
    Remove the caliper bracket.
  14. Step 14
    Step-by-step recommendations for DIY replacement Golf Mk6 2009 1.4 Brake Discs
    Unscrew the brake disc fastening. Use Torx T30. Use a ratchet wrench.
  15. Step 15
    DIY replacement of Brake Discs on VW GOLF VI (5K1) 1.4 TSI 2010 is not an issue anymore with our step-by-step tutorial
    Remove the brake disc.
  16. Step 16
    How to change Brake Discs on Golf Mk6 2008 - free PDF and video manuals
    Clean the hub. Use a wire brush. Treat the contacting surface. Use a multipurpose grease.
  17. Step 17
    How to replace VW GOLF VI (5K1) 1.6 TDI 2009 Brake Discs - step-by-step manuals and video guides
    Install the brake disc.
Comments – 1
  • @user_1216802
    04.12.2022 04:48
    Member
    Why use the Tap wrench when unscrewing the caliper bracket fastening in step 12? In other words, what's the use of the Tap wrench when unscrewing the caliper bracket fastening in step 12? Which experts please guide me? Thanks in advance!
    My Email is [email protected]
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
Users voted – 0
Need New Tyres?

Find out which tyre and wheel sizes are compatible with the VW Golf VI Hatchback (5K1) model

Golf Mk6 tyre size

Popular maintenance tutorials for Golf Mk6

More manuals for Golf Mk6

Complete guides for changing the Brake rotors on different VW GOLF models

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

DIY VW GOLF VI (5K1) Brake Discs replacement - online guide
Tips & tricks for your VW GOLF VI (5K1)
View more
  • How to change Brake rotors on VW GOLF VI (5K1) 1.4 TSI - replacement tricks
    Can You Hear Your Brakes Squeaking? Learn the Causes and DIY Solutions! | AUTODOC Tips
    7K views
    Published on: 19/01/2021
  • Changing Brake disc Golf Mk6 1.6 TDI - Replacement Tips
    Transform Your Engine Bay: Affordable Valve Cover Restoration with AUTODOC
    7K views
    Published on: 29/06/2023
  • Maintenance Hacks - VW GOLF VI (5K1) 2.0 TDI Rotors replacement guide
    Checking the starter without removing it | AUTODOC tips
    27K views
    Published on: 01/12/2020
  • Replace Disc brakes on Golf Mk6 - free video tips
    #DIY Guide: How to Fix a Cracked Windscreen Without a Garage Visit
    8K views
    Published on: 14/12/2023

Most commonly replaced car parts on VW GOLF

Professional manuals for the most common VW models

Autodoc CLUB App icon
Time to replace parts? Get even better deals in our Shop app.
VW GOLF VI (5K1) Brake Discs replace by yourself - Scan QR-code and download AUTODOC CLUB app
SCAN ME