Recommended replacement interval for the part category Brake Pad Set, disc brake : 30000 km

Important!

This replacement procedure can be used for:
VW GOLF II (19E, 1G1) 1.6 … View more

The steps may slightly vary depending on the car design.

How to change front brake pads on VW GOLF 2 [TUTORIAL AUTODOC]

All the parts you need to replace – Brake Pads for GOLF II (19E, 1G1) and other VW models

Brake Pad Set, disc brake

Brake Pad Set, disc brake for VW GOLF II (19E, 1G1) 1.6 Petrol (72 hp)

Replacement: brake pads – VW Golf 2. Tools you might need:

                        Wire brush
                      
                        Nylon cleaning brush
                      
                        WD-40 spray
                      
                        Brake cleaner 
                      
                        Anti-squeal paste
                      
                        Copper grease 
                      
                        Torque wrench
                      
                        HEX bit No.H6
                      
                        Wheel impact socket #17
                      
                        Ratchet wrench
                      
                        Brake caliper wind back tool
                      
                        Crow bar
                      
                        Wheel chock

Buy tools

Replacement: brake pads – VW Golf 2. AUTODOC experts recommend:

Perform the replacement of brake pads in complete set for each axis. This provides effective braking.
The replacement procedure is identical for all brake pads on the same axle.
Please note: all work on the car – VW Golf 2 – should be done with the engine switched off.

Carry out replacement in the following order:

Step 1

Open the bonnet.Unscrew the brake fluid reservoir cap.
Step 2

Secure the wheels with chocks.

Step 3

Loosen the wheel mounting bolts.Use wheel impact socket #17.
Step 4

Raise the front of the car and secure on supports.
Step 5

Unscrew the wheel bolts.

AUTODOC recommends:

Important! Hold the wheel while unscrewing the fastening bolts. VW Golf 2
Step 6

Remove the wheel.
Step 7

Remove the dust boot caps of the brake caliper guide pins. Use a crowbar.

Step 8

Clean the brake caliper fasteners. Use a wire brush.Use WD-40 spray.
Step 9

Unscrew the brake caliper fastening.Use HEX No.H6.Use a ratchet wrench.
Step 10

Spread the brake pads.Use a crowbar.
Step 11

Remove the brake caliper.

Replacement: brake pads – VW Golf 2. Professionals recommend:

Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
Step 12

Remove the brake pads.

Replacement: brake pads – VW Golf 2. AUTODOC experts recommend:

Measure the brake disc thickness. Upon reaching the wear limit the part must be replaced.
Step 13

Clean the brake caliper bracket of dirt and dust.Use a wire brush.Use a brake cleaner.

AUTODOC recommends:

Replacement: brake pads – VW Golf 2. After applying the spray, wait a few minutes.
Step 14

Treat the brake pads in the area where their surface comes into contact with the brake caliper bracket. Use anti-squeal paste.

Replacement: brake pads – VW Golf 2. Professionals recommend:

Make sure the disc surface is clean before installing the pads.
Step 15

Install new brake pads.

Replacement: brake pads – VW Golf 2. AUTODOC recommends:

Make sure the pads are installed with the linings facing the disc.
Step 16

Treat the brake caliper piston.Use a nylon cleaning brush.Use a brake cleaner.

AUTODOC recommends:

Replacement: brake pads – VW Golf 2. After applying the spray, wait a few minutes.
Step 17

Press in the brake caliper piston.Use brake caliper wind back tool.
Step 18

Install the brake caliper and fix it.Use HEX No.H6.Use a torque wrench.Tighten it to 35 Nm torque.
Step 19

Install the dust boot caps of the brake caliper guide pins.

Step 20

Treat the surface where the brake disc contacts the wheel rim. Use copper grease.
Step 21

Clean the brake disk surface.Use a brake cleaner.

Replacement: brake pads – VW Golf 2. Tip from AUTODOC experts:

After applying the spray, wait a few minutes.
Step 22

Install the wheel.

AUTODOC recommends:

Warning! To avoid injury, hold the wheel while screwing in the fastening bolts on the car. VW Golf 2
Step 23

Screw in the wheel bolts.Use wheel impact socket #17.
Step 24

Lower the car and working in a cross order, tighten the wheel bolts.Use wheel impact socket #17.Use a torque wrench.Tighten it to 120 Nm torque.
Step 25

Remove the jacks and chocks.

Replacement: brake pads – VW Golf 2. AUTODOC recommends:

Check the brake fluid level in the expansion tank and refill if necessary.
Step 26

Tighten the brake fluid reservoir cap. Close the hood.

Replacement: brake pads – VW Golf 2. Tip from AUTODOC:

Without starting the engine, press the brake pedal several times until you feel significant resistance.Slow down smoothly for first 150-200 km after the brake pads replacement. Avoid unneccessary and sharp braking to a stop.

Comment

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

How to change rear brake shoes on VW Golf 2 – replacement guide

Free download PDF

8.17 MB
How to change front brake hose on VW Golf 2 – replacement guide

Free download PDF

7.75 MB
How to change brake drum on VW Golf 2 – replacement guide

Free download PDF

5.36 MB
How to change front brake discs on VW Golf 2 – replacement guide

Free download PDF

6.72 MB
How to change rear wheel bearing on VW Golf 2 – replacement guide

Free download PDF

7.42 MB
How to change front wheel bearing on VW Golf 2 – replacement guide

Free download PDF

14.2 MB

How to change rear brake pads on VW Golf 5 – replacement guide

Free download PDF

2.38 MB
How to change front brake pads on VW Golf 5 – replacement guide

Free download PDF

2.36 MB
How to change front brake pads on VW Golf 7 – replacement guide

Free download PDF

1.62 MB
How to change rear brake pads on VW Golf 7 – replacement guide

Free download PDF

1.51 MB
How to change rear brake pads on VW Golf 4 – replacement guide

Free download PDF

1.39 MB
How to change front brake pads on VW Golf 4 – replacement guide

Free download PDF

1.64 MB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

Tips & tricks for your VW GOLF II (19E, 1G1)

How to shine your tyres | AUTODOC tips

2K views

Published on: 07/04/2022
How to change an oxygen sensor | AUTODOC tips

6K views

Published on: 26/07/2020
How to fix your car with AUTODOC CLUB

15K views

Published on: 30/11/2021
How to check your head gasket | AUTODOC

6K views

Published on: 13/10/2020