When to replace the Brake Discs on your FORD FOCUS
Recommended replacement interval for the part category Brake disc : 50000 km
Important!
This replacement procedure can be used for:
FORD FOCUS Estate (DNW) 1.8 TDCi, FORD FOCUS Estate (DNW) 1.8 TDCi, FORD FOCUS Estate (DNW) 1.8 DI / TDDi, FORD FOCUS Estate (DNW) 1.8 Turbo DI / TDDi, FORD FOCUS Estate (DNW) 2.0 16V, FORD FOCUS Estate (DNW) 1.8 16V, FORD FOCUS Estate (DNW) 1.6 16V, FORD FOCUS Estate (DNW) 1.4 16V View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Brake Discs for FOCUS Estate (DNW) and other FORD models
Tools
Replacement: brake discs – FORD FOCUS Estate (DNW). List of the tools you'll need:
Wire brush
Nylon cleaning brush
WD-40 spray
Brake cleaner
Copper grease
Torque wrench
Combination spanner #15
Drive socket # 13
Wheel impact socket #19
Brake caliper wind back tool
Ratchet wrench
Tap wrench
Rubber mallet
Water pump pliers
Crow bar
Hand operated fluid syringe
Wheel chock
Replacement: brake discs – FORD FOCUS Estate (DNW). AUTODOC experts recommend:
  • Replace the brake disks on the car FORD FOCUS Estate (DNW) in complete set for each axis. Regardless of the state of components. This will ensure even braking.
  • The replacement procedure is identical for both brake disks on the same axle.
  • When changing the brake discs, always replace the brake pads.
  • Please note: all work on the car – FORD FOCUS Estate (DNW) – should be done with the engine switched off.
Carry out replacement in the following order:
  1. Step 1
    Open the bonnet. Unscrew the brake fluid reservoir cap.
    Replacement: brake discs – FORD FOCUS Estate (DNW). Professionals recommend:
    Pump out any excess brake fluid.
    Step 2
    Secure the wheels with chocks.
    Step 3
    How to change Brake Discs on Ford Focus dnw 1999 - free PDF and video manuals
    Loosen the wheel mounting bolts. Use wheel impact socket #19.
  2. Step 4
    Raise the rear of the car and secure on supports.
    Step 5
    How to replace FORD FOCUS Estate (DNW) 1.6 16V 2000 Brake Discs - step-by-step manuals and video guides
    Unscrew the wheel bolts.
    AUTODOC recommends:
    Warning! To avoid injury, hold the wheel while unscrewing the fastening bolts. FORD FOCUS Estate (DNW)
  3. Step 6
    Ford Focus dnw 1.8 Turbo DI / TDDi 2001 Brake Discs replacement: free workshop manuals
    Remove the wheel.
  4. Step 7
    Changing Brake Discs on FORD FOCUS Estate (DNW) 1.8 TDCi 2002 by yourself
    Release the parking brake cable. Use water pump pliers.
  5. Step 8
    How to remove FORD FOCUS 1.6 16V Flexifuel 2003 Brake Discs - online easy-to-follow instructions
    Clean the brake caliper fasteners. Use a wire brush. Use WD-40 spray.
  6. Step 9
    How to replace Brake Discs on FORD FOCUS Estate (DNW) 2004: download PDF manuals and video instructions
    Unscrew the brake caliper fastening. Use a combination spanner #15. Use a drive socket #13. Use a ratchet wrench.
  7. Step 10
    How hard is it to do yourself: Brake Discs replacement on Ford Focus dnw 2.0 16V 2005 - download illustrated guide
    Spread the brake pads. Use a crowbar.
  8. Step 11
    Need to know how to renew Brake Discs on FORD FOCUS 2006? This free workshop manual will help you to do it yourself
    Remove the brake caliper.
    Replacement: brake discs – FORD FOCUS Estate (DNW). AUTODOC experts recommend:
    Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
  9. Step 12
    Changing of Brake Discs on Ford Focus dnw 2007 won't be an issue if you follow this illustrated step-by-step guide
    Remove the brake pads.
  10. Step 13
    FORD FOCUS ST170 2.0 Brake Discs replacement: online guides and video tutorials
    Clean the brake caliper bracket fasteners. Use a wire brush. Use WD-40 spray.
  11. Step 14
    Replacing Brake Discs on Ford Focus dnw 2000 1.6 16V by yourself
    Unscrew the caliper bracket fastening. Use a drive socket #13. Use a tap wrench.
  12. Step 15
    FOCUS Estate (DNW) 1.6 16V Flexifuel 2001 Brake Discs DIY replacement workshop manual
    Remove the caliper bracket.
  13. Step 16
    How to change Brake Discs on FORD FOCUS Estate (DNW) 2002 - tips and tricks
    Clean the brake disc fastener. Use a wire brush. Use WD-40 spray.
  14. Step 17
    Step-by-step recommendations for DIY replacement Ford Focus dnw 2003 1.6 16V Flexifuel Brake Discs
    Unscrew the brake disc fastening. Use a crowbar.
  15. Step 18
    DIY replacement of Brake Discs on FORD FOCUS Estate (DNW) 1.8 16V 2004 is not an issue anymore with our step-by-step tutorial
    Remove the brake disc.
    Replacement: brake discs – FORD FOCUS Estate (DNW). AUTODOC recommends:
    If necessary, use a rubber mallet.
  16. Step 19
    How to change Brake Discs on Ford Focus dnw 1999 - free PDF and video manuals
    Clean the hub. Use a wire brush. Treat the contacting surface. Use copper grease.
  17. Step 20
    How to replace FORD FOCUS Estate (DNW) 1.6 16V 2000 Brake Discs - step-by-step manuals and video guides
    Install the brake disc.
  18. Step 21
    Ford Focus dnw 1.8 Turbo DI / TDDi 2001 Brake Discs replacement: free workshop manuals
    Screw in the brake disc fastener. Use a crowbar.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
Users voted – 0
Searching for the right tyres?

Find out which tyre and wheel sizes are compatible with the FORD Focus Mk1 Estate (DNW) model.

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!
Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.
FORD FOCUS Estate (DNW) Brake Discs replace by yourself - Scan QR-code and download AUTODOC CLUB app
Scan

To download the app:

  • - scan the QR code
  • - download from App Store
  • - download from Google Play
DIY FORD FOCUS Estate (DNW) Brake Discs replacement - online guide
Tips & tricks for your FORD FOCUS Estate (DNW)
View more
  • How to change Brake rotors on FORD FOCUS Estate (DNW) 1.8 16V - replacement tricks
    How to start a car after a long idle period | AUTODOC tips
  • Changing Brake disc Ford Focus dnw 1.6 16V - Replacement Tips
    Car checks you need to carry out on your car after the winter | AUTODOC tips
  • Maintenance Hacks - FORD FOCUS Estate (DNW) 1.8 Turbo DI / TDDi Brake disc kit replacement guide
    Headlight Restoration | AUTODOC tips
  • Replace Disc brake set on Ford Focus dnw - free video tips
    DIY jack restoration | AUTODOC tips