Recommended replacement interval for the part category Brake disc : 50000 km

Important!

This replacement procedure can be used for:
RENAULT KOLEOS (HY_) 2.0 dCi (HY0K), RENAULT KOLEOS (HY_) 2.0 dCi 4x4 (HY0K), RENAULT KOLEOS (HY_) 2.0 dCi 4x4 (HY0B), RENAULT KOLEOS (HY_) 2.5 (HY0C, HY0N), RENAULT KOLEOS (HY_) 2.5 4x4 (HY0C, HY0N), RENAULT KOLEOS (HY_) 2.0, RENAULT KOLEOS (HY_) 2.0 dCi 4x4, RENAULT KOLEOS (HY_) 2.0 dCi … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

Alternative products

Brake disc

Replacement: brake discs – RENAULT KOLEOS (HY_). List of the tools you'll need:

                      Wire brush
                    
                      Nylon cleaning brush
                    
                      WD-40 spray
                    
                      Brake cleaner 
                    
                      Anti-squeal paste
                    
                      Brake caliper guide pins grease
                    
                      Ceramic grease
                    
                      Torque wrench
                    
                      Drive socket # 14
                    
                      Drive socket # 19
                    
                      Wheel impact socket #21
                    
                      Ratchet wrench
                    
                      Brake caliper wind back tool
                    
                      Flat screwdriver
                    
                      Wheel chock

Buy tools

AUTODOC recommends:

Replace the brake disks on the car RENAULT KOLEOS (HY_) in complete set for each axis. Regardless of the state of components. This will ensure even braking.
The replacement procedure is identical for both brake disks on the same axle.
When changing the brake discs, always replace the brake pads.
Please note: all work on the car – RENAULT KOLEOS (HY_) – should be done with the engine switched off.

Carry out replacement in the following order:

Step 1

Open the bonnet. Unscrew the brake fluid reservoir cap.
Step 2

Secure the wheels with chocks.

Step 3

Loosen the wheel mounting bolts. Use wheel impact socket #21.
Step 4

Raise the car.

Replacement: brake discs – RENAULT KOLEOS (HY_). Tip from AUTODOC:
If you are using a jack, make sure it rests on a flat surface without any unevenness.Be sure to additionally secure the car with jack stands.
Step 5

Unscrew the wheel bolts.

AUTODOC recommends:
Warning! To avoid injury, hold the wheel while unscrewing the fastening bolts. RENAULT KOLEOS (HY_)
Step 6

Remove the wheel.
Step 7

Clean the brake caliper fasteners. Use a wire brush. Use WD-40 spray.
Step 8

Unscrew the brake caliper fasteners. Use a drive socket #14. Use a ratchet wrench.
Step 9

Remove the brake caliper guide pins.
Step 10

Remove the brake caliper.

Replacement: brake discs – RENAULT KOLEOS (HY_). Tip from AUTODOC experts:
Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur.
Step 11

Remove the brake pads.
Step 12

Clean the brake caliper bracket fasteners. Use a wire brush. Use WD-40 spray.
Step 13

Unscrew the brake caliper bracket fasteners. Use a drive socket #19. Use a ratchet wrench.
Step 14

Remove the fastening bolts.

Step 15

Remove the caliper bracket.
Step 16

Remove the rubber plug. Use a flat screwdriver.
Step 17

Release the parking brake adjuster. Use a flat screwdriver.
Step 18

Remove the brake disc.
Step 19

Clean the hub. Use a wire brush.
Step 20

Treat the contacting surface. Use ceramic grease.
Step 21

Install the brake disc.
Step 22

Set the parking brake adjuster in the correct position. Use a flat screwdriver.
Step 23

Install the rubber plug. Use a flat screwdriver.
Step 24

Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.

AUTODOC recommends:
Replacement: brake discs – RENAULT KOLEOS (HY_). After applying the spray, wait a few minutes.Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
Step 25

Install the brake caliper bracket.
Step 26

Install the fastening bolts.
Step 27

Tighten the brake caliper bracket fasteners. Use a drive socket #19. Use a torque wrench. Tighten it to 80 nm torque.
Step 28

Treat the brake caliper piston. Use a nylon cleaning brush. Use a brake cleaner.

AUTODOC recommends:
After applying the spray, wait a few minutes.
Step 29

Press in the brake caliper piston. Use brake caliper wind back tool.
Step 30

Treat the brake pads in the area where their surface comes into contact with the brake caliper bracket. Use anti-squeal paste.

Replacement: brake discs – RENAULT KOLEOS (HY_). Professionals recommend:
Make sure the disc surface is clean before installing the pads.
Step 31

Install the brake pads.
Step 32

Clean the brake caliper guide pins. Use a brake cleaner.

AUTODOC recommends:
After applying the spray, wait a few minutes.
Step 33

Treat the brake caliper guide pins. Use the brake caliper guide pin grease.
Step 34

Install the brake caliper and fix it.
Step 35

Install the brake caliper guide pins.
Step 36

Tighten the brake caliper fasteners. Use a drive socket #14. Use a torque wrench. Tighten it to 32 Nm torque.
Step 37

Treat the surface where the brake disc contacts the wheel rim. Use ceramic grease.
Step 38

Clean the brake disk surface. Use a brake cleaner.

AUTODOC recommends:
Replacement: brake discs – RENAULT KOLEOS (HY_). After applying the spray, wait a few minutes.
Step 39

Install the wheel.

AUTODOC recommends:
Warning! To avoid injury, hold the wheel while screwing in the fastening bolts on the car. RENAULT KOLEOS (HY_)
Step 40

Screw in the wheel bolts. Use wheel impact socket #21.
Step 41

Lower the car and working in a cross order, tighten the wheel bolts. Use wheel impact socket #21. Use a torque wrench. Tighten it to 118 Nm torque.
Step 42

Remove the jacks and chocks.

Replacement: brake discs – RENAULT KOLEOS (HY_). AUTODOC recommends:
Without starting the engine, press the brake pedal several times until you feel significant resistance.Check the brake fluid level in the expansion tank and refill if necessary.
Step 43

Tighten the brake fluid reservoir cap. Close the hood.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Need New Tyres?

Find out which tyre and wheel sizes are compatible with the RENAULT Koleos I (HY) model

Renault Koleos 1 tyre size

How to change rear brake pads on RENAULT KOLEOS (HY_) – replacement guide

Free download PDF
1.73 MB
How to change front wheel bearing on RENAULT KOLEOS (HY_) – replacement guide

Free download PDF
3.86 MB
How to change spark plugs on RENAULT KOLEOS (HY_) – replacement guide

Free download PDF
2.02 MB
How to change front windshield wipers on RENAULT KOLEOS (HY_) – replacement guide

Free download PDF
512 KB
How to change engine oil and filter on RENAULT KOLEOS (HY_) – replacement guide

Free download PDF
1.54 MB
How to change front anti roll bar links on RENAULT KOLEOS (HY_) – replacement guide

Free download PDF
1.28 MB

How to change front brake discs on RENAULT Koleos II (HC_) – replacement guide

Free download PDF
1.78 MB
How to change brake discs on a car – replacement tutorial

Universal

Free download PDF
2.92 MB
How to change front brake discs on Renault Clio 2 – replacement guide

Free download PDF
1.99 MB
How to change front brake discs on Renault Megane Scenic – replacement guide

Free download PDF
2.61 MB
How to change front brake discs on Renault Twingo C06 – replacement guide

Free download PDF
1.72 MB
How to change rear brake discs on Renault Megane 2 – replacement guide

Free download PDF
2.08 MB

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

BMW E30 Turbo Suspension Swap: Boost Your Handling | AUTODOC project

2K views

Published on: 04/03/2021
The Ultimate Guide to Engine Bay Cleaning | AUTODOC

6K views

Published on: 11/09/2020
7 signs of faulty fuel injectors | AUTODOC tips

10K views

Published on: 09/01/2025
What to do if your check engine light is on | AUTODOC tips

19K views

Published on: 19/08/2020