Recommended replacement interval for the part category Brake pad set : 30000 km

Important!

This replacement procedure can be used for:
VOLVO V50 (545) 1.6 D, VOLVO V50 (545) D4, VOLVO V50 (545) D3, VOLVO V50 (545) 2.4, VOLVO V50 (545) 2.4, VOLVO V50 (545) T5, VOLVO V50 (545) 2.0 D, VOLVO V50 (545) T5 AWD, VOLVO V50 (545) 1.8, VOLVO V50 (545) 1.6, VOLVO V50 (545) 2.0, VOLVO V50 (545) D5, VOLVO V50 (545) T5, VOLVO V50 (545) T5 AWD, VOLVO V50 (545) 1.8 FlexFuel, VOLVO V50 (545) 2.4 AWD, VOLVO V50 (545) 2.4 Tdi, VOLVO V50 (545) D2, VOLVO V50 (545) 2.0 FlexFuel, VOLVO V50 (545) 2.0 CDI, VOLVO V50 (545) 2.0 D4, VOLVO V50 (545) 1.8 BiFuel … View more

The steps may slightly vary depending on the car design.

How to change rear brake pads / rear brake pad set on VOLVO V50 1 (P12) [TUTORIAL AUTODOC]

Alternative products

Brake pad set

Replacement: brake pads – Volvo V50 MW. List of the tools you'll need:

                      Brake cleaner 
                    
                      Anti-squeal paste
                    
                      Copper grease 
                    
                      HEX bit no.H7.
                    
                      Wheel impact socket #19
                    
                      Brake caliper wind back tool
                    
                      Ratchet wrench
                    
                      Torque wrench
                    
                      Rubber mallet
                    
                      Crow bar
                    
                      Wheel chock

Buy tools

Replacement: brake pads – Volvo V50 MW. AUTODOC experts recommend:

Perform the replacement of brake pads in complete set for each axis. This provides effective braking.
The replacement procedure is identical for all brake pads on the same axle.
All work should be done with the engine stopped.

Replacement: brake pads – Volvo V50 MW. Use the following procedure:

Step 1

Open the bonnet. Unscrew the brake fluid reservoir cap.
Step 2

Secure the wheels with chocks.
Step 3

Loosen the wheel mounting bolts. Use wheel impact socket #19.
Step 4

Raise the rear of the car and secure on supports.
Step 5

Unscrew the wheel bolts.

AUTODOC recommends:
Warning! To avoid injury, hold the wheel while unscrewing the fastening bolts. Volvo V50 MW
Step 6

Remove the wheel.
Step 7

Remove the dust boot caps of the brake caliper guide pins. Use a crowbar.
Step 8

Unscrew the brake caliper fastening. Use HEX No.H7. Use a ratchet wrench.
Step 9

Detach the brake caliper retaining spring. Use a crowbar.
Step 10

Remove the brake caliper. Use a crowbar.

Replacement: brake pads – Volvo V50 MW. Professionals recommend:
Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
Step 11

Remove the brake pads. Use a crowbar.

Replacement: brake pads – Volvo V50 MW. Tip from AUTODOC:
Measure the brake disc thickness. Upon reaching the wear limit the part must be replaced.
Step 12

Treat the brake caliper piston. Use a brake cleaner.

AUTODOC recommends:
Replacement: brake pads – Volvo V50 MW. After applying the spray, wait a few minutes.
Step 13

Press in the brake caliper piston. Use brake caliper wind back tool.
Step 14

Treat the brake pads in the area where their surface comes into contact with the brake caliper bracket. Use anti-squeal paste.

Replacement: brake pads – Volvo V50 MW. Tip:
Make sure the disc surface is clean before installing the pads.
Step 15

Install new brake pads.

Replacement: brake pads – Volvo V50 MW. AUTODOC recommends:
Make sure the pads are installed with linings facing the disc.
Step 16

Install the brake caliper and fix it. Use HEX No.H7. Use a torque wrench. Tighten it to 35 Nm torque.
Step 17

Install the dust boot caps of the brake caliper guide pins.
Step 18

Install the brake caliper retaining spring. Use a rubber mallet.
Step 19

Treat the surface where the brake disc contacts the wheel rim. Use copper grease.
Step 20

Clean the brake disk surface. Use a brake cleaner.

Replacement: brake pads – Volvo V50 MW. Professionals recommend:
After applying the spray, wait a few minutes.
Step 21

Install the wheel.

AUTODOC recommends:
Warning! To avoid injury, hold the wheel while screwing in the fastening bolts on the car. Volvo V50 MW
Step 22

Screw in the wheel bolts. Use wheel impact socket #19.
Step 23

Lower the car and working in a cross order, tighten the wheel bolts. Use a torque wrench. Tighten it to 110 Nm torque.
Step 24

Remove the jacks and chocks.

AUTODOC recommends:
Important! Replacement: brake pads – Volvo V50 MW. Check the brake fluid level in the reservoir and top up if necessary.
Step 25

Tighten the brake fluid reservoir cap.

AUTODOC recommends:
Volvo V50 MW – Without starting the engine, press the brake pedal several times until it feels firm.
Step 26

Close the hood.

Replacement: brake pads – Volvo V50 MW. Tip from AUTODOC experts:
Slow down smoothly for first 150-200 km after the brake pads replacement. Avoid unneccessary and sharp braking to a stop.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Need New Tyres?

Find out which tyre and wheel sizes are compatible with the VOLVO V50 (MW, 545) model

Volvo V50 545 tyre size

How to change rear brake discs on Volvo V50 MW – replacement guide

Free download PDF
1.93 MB
How to change front brake discs on Volvo V50 MW – replacement guide

Free download PDF
2.05 MB
How to change front brake pads on Volvo V50 MW – replacement guide

Free download PDF
1.66 MB
How to change front windshield wipers on Volvo V50 MW – replacement guide

Free download PDF
604.16 KB
How to change rear windshield wipers on Volvo V50 MW – replacement guide

Free download PDF
1.32 MB
How to change engine oil and filter on Volvo V50 MW – replacement guide

Free download PDF
2.92 MB

How to change front brake pads on Volvo V50 MW – replacement guide

Free download PDF
1.66 MB
How to change brake pads on a car – replacement tutorial

Universal

Free download PDF
2.84 MB
How to change rear brake discs on Volvo V70 BW – replacement guide

Free download PDF
2.25 MB
How to change rear brake pads on Volvo XC90 1 – replacement guide

Free download PDF
1.83 MB
How to change front brake discs on Volvo V70 BW – replacement guide

Free download PDF
2.36 MB
How to change rear brake pads on Volvo V70 BW – replacement guide

Free download PDF
1.6 MB

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

5 most common causes of oil leaks | AUTODOC tips

69K views

Published on: 30/03/2023
TOP 6 WD-40 lifehacks | AUTODOC tips

13K views

Published on: 15/07/2021
How to choose the right engine oil for your car | AUTODOC

15K views

Published on: 01/07/2020
How to Get the Best Deals on Car Parts | Save Money with AUTODOC

2K views

Published on: 03/02/2022