When to replace the Brake Pads on your HYUNDAI SANTA FE
Recommended replacement interval for the part category Brake pad set : 30000 km
Important!
This replacement procedure can be used for:
HYUNDAI SANTA FÉ II (CM) 2.2 CRDi, HYUNDAI SANTA FÉ II (CM) 2.2 CRDi 4x4, HYUNDAI SANTA FÉ II (CM) 2.2 CRDi GLS, HYUNDAI SANTA FÉ II (CM) 2.2 CRDi GLS 4x4, HYUNDAI SANTA FÉ II (CM) 2.2 CRDi 4x4, HYUNDAI SANTA FÉ II (CM) 2.7 4x4, HYUNDAI SANTA FÉ II (CM) 2.7, HYUNDAI SANTA FÉ II (CM) 2.7 V6 GLS, HYUNDAI SANTA FÉ II (CM) 2.7 V6 GLS 4x4, HYUNDAI SANTA FÉ II (CM) 2.7 4x4 View more

The steps may slightly vary depending on the car design.

How to change rear brake discs and rear brake pads on HYUNDAI SANTA FÉ CM TUTORIAL | AUTODOC

video
All the parts you need to replace – Brake Pads for SANTA FÉ II (CM) and other HYUNDAI models
Tools
Replacement: brake pads – Hyundai Santa Fe CM. Tools you might need:
Wire brush
Nylon cleaning brush
WD-40 spray
Brake cleaner
Anti-squeal paste
Copper grease
Torque wrench
Combination spanner #17
Drive socket # 14
Wheel impact socket #21
Ratchet wrench
Brake caliper wind back tool
Crow bar
Wheel chock
Replacement: brake pads – Hyundai Santa Fe CM. Tip from AUTODOC:
  • Perform the replacement of brake pads in complete set for each axis. This provides effective braking.
  • The replacement procedure is identical for all brake pads on the same axle.
  • Please note: all work on the car – Hyundai Santa Fe CM – should be done with the engine switched off.
Carry out replacement in the following order:
  1. Step 1
    How to change Brake Pads on Hyundai Santa Fe cm 2005 - free PDF and video manuals
    Open the hood. Unscrew the brake fluid reservoir cap.
  2. Step 2
    How to replace HYUNDAI SANTA FÉ II (CM) 2.2 CRDi 4x4 2006 Brake Pads - step-by-step manuals and video guides
    Secure the wheels with chocks.
  3. Step 3
    Hyundai Santa Fe cm 2.2 CRDi GLS 4x4 2007 Brake Pads replacement: free workshop manuals
    Loosen the wheel mounting bolts. Use wheel impact socket #21.
  4. Step 4
    Changing Brake Pads on HYUNDAI SANTA FÉ II (CM) 2.7 V6 GLS 4x4 2008 by yourself
    Raise the rear of the car and secure on supports.
  5. Step 5
    How to remove HYUNDAI SANTA FE 2.2 CRDi GLS 2009 Brake Pads - online easy-to-follow instructions
    Unscrew the wheel bolts.
    AUTODOC recommends:
    Warning! To avoid injury, hold the wheel while unscrewing the fastening bolts. Hyundai Santa Fe CM
  6. Step 6
    How to replace Brake Pads on HYUNDAI SANTA FÉ II (CM) 2010: download PDF manuals and video instructions
    Remove the wheel.
  7. Step 7
    Clean the brake caliper fasteners. Use a wire brush. Use WD-40 spray.
    Step 8
    How hard is it to do yourself: Brake Pads replacement on Hyundai Santa Fe cm 2.4 4x4 2011 - download illustrated guide
    Unscrew the brake caliper fastening. Use a combination spanner #17. Use a drive socket #14. Use a ratchet wrench.
  8. Step 9
    Remove the guide pins from the old brake caliper.
    Step 10
    Spread the brake pads. Use a crowbar.
    Step 11
    Need to know how to renew Brake Pads on HYUNDAI SANTA FE 2012? This free workshop manual will help you to do it yourself
    Remove the brake caliper. Use a crowbar.
    Replacement: brake pads – Hyundai Santa Fe CM. Tip:
    Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
  9. Step 12
    Changing of Brake Pads on Hyundai Santa Fe cm 2005 won't be an issue if you follow this illustrated step-by-step guide
    Remove the brake pads.
    Replacement: brake pads – Hyundai Santa Fe CM. Tip from AUTODOC experts:
    Measure the brake disc thickness. Upon reaching the wear limit the part must be replaced.
  10. Step 13
    Remove the brake pads retaining clips.
    Step 14
    HYUNDAI SANTA FE 2.2 CRDi GLS 4x4 Brake Pads replacement: online guides and video tutorials
    Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.
    AUTODOC recommends:
    Replacement: brake pads – Hyundai Santa Fe CM. After applying the spray, wait a few minutes.
  11. Step 15
    Replacing Brake Pads on Hyundai Santa Fe cm 2007 2.2 CRDi 4x4 by yourself
    Treat the brake pads in the area where their surface comes into contact with the brake caliper bracket. Use anti-squeal paste.
    Replacement: brake pads – Hyundai Santa Fe CM. AUTODOC experts recommend:
    Make sure the disc surface is clean before installing the pads.
  12. Step 16
    Install the brake pads retaining clips.
    Step 17
    SANTA FÉ II (CM) 2.2 CRDi GLS 2008 Brake Pads DIY replacement workshop manual
    Install new brake pads.
    Replacement: brake pads – Hyundai Santa Fe CM. Tip:
    Make sure the pads are installed with linings facing the disc.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
Users voted – 0
Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!
Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.
HYUNDAI SANTA FÉ II (CM) Brake Pads replace by yourself - Scan QR-code and download AUTODOC CLUB app
Scan

To download the app:

  • - scan the QR code
  • - download from App Store
  • - download from Google Play
DIY HYUNDAI SANTA FÉ II (CM) Brake Pads replacement - online guide
Tips & tricks for your HYUNDAI SANTA FÉ II (CM)
View more
  • How to change Brake pad set on HYUNDAI SANTA FÉ II (CM) 2.2 CRDi - replacement tricks
    How to check your head gasket | AUTODOC
  • Changing Disc pads Hyundai Santa Fe cm 2.2 CRDi 4x4 - Replacement Tips
    Checking the starter without removing it | AUTODOC tips
  • Maintenance Hacks - HYUNDAI SANTA FÉ II (CM) 2.2 CRDi GLS 4x4 Brake pad kit replacement guide
    How and why to check your oil | AUTODOC tips
  • Replace Disc brake pads on Hyundai Santa Fe cm - free video tips
    How to wash your car in winter | AUTODOC tips