Recommended replacement interval for the part category Spark plug : 120000 km

Important!

This replacement procedure can be used for:
ALFA ROMEO SPIDER (939) 2.2 JTS (939EXB1B, 939EXB11) … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Spark Plug for SPIDER (939) and other ALFA ROMEO models

Alternative products

Spark plug

Replacement: spark plugs – ALFA ROMEO SPIDER (939). Tools you need:

                      Electronic spray
                    
                      High-temperature anti-seize lubricant
                    
                      Drive socket # 8 
                    
                      Drive socket # 10 
                    
                      Spark plug socket # 16
                    
                      Ratchet wrench
                    
                      Torque wrench
                    
                      Flat Screwdriver
                    
                      Fender cover

Buy tools

Replacement: spark plugs – ALFA ROMEO SPIDER (939). AUTODOC experts recommend:

The replacement procedure is the same for all spark plugs.
All work should be done with the engine stopped.

Replacement: spark plugs – ALFA ROMEO SPIDER (939). Use the following procedure:

Step 1

Open the hood.

Step 2

Use a fender protection cover to prevent damaging paintwork and plastic parts of the car.

Step 3

Undo the engine cover screws (4 pieces). Use a drive socket #8. Use a ratchet wrench.
Step 4

Remove the engine cover.
Step 5

Detach the connector from the ignition coil. Use a flat screwdriver.
Step 6

Unscrew the ignition coil bracket. Use a drive socket #10. Use a ratchet wrench.
Step 7

Take out the ignition coil from the spark plug well.
Step 8

Clean dirt, dust and debris from inside the spark plug wells. Unscrew the spark plugs. Use the spark plug socket #16. Use a ratchet wrench.

Step 9

Take out the spark plugs.
Step 10

Install the new spark plugs into their mounting seats.
Step 11

Screw new spark plugs and tighten them. Use the spark plug socket #16. Use a torque wrench. Tighten it to 22 nm torque.

Replacement: spark plugs – ALFA ROMEO SPIDER (939). AUTODOC recommends:
Don't tighten the plugs with excessive force. Exceeding tightening torque can damage the thread connection. Be careful when working with a spark plug wrench. Its skewing can cause damage to the threaded connection.
Step 12

Treat the mounting seats of the spark plugs on the ignition coil. Use high-temperature grease.
Step 13

Install the ignition coil to the spark plug well. Make sure you hear a click indicating that it is locked in place.
Step 14

Tighten the ignition coil fastening. Use a drive socket #10. Use a torque wrench. Tighten it to 8 nm torque.
Step 15

Treat the ignition coil connector with electronic spray. The spray will protect the electrical contacts from corrosion, oxidation, and will reduce the contact resistance.
Step 16

Plug in the ignition coil connector.
Step 17

Install the engine cover and secure it. Use a drive socket #8. Use a ratchet wrench.

Replacement: spark plugs – ALFA ROMEO SPIDER (939). Tip from AUTODOC:
Make sure the engine cover is properly seated. It should not be displaced with respect to the guiding fasteners and the throttle body air intake hose.
Step 18

Run the engine for a few minutes. This is necessary in order to make sure that the component operates properly.

Step 19

Shut off the engine.

Step 20

Remove the fender protection cover.

Step 21

Close the hood.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Need New Tyres?

Find out which tyre and wheel sizes are compatible with the ALFA ROMEO Spider (939) model

Alfa Romeo Spider 939 tyre size

How to change front brake pads on ALFA ROMEO Spider (939) – replacement guide

Free download PDF
1.89 MB
How to change rear brake pads on ALFA ROMEO SPIDER (939) – replacement guide

Free download PDF
1.57 MB
How to change rear brake discs on ALFA ROMEO SPIDER (939) – replacement guide

Free download PDF
2.18 MB
How to change front brake discs on ALFA ROMEO SPIDER (939) – replacement guide

Free download PDF
2.37 MB
How to change front wheel bearing on ALFA ROMEO SPIDER (939) – replacement guide

Free download PDF
3.64 MB
How to change rear wheel bearing on ALFA ROMEO SPIDER (939) – replacement guide

Free download PDF
2.4 MB

How to change spark plugs on ALFA ROMEO SPIDER (916S_) – replacement guide

Free download PDF
1.65 MB
How to change spark plugs on a car – replacement tutorial

Universal

Free download PDF
1.74 MB
How to change spark plugs on Alfa Romeo 147 937 – replacement guide

Free download PDF
1.96 MB
How to change spark plugs on Alfa Romeo 159 Sportwagon – replacement guide

Free download PDF
1.71 MB
How to change spark plugs on ALFA ROMEO Brera (939_) – replacement guide

Free download PDF
1.22 MB
How to change spark plugs on ALFA ROMEO 159 Saloon (939) – replacement guide

Free download PDF
1.22 MB

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

Top 5 Car Interior Cleaning Mistakes You Should Avoid | AUTODOC Tips

7K views

Published on: 26/05/2022
DIY starter repair | AUTODOC tips

131K views

Published on: 31/08/2023
Top 5 car noises you shouldn't ignore

6K views

Published on: 10/04/2025
Easy Steps to Fix Minor Scratches on Your Vehicle | AUTODOC tips

8K views

Published on: 12/05/2022