Recommended replacement interval for the part category Brake pad set : 30000 km

Important!

This replacement procedure can be used for:
FORD FOCUS III Saloon 1.6 Ti, FORD FOCUS III Saloon 1.6 Ti, FORD FOCUS III Saloon 1.6 Flexifuel, FORD FOCUS III Saloon 1.6 EcoBoost, FORD FOCUS III Saloon 1.6 EcoBoost, FORD FOCUS III Saloon 1.6 TDCi, FORD FOCUS III Saloon 1.6 TDCi, FORD FOCUS III Saloon 2.0 TDCi, FORD FOCUS III Saloon 2.0 TDCi, FORD FOCUS III Saloon 2.0 TDCi, FORD FOCUS III Saloon 1.6 Ti, FORD FOCUS III Saloon 1.0 EcoBoost, FORD FOCUS III Saloon 1.0 EcoBoost, FORD FOCUS III Saloon 2.0 TDCi, FORD FOCUS III Saloon 1.6 Flexifuel, FORD FOCUS III Saloon 2.0, FORD FOCUS III Saloon 1.5 EcoBoost, FORD FOCUS III Saloon 1.5 EcoBoost, FORD FOCUS III Saloon 1.5 TDCi, FORD FOCUS III Saloon 1.5 TDCi ECOnetic, FORD FOCUS III Saloon 1.5 TDCi, FORD FOCUS III Saloon 2.0 TDCi, FORD FOCUS III Saloon 1.6 TDCi, FORD FOCUS III Saloon 1.0 EcoBoost … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Brake Pads for FOCUS III Saloon and other FORD models

Alternative products

Brake pad set

Replacement: brake pads – FORD FOCUS III Saloon. Tools you might need:

                      Wire brush
                    
                      WD-40 spray
                    
                      Brake cleaner
                    
                      Anti-squeal paste
                    
                      Brake caliper guide pins grease
                    
                      Copper grease
                    
                      HEX bit no.H7.
                    
                      Wheel impact socket #19
                    
                      Ratchet wrench
                    
                      Torque wrench
                    
                      Brake caliper wind back tool
                    
                      Flat Screwdriver
                    
                      Crow bar
                    
                      Wheel chock

Buy tools

Replacement: brake pads – FORD FOCUS III Saloon. AUTODOC recommends:

Perform the replacement of brake pads in complete set for each axis. This provides effective braking.
The replacement procedure is identical for all brake pads on the same axle.
All work should be done with the engine stopped.

Replacement: brake pads – FORD FOCUS III Saloon. Use the following procedure:

Step 1

Open the bonnet. Unscrew the brake fluid reservoir cap.

Step 2

Secure the wheels with chocks.
Step 3

Loosen the wheel mounting bolts. Use wheel impact socket #19.
Step 4

Raise the rear of the car and secure on supports.

Step 5

Unscrew the wheel bolts.

Replacement: brake pads – FORD FOCUS III Saloon. Tip:
To avoid injury, hold up the wheel when unscrewing the bolts.
Step 6

Remove the wheel.
Step 7

Detach the brake caliper retaining spring. Use a flat screwdriver.
Step 8

Remove the dust boot caps of the brake caliper guide pins. Use a flat screwdriver.
Step 9

Unscrew the brake caliper fastening. Use HEX No.H7. Use a ratchet wrench.
Step 10

Remove the guide pins from the brake caliper.

Step 11

Spread the brake pads. Use a crowbar.
Step 12

Remove the brake caliper.

Replacement: brake pads – FORD FOCUS III Saloon. AUTODOC experts recommend:
Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur.Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
Step 13

Remove the brake pads.

Replacement: brake pads – FORD FOCUS III Saloon. Tip from AUTODOC:
Measure the brake disc thickness. Upon reaching the wear limit the part must be replaced.
Step 14

Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.

AUTODOC recommends:
Replacement: brake pads – FORD FOCUS III Saloon. After applying the spray, wait a few minutes.
Step 15

Treat the brake pads in the area where their surface comes into contact with the brake caliper bracket. Use anti-squeal paste.

Replacement: brake pads – FORD FOCUS III Saloon. Tip from AUTODOC experts:
Make sure the disc surface is clean before installing the pads.
Step 16

Install new brake pads.

Replacement: brake pads – FORD FOCUS III Saloon. Tip:
Make sure the pads are installed with linings facing the disc.
Step 17

Treat the brake caliper piston. Use a brake cleaner.

AUTODOC recommends:
Replacement: brake pads – FORD FOCUS III Saloon. After applying the spray, wait a few minutes.
Step 18

Press in the brake caliper piston. Use brake caliper wind back tool.
Step 19

Install the brake caliper and fix it.
Step 20

Clean the brake caliper guide pins.
Step 21

Treat the brake caliper guide pins. Use the brake caliper guide pin grease.
Step 22

Screw in the guide pins.
Step 23

Tighten the brake caliper fasteners. Use HEX No.H7. Use a torque wrench. Tighten it to 35 Nm torque.
Step 24

Install the dust boot caps of the brake caliper guide pins.
Step 25

Install the brake caliper retaining spring. Use a flat screwdriver.
Step 26

Treat the surface where the brake disc contacts the wheel rim. Use copper grease.
Step 27

Clean the brake disk surface. Use a brake cleaner.

Replacement: brake pads – FORD FOCUS III Saloon. AUTODOC recommends:
After applying the spray, wait a few minutes.
Step 28

Install the wheel.

AUTODOC recommends:
Important! Hold the wheel while screwing in the fastening bolts. FORD FOCUS III Saloon
Step 29

Screw in the wheel bolts. Use wheel impact socket #19.
Step 30

Lower the car and working in a cross order, tighten the wheel bolts. Use wheel impact socket #19. Use a torque wrench. Tighten it to 120 Nm torque.
Step 31

Remove the jacks and chocks.

Replacement: brake pads – FORD FOCUS III Saloon. Professionals recommend:
Check the brake fluid level in the expansion tank and refill if necessary.
Step 32

Tighten the brake fluid reservoir cap. Close the hood.

AUTODOC recommends:
FORD FOCUS III Saloon – Without starting the engine, press the brake pedal several times until it feels firm.Slow down smoothly for first 150-200 km after the brake pads replacement. Avoid unneccessary and sharp braking to a stop.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Need New Tyres?

Find out which tyre and wheel sizes are compatible with the FORD Focus Mk3 Saloon (DYB) model

Ford Focus mk3 Saloon tyre size

How to change front brake pads on FORD Focus Mk3 Saloon (DYB) – replacement guide

Free download PDF
2.36 MB
How to change front brake caliper on FORD FOCUS III Saloon – replacement guide

Free download PDF
2.11 MB
How to change serpentine belt on FORD FOCUS III Saloon – replacement guide

Free download PDF
768 KB
How to change spark plugs on FORD FOCUS III Saloon – replacement guide

Free download PDF
931.84 KB
How to change rear windshield wipers on FORD FOCUS III Saloon – replacement guide

Free download PDF
614.4 KB
How to change engine oil and filter on FORD Focus Mk3 Saloon (DYB) – replacement guide

Free download PDF
2.39 MB

How to change front brake pads on FORD Focus Mk3 Hatchback (DYB) – replacement guide

Free download PDF
2.36 MB
How to change rear brake pads on FORD FOCUS III – replacement guide

Free download PDF
1.72 MB
How to change front brake pads on FORD Focus Mk2 Hatchback (DA_, HCP, DP) – replacement guide

Free download PDF
2.36 MB
How to change rear brake pads on FORD Focus II Hatchback (DA_, HCP, DP) – replacement guide

Free download PDF
1.72 MB
How to change front brake pads on Ford Focus DAW – replacement guide

Free download PDF
1.79 MB
How to change rear brake pads on Ford Focus DAW – replacement guide

Free download PDF
1.69 MB

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

5 Essential Tips for beginner drivers: Avoid Common Mistakes

4K views

Published on: 31/01/2023
Regain Your Confidence on the Road: Easy Headlight Restoration Tips

9K views

Published on: 04/07/2024
Checking the starter without removing it | AUTODOC tips

27K views

Published on: 01/12/2020
Stop Rust Before It Starts: Top 5 Tips for Car Body Protection | AUTODOC Insights

7K views

Published on: 27/07/2023