How to carry out replacement: Brake Pads 1.6 TDCi Ford Focus 2 da
Disclaimer
Change Ford Focus 2 da 2.0 LPG Brake Pads yourself – manuals and video tutorials

How to change rear brake pads on FORD Focus II Estate (DA_, FFS, DS) – replacement guide

downloads: 1
Views: 11
Download your free tutorial and fix FORD Focus II Estate (DA_, FFS, DS) 1.8 problems yourself Download for free 1.72 MB Brake Pads for Ford Focus 2 da Shop now
Leave a comment Open in a new tab
When to replace the Brake Pads on your FORD FOCUS
Recommended replacement interval for the part category Brake pad set : 30000 km
Important!
This replacement procedure can be used for:
FORD Focus II Estate (DA_, FFS, DS) 1.6 TDCi, FORD Focus II Estate (DA_, FFS, DS) 2.0 TDCi, FORD Focus II Estate (DA_, FFS, DS) 1.6 TDCi, FORD Focus II Estate (DA_, FFS, DS) 1.4, FORD Focus II Estate (DA_, FFS, DS) 1.6, FORD Focus II Estate (DA_, FFS, DS) 1.6 Ti, FORD Focus II Estate (DA_, FFS, DS) 2.0, FORD Focus II Estate (DA_, FFS, DS) 1.6 TDCi, FORD Focus II Estate (DA_, FFS, DS) 2.0 TDCi, FORD Focus II Estate (DA_, FFS, DS) 1.6 TDCi, FORD Focus II Estate (DA_, FFS, DS) 1.8 TDCi, FORD Focus II Estate (DA_, FFS, DS) 1.8 Flexifuel, FORD Focus II Estate (DA_, FFS, DS) 2.0 TDCi, FORD Focus II Estate (DA_, FFS, DS) 1.8, FORD Focus II Estate (DA_, FFS, DS) 2.0 LPG, FORD Focus II Estate (DA_, FFS, DS) 1.6 LPG … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Brake Pads for Focus II Estate (DA_, FFS, DS) and other FORD models
Alternative products
How to change Brake pad set on Ford Focus 2 da 1.6 TDCi – step-by-step instructions for straightforward car repair Brake pad set
Tools
Replacement: brake pads – FORD FOCUS II Estate (DA_). Tools you might need:
Wire brush
WD-40 spray
Brake cleaner
Anti-squeal paste
Brake caliper guide pins grease
Copper grease
HEX bit no.H7.
Wheel impact socket #19
Ratchet wrench
Torque wrench
Brake caliper wind back tool
Flat Screwdriver
Crow bar
Wheel chock
Buy tools
Replacement: brake pads – FORD FOCUS II Estate (DA_). AUTODOC recommends:
  • Perform the replacement of brake pads in complete set for each axis. This provides effective braking.
  • The replacement procedure is identical for all brake pads on the same axle.
  • All work should be done with the engine stopped.
Replacement: brake pads – FORD FOCUS II Estate (DA_). Use the following procedure:
  1. Step 1
    Open the bonnet. Unscrew the brake fluid reservoir cap.
    Step 2
    How to change Brake Pads on Ford Focus 2 da 2004 - free PDF and video manuals
    Secure the wheels with chocks.
  2. Step 3
    How to replace FORD Focus II Estate (DA_, FFS, DS) 1.6 TDCi 2005 Brake Pads - step-by-step manuals and video guides
    Loosen the wheel mounting bolts. Use wheel impact socket #19.
  3. Step 4
    Raise the rear of the car and secure on supports.
    Step 5
    Ford Focus 2 da 1.6 2006 Brake Pads replacement: free workshop manuals
    Unscrew the wheel bolts.
    Replacement: brake pads – FORD FOCUS II Estate (DA_). Tip:
    To avoid injury, hold up the wheel when unscrewing the bolts.
  4. Step 6
    Changing Brake Pads on FORD Focus II Estate (DA_, FFS, DS) 1.8 TDCi 2007 by yourself
    Remove the wheel.
  5. Step 7
    How to remove FORD FOCUS 1.6 Ti 2008 Brake Pads - online easy-to-follow instructions
    Detach the brake caliper retaining spring. Use a flat screwdriver.
  6. Step 8
    How to replace Brake Pads on FORD Focus II Estate (DA_, FFS, DS) 2009: download PDF manuals and video instructions
    Remove the dust boot caps of the brake caliper guide pins. Use a flat screwdriver.
  7. Step 9
    How hard is it to do yourself: Brake Pads replacement on Ford Focus 2 da 2.0 2010 - download illustrated guide
    Unscrew the brake caliper fastening. Use HEX No.H7. Use a ratchet wrench.
  8. Step 10
    Remove the guide pins from the brake caliper.
    Step 11
    Need to know how to renew Brake Pads on FORD FOCUS 2011? This free workshop manual will help you to do it yourself
    Spread the brake pads. Use a crowbar.
  9. Step 12
    Changing of Brake Pads on Ford Focus 2 da 2012 won't be an issue if you follow this illustrated step-by-step guide
    Remove the brake caliper.
    Replacement: brake pads – FORD FOCUS II Estate (DA_). AUTODOC experts recommend:
    Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur.Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
  10. Step 13
    FORD FOCUS 2.0 LPG Brake Pads replacement: online guides and video tutorials
    Remove the brake pads.
    Replacement: brake pads – FORD FOCUS II Estate (DA_). Tip from AUTODOC:
    Measure the brake disc thickness. Upon reaching the wear limit the part must be replaced.
  11. Step 14
    Replacing Brake Pads on Ford Focus 2 da 2005 1.6 TDCi by yourself
    Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.
    AUTODOC recommends:
    Replacement: brake pads – FORD FOCUS II Estate (DA_). After applying the spray, wait a few minutes.
  12. Step 15
    Focus II Estate (DA_, FFS, DS) 1.6 Ti 2006 Brake Pads DIY replacement workshop manual
    Treat the brake pads in the area where their surface comes into contact with the brake caliper bracket. Use anti-squeal paste.
    Replacement: brake pads – FORD FOCUS II Estate (DA_). Tip from AUTODOC experts:
    Make sure the disc surface is clean before installing the pads.
  13. Step 16
    How to change Brake Pads on FORD Focus II Estate (DA_, FFS, DS) 2007 - tips and tricks
    Install new brake pads.
    Replacement: brake pads – FORD FOCUS II Estate (DA_). Tip:
    Make sure the pads are installed with linings facing the disc.
  14. Step 17
    Treat the brake caliper piston. Use a brake cleaner.
    AUTODOC recommends:
    Replacement: brake pads – FORD FOCUS II Estate (DA_). After applying the spray, wait a few minutes.
    Step 18
    Step-by-step recommendations for DIY replacement Ford Focus 2 da 2008 1.6 Ti Brake Pads
    Press in the brake caliper piston. Use brake caliper wind back tool.
  15. Step 19
    DIY replacement of Brake Pads on FORD Focus II Estate (DA_, FFS, DS) 1.8 Flexifuel 2009 is not an issue anymore with our step-by-step tutorial
    Install the brake caliper and fix it.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
Users voted – 0
Need New Tyres?

Find out which tyre and wheel sizes are compatible with the FORD Focus Mk2 Estate (DA_, FFS, DS) model

Ford Focus 2 da tyre size

Popular maintenance tutorials for Ford Focus 2 da

More manuals for Ford Focus 2 da

Complete guides for changing the Brake pad set on different FORD FOCUS models

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

DIY FORD Focus II Estate (DA_, FFS, DS) Brake Pads replacement - online guide
Tips & tricks for your FORD Focus II Estate (DA_, FFS, DS)
View more
  • How to change Brake pad set on FORD Focus II Estate (DA_, FFS, DS) 1.8 Flexifuel - replacement tricks
    #DIY Tips for Fixing Your Car's Air Conditioning Issues | Don't Wait for Costly Repairs!
    7K views
    Published on: 05/08/2021
  • Changing Disc pads Ford Focus 2 da 1.6 TDCi - Replacement Tips
    Engine Overheating? Replace Your Cooling Fan to Fix It
    7K views
    Published on: 15/11/2020
  • Maintenance Hacks - FORD Focus II Estate (DA_, FFS, DS) 1.6 Brake pad kit replacement guide
    Prevent Engine Damage: How to Identify Rocker Cover Gasket Issues and Proper Replacement | AUTODOC
    6K views
    Published on: 03/12/2020
  • Replace Disc brake pads on Ford Focus 2 da - free video tips
    DIY rear axle restoration | Drivetrain restoration – Part 2
    7K views
    Published on: 07/11/2024

Most commonly replaced car parts on FORD FOCUS

Professional manuals for the most common FORD models

ОЕ number
Autodoc CLUB App icon
Time to replace parts? Get even better deals in our Shop app.
FORD Focus II Estate (DA_, FFS, DS) Brake Pads replace by yourself - Scan QR-code and download AUTODOC CLUB app
SCAN ME