How to carry out replacement: Brake Calipers 1.6 TDI VW Golf 6 Convertible
Disclaimer
Change VW Golf 6 Convertible 2.0 TDI Brake Calipers yourself – manuals and video tutorials

How to change rear brake caliper on VW Golf VI Convertible (517) – replacement guide

downloads: 3
Views: 18
Download your free tutorial and fix VW Golf VI Convertible (517) 1.6 TDI problems yourself Download for free 1.73 MB Brake Calipers for VW Golf 6 Convertible Shop now
Leave a comment Open in a new tab
When to replace the Brake Calipers on your VW GOLF
Recommended replacement interval for the part category Brake caliper : 100000 km
Important!
This replacement procedure can be used for:
VW Golf VI Convertible (517) 1.2 TSI, VW Golf VI Convertible (517) 1.4 TSI, VW Golf VI Convertible (517) 1.4 TSI, VW Golf VI Convertible (517) 2.0 GTI, VW Golf VI Convertible (517) 1.6 TDI, VW Golf VI Convertible (517) 2.0 TDI, VW Golf VI Convertible (517) 1.2 TSI 16V, VW Golf VI Convertible (517) 2.0 R, VW Golf VI Convertible (517) 1.4 TSI, VW Golf VI Convertible (517) 1.4 TSI, VW Golf VI Convertible (517) 2.0 TDI … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Brake Calipers for Golf VI Convertible (517) and other VW models
Alternative products
How to change Brake caliper on VW Golf 6 Convertible 1.6 TDI – step-by-step instructions for straightforward car repair Brake caliper
Tools
Replacement: brake caliper – VW GOLF VI Convertible (517). Tools you'll need:
Wire brush
WD-40 spray
Brake cleaner
Copper grease
Combination spanner #11
Combination spanner #13
Combination spanner #15
Drive socket # 11
Drive socket # 13
HEX bit no.H7.
Wheel impact socket #17
Ratchet wrench
Torque wrench
Fluid container
Brake bleeder kit
Brake hose clip
Crow bar
Rubber mallet
Water pump pliers
Wheel chock
Buy tools
Replacement: brake caliper – VW GOLF VI Convertible (517). Professionals recommend:
  • The replacement procedure is identical for the left and right brake calipers on the same axle.
  • All work should be done with the engine stopped.
Replacement: brake caliper – VW GOLF VI Convertible (517). Use the following procedure:
  1. Step 1
    Open the bonnet. Unscrew the brake fluid reservoir cap.
    Step 2
    How to change Brake Calipers on VW Golf 6 Convertible 2011 - free PDF and video manuals
    Secure the wheels with chocks.
  2. Step 3
    How to replace VW Golf VI Convertible (517) 1.6 TDI 2012 Brake Calipers - step-by-step manuals and video guides
    Loosen the wheel mounting bolts. Use wheel impact socket #17.
  3. Step 4
    Raise the rear of the car and secure on supports.
    Step 5
    VW Golf 6 Convertible 2.0 TDI 2013 Brake Calipers replacement: free workshop manuals
    Unscrew the wheel bolts.
    Replacement: brake caliper – VW GOLF VI Convertible (517). AUTODOC recommends:
    To avoid injury, hold up the wheel when unscrewing the bolts.
  4. Step 6
    Changing Brake Calipers on VW Golf VI Convertible (517) 1.4 TSI 2014 by yourself
    Remove the wheel.
  5. Step 7
    How to remove VW GOLF 2.0 GTI 2015 Brake Calipers - online easy-to-follow instructions
    Clean the area where the brake hose is connected to the caliper, and the guide pins area. Use a wire brush. Use WD-40 spray.
  6. Step 8
    How to replace Brake Calipers on VW Golf VI Convertible (517) 2016: download PDF manuals and video instructions
    Loosen the fastener connecting the brake pipe to the brake hose. Use a combination spanner #11.
  7. Step 9
    How hard is it to do yourself: Brake Calipers replacement on VW Golf 6 Convertible 2.0 R 2011 - download illustrated guide
    Loosen the fastener connecting the brake pipe to the brake caliper. Use a combination spanner #11.
  8. Step 10
    Need to know how to renew Brake Calipers on VW GOLF 2012? This free workshop manual will help you to do it yourself
    Clamp the brake hose off using a brake hose clamp.
  9. Step 11
    Changing of Brake Calipers on VW Golf 6 Convertible 2013 won't be an issue if you follow this illustrated step-by-step guide
    Put a container for gathering brake fluid beneath.
  10. Step 12
    Unscrew the fastener connecting the brake pipe to the brake hose. Use a combination spanner #11.
    Step 13
    VW GOLF 2.0 TDI Brake Calipers replacement: online guides and video tutorials
    Remove the brake hose retaining clip. Use a crowbar.
  11. Step 14
    Replacing Brake Calipers on VW Golf 6 Convertible 2015 1.6 TDI by yourself
    Remove the retaining clip of the parking brake cable. Use a crowbar.
  12. Step 15
    Press the parking brake actuator lever on the brake caliper.
    Step 16
    Disconnect the parking brake cable from the caliper. Use water pump pliers.
    Step 17
    Golf VI Convertible (517) 2.0 GTI 2016 Brake Calipers DIY replacement workshop manual
    Unscrew the brake caliper fastening. Use a combination spanner #13.
  13. Step 18
    How to change Brake Calipers on VW Golf VI Convertible (517) 2011 - tips and tricks
    Remove the brake caliper.
    Replacement: brake caliper – VW GOLF VI Convertible (517). AUTODOC experts recommend:
    When replacing the brake caliper, it is recommended to check the brake hose for damages and, if necessary, to replace it with a new one. When replacing a brake caliper it is recommended to replace brake pads, check the state of the brake discs and replace them with new ones if necessary.If no new guide pins were supplied in a kit with the new brake calipers, use the old pins.
  14. Step 19
    Step-by-step recommendations for DIY replacement VW Golf 6 Convertible 2012 2.0 GTI Brake Calipers
    Unscrew the fastener connecting the brake pipe to the brake caliper. Use a combination spanner #11.
  15. Step 20
    DIY replacement of Brake Calipers on VW Golf VI Convertible (517) 1.2 TSI 2013 is not an issue anymore with our step-by-step tutorial
    Install the brake caliper and fix it.
  16. Step 21
    How to change Brake Calipers on VW Golf 6 Convertible 2011 - free PDF and video manuals
    Tighten the brake caliper fasteners. Use a combination spanner #15. Use a drive socket #13. Use a torque wrench. Tighten it to 35 Nm torque.
  17. Step 22
    Install the parking brake cable into the brake caliper bracket. Use water pump pliers.
    Step 23
    How to replace VW Golf VI Convertible (517) 1.6 TDI 2012 Brake Calipers - step-by-step manuals and video guides
    Secure the parking brake cable with the retaining clip.
  18. Step 24
    VW Golf 6 Convertible 2.0 TDI 2013 Brake Calipers replacement: free workshop manuals
    Unscrew the brake hose plug. Use HEX No.H7. Use a ratchet wrench.
  19. Step 25
    Changing Brake Calipers on VW Golf VI Convertible (517) 1.4 TSI 2014 by yourself
    Treat the brake pipe. Use a brake cleaner.
    Replacement: brake caliper – VW GOLF VI Convertible (517). Tip:
    After applying the spray, wait a few minutes.
  20. Step 26
    How to remove VW GOLF 2.0 GTI 2015 Brake Calipers - online easy-to-follow instructions
    Screw in the fastener connecting the brake pipe to the brake caliper. Use a combination spanner #11.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
Users voted – 0
Need New Tyres?

Find out which tyre and wheel sizes are compatible with the VW Golf VI Convertible (517) model

VW Golf 6 Convertible tyre size

Popular maintenance tutorials for VW Golf 6 Convertible

More manuals for VW Golf 6 Convertible

Complete guides for changing the Brake calipers on different VW GOLF models

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

DIY VW Golf VI Convertible (517) Brake Calipers replacement - online guide
Tips & tricks for your VW Golf VI Convertible (517)
View more
  • How to change Brake calipers on VW Golf VI Convertible (517) 1.2 TSI - replacement tricks
    Easy Steps to Paint Brake Calipers Without Special Skills or High Costs
    10K views
    Published on: 08/04/2021
  • Changing Caliper VW Golf 6 Convertible 1.6 TDI - Replacement Tips
    How to prevent car windows from fogging up | AUTODOC tips
    13K views
    Published on: 04/02/2021
  • Maintenance Hacks - VW Golf VI Convertible (517) 2.0 TDI Calipers replacement guide
    Initial Car Inspection: What to Check Before You Buy
    5K views
    Published on: 24/10/2020
  • Replace Brake calipers on VW Golf 6 Convertible - free video tips
    Which Coolant is Best? Comparison Test | AUTODOC
    9K views
    Published on: 13/10/2022

Most commonly replaced car parts on VW GOLF

Professional manuals for the most common VW models

ОЕ number
Autodoc CLUB App icon
Time to replace parts? Get even better deals in our Shop app.
VW Golf VI Convertible (517) Brake Calipers replace by yourself - Scan QR-code and download AUTODOC CLUB app
SCAN ME