Recommended replacement interval for the part category Brake disc : 50000 km

Important!

This replacement procedure can be used for:
TOYOTA Yaris Verso (_P2_) 1.3 (NCP20_, NCP22_), TOYOTA Yaris Verso (_P2_) 1.3 (NCP20_, NCP22_) … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Brake Discs for Yaris Verso (_P2_) and other TOYOTA models

Brake disc

Brake disc for Yaris Verso (P2) Petrol (86 hp)

Simple DIY car repair steps – Replacing Brake disc on Yaris Verso (P2)

Brake disc for Yaris Verso (P2) Petrol (84 hp)

Replacement: brake discs – TOYOTA YARIS VERSO (_NLP2_, _NCP2_). Tools you need:

                        Wire brush
                      
                        WD-40 spray
                      
                        Brake cleaner 
                      
                        Brake caliper guide pins grease
                      
                        Copper grease 
                      
                        Combination spanner #17
                      
                        Drive socket # 14 
                      
                        Drive socket # 17 
                      
                        Wheel impact socket #21
                      
                        Ratchet wrench
                      
                        Torque wrench
                      
                        Brake caliper wind back tool
                      
                        Crow bar
                      
                        Wheel chock

Buy tools

Replacement: brake discs – TOYOTA YARIS VERSO (_NLP2_, _NCP2_). Tip from AUTODOC:

Replace the brake disks on the car TOYOTA YARIS VERSO (_NLP2_, _NCP2_) in complete set for each axis. Regardless of the state of components. This will ensure even braking.
The replacement procedure is identical for both brake disks on the same axle.
When changing the brake discs, always replace the brake pads.
All work should be done with the engine stopped.

Replacement: brake discs – TOYOTA YARIS VERSO (_NLP2_, _NCP2_). Recommended sequence of steps:

Step 1

Open the bonnet. Unscrew the brake fluid reservoir cap.

Step 2

Secure the wheels with chocks.
Step 3

Loosen the wheel mounting bolts. Use wheel impact socket #21.
Step 4

Raise the front of the car and secure on supports.

Step 5

Unscrew the wheel bolts.

Replacement: brake discs – TOYOTA YARIS VERSO (_NLP2_, _NCP2_). Tip:
To avoid injury, hold up the wheel when unscrewing the bolts.
Step 6

Remove the wheel.
Step 7

Clean the brake caliper fasteners. Use a wire brush. Use WD-40 spray.

Step 8

Spread the brake pads. Use a crowbar.
Step 9

Unscrew the brake caliper fastening. Use a combination spanner #17. Use a drive socket #14.
Step 10

Remove the brake caliper.

Replacement: brake discs – TOYOTA YARIS VERSO (_NLP2_, _NCP2_). Tip from AUTODOC experts:
Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
Step 11

Remove the brake pads.
Step 12

Clean the brake caliper bracket fasteners. Use a wire brush. Use WD-40 spray.
Step 13

Unscrew the caliper bracket fastening. Use a drive socket #17. Use a ratchet wrench.
Step 14

Remove the caliper bracket.
Step 15

Remove the brake disc.
Step 16

Clean the hub. Use a wire brush. Treat the contacting surface. Use copper grease.
Step 17

Install the brake disc.
Step 18

Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.

AUTODOC recommends:
Replacement: brake discs – TOYOTA YARIS VERSO (_NLP2_, _NCP2_). After applying the spray, wait a few minutes.
Step 19

Remove the guide pins from the brake caliper.

Step 20

Clean old grease and rust stains, if there are any, from the caliper guide pins and guide pin boots.
Step 21

Treat the brake caliper guide pins. Use the brake caliper guide pin grease.

Step 22

Screw in the guide pins.

Step 23

Install the brake caliper bracket.
Step 24

Tighten the brake caliper bracket. Use a drive socket #17. Use a torque wrench. Tighten it to 88 Nm torque.
Step 25

Install the brake pads.
Step 26

Treat the brake caliper piston. Use a brake cleaner.

Replacement: brake discs – TOYOTA YARIS VERSO (_NLP2_, _NCP2_). AUTODOC experts recommend:
After applying the spray, wait a few minutes.
Step 27

Press in the brake caliper piston. Use brake caliper wind back tool.
Step 28

Install the brake caliper and fix it. Use a combination spanner #17. Use a drive socket #14. Use a torque wrench. Tighten it to 35 Nm torque.
Step 29

Treat the surface where the brake disc contacts the wheel rim. Use copper grease.
Step 30

Clean the brake disk surface. Use a brake cleaner.

AUTODOC recommends:
Replacement: brake discs – TOYOTA YARIS VERSO (_NLP2_, _NCP2_). After applying the spray, wait a few minutes.
Step 31

Install the wheel.

Replacement: brake discs – TOYOTA YARIS VERSO (_NLP2_, _NCP2_). Tip from AUTODOC:
To avoid injury, hold up the wheel when screwing in the fastening bolts.
Step 32

Screw in the wheel bolts. Use wheel impact socket #21.
Step 33

Lower the car and working in a cross order, tighten the wheel bolts. Use wheel impact socket #21. Use a torque wrench. Tighten it to 103 Nm torque.
Step 34

Remove the jacks and chocks.

AUTODOC recommends:
Important! Replacement: brake discs – TOYOTA YARIS VERSO (_NLP2_, _NCP2_). Check the brake fluid level in the reservoir and top up if necessary.
Step 35

Tighten the brake fluid reservoir cap. Without starting the engine, press the brake pedal several times until you feel significant resistance.

Step 36

Close the hood.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Searching for the right tyres?

Find out which tyre and wheel sizes are compatible with the TOYOTA Yaris Verso (P2) model.

Browse tyres

How to change front brake pads on TOYOTA Yaris Verso (P2) – replacement guide

Free download PDF
1.41 MB
How to change brake drum on TOYOTA Yaris Verso (_P2_) – replacement guide

Free download PDF
1.06 MB
How to change front wheel bearing on TOYOTA Yaris Verso (_P2_) – replacement guide

Free download PDF
2.53 MB
How to change rear wheel bearing on TOYOTA Yaris Verso (_P2_) – replacement guide

Free download PDF
1.13 MB
How to change serpentine belt on TOYOTA Yaris Verso (_P2_) – replacement guide

Free download PDF
819.2 KB
How to change spark plugs on TOYOTA Yaris Verso (_P2_) – replacement guide

Free download PDF
2.08 MB

How to change front brake discs on Toyota Yaris Mk2 – replacement guide

Free download PDF
2.01 MB
How to change rear brake discs on Toyota Yaris Mk2 – replacement guide

Free download PDF
2.01 MB
How to change front brake discs on Toyota Yaris P1 – replacement guide

Free download PDF
1.98 MB
How to change rear brake discs on TOYOTA Yaris Hatchback (_P13_) – replacement guide

Free download PDF
1.96 MB
How to change front brake discs on TOYOTA Yaris Hatchback (_P13_) – replacement guide

Free download PDF
1.93 MB
How to change rear brake discs on TOYOTA Yaris III Hatchback (XP150) – replacement guide

Free download PDF
1.95 MB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

What to do if the ABS light comes on | AUTODOC tips

6K views

Published on: 11/03/2021
Top 5 reasons why your car squeals | AUTODOC Tips

6K views

Published on: 26/10/2023
Replacing your engine cooling fan | AUTODOC tips

2K views

Published on: 15/11/2020
How to paint a brake caliper | AUTODOC tips

10K views

Published on: 08/04/2021