Recommended replacement interval for the part category Oil filter : 1 year / 15000 km

Important!

This replacement procedure can be used for:
PEUGEOT 108 1.0 VTi, PEUGEOT 108 1.0 VTi … View more

The steps may slightly vary depending on the car design.

How to change oil filter and engine oil on PEUGEOT 107 1 (PM, PN) [TUTORIAL AUTODOC]

All the parts you need to replace – Oil Filter for 107 Hatchback (PM_, PN_) and other PEUGEOT models

Alternative products

Oil filter

Replacement: engine oil and filter – Peugeot 107 PM PN. Tools you need:

                      Wire brush
                    
                      All-purpose cleaning spray
                    
                      Oil filter cup socket 67-14F
                    
                      Drive socket # 14 
                    
                      Ratchet wrench
                    
                      Torque wrench
                    
                      Oil drain pan
                    
                      Funnel
                    
                      Fender cover

Buy tools

Replacement: engine oil and filter – Peugeot 107 PM PN. Tip from AUTODOC:

Replace the oil filter every time when changing motor oil.
Wear gloves to prevent contact with hot liquid.
Please note: all work on the car – Peugeot 107 PM PN – should be done with the engine switched off.

Carry out replacement in the following order:

Step 1

Open the hood.
Step 2

Use a fender protection cover to prevent damaging paintwork and plastic parts of the car.
Step 3

Unscrew the oil filler plug.
Step 4

Lift the car using a jack or place it over an inspection pit.

Replacement: engine oil and filter – Peugeot 107 PM PN. Tip from AUTODOC:
The vehicle must be on even keel, and if it is at an angle, the drain plug must be at the lowest point.
Step 5

Put a waste oil container with at least 4 l capacity under the drainage hole.
Step 6

Clean the area of the oil pan drainage hole. Use a wire brush.
Step 7

Unscrew the drain plug. Use a drive socket #14. Use a ratchet wrench.
Step 8

Drain the used oil.

Replacement: engine oil and filter – Peugeot 107 PM PN. AUTODOC recommends:
Caution! The oil may be hot.Wait until the oil has completely drained from the drainage hole.
Step 9

Prepare a container for the old oil filter.

Step 10

Clean the oil filter. Use all-purpose cleaning spray.
Step 11

Unscrew the oil filter. Use the 67-14F socket. Use a ratchet wrench.
Step 12

Put the old oil filter in the container.

Replacement: engine oil and filter – Peugeot 107 PM PN. Tip:
Move up the container. The oil starts to drain out of the drainage hole immediately after you have removed the oil filter.
Step 13

Clean the oil filter seat. Use all-purpose cleaning spray.
Step 14

Lubricate the rubber seal of the new filter with a little amount of fresh oil.
Step 15

Screw the new filter into its place. Use the 67-14F socket. Use a torque wrench. Tighten it to 23 Nm torque.
Step 16

Clean the area of the oil pan drainage hole.
Step 17

Screw in the new drainage plug and tighten it. Use a drive socket #14. Use a torque wrench. Tighten it to 27 Nm torque.
Step 18

Clean the area of the oil pan drainage hole. Use all-purpose cleaning spray.
Step 19

Lower the car.
Step 20

Remove the oil filler cap.
Step 21

Insert the funnel.
Step 22

Pour oil into the engine through the filler. Required amount of oil: 3.6 l.

Replacement: engine oil and filter – Peugeot 107 PM PN. Tip from AUTODOC:
Use the oil recommended by the manufacturer.
Step 23

Check the oil level using the dipstick. Top up oil if necessary.

Please note!
The oil level should be between the Min and Max marks.
Step 24

Install the oil filler cap.

Step 25

Tighten the oil filler cap.
Step 26

Run the engine for a few minutes. After the oil pressure warning light goes out, stop the engine.
Step 27

Check the oil level 5 minutes after the stop of the engine operation using a dipstick and add oil if necessary.

Please note!
The oil level should be between the Min and Max marks.Make sure that the oil filler cap is properly tightened.Check the threaded plug of the drainage hole and the oil filter seal for tightness. If necessary, carefully tighten them up.
Step 28

Remove the fender protection cover.
Step 29

Close the hood.

Replacement: engine oil and filter – Peugeot 107 PM PN. Tip from AUTODOC experts:
Note that oil pressure warning light, which indicates insufficient pressure in the lubrication system, may be on for a longer time than usual. After a few seconds, the oil will fill all the channels, and the light will go out. To protect the environment from pollution, be sure to dispose of the used filters at special collection points.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Need New Tyres?

Find out which tyre and wheel sizes are compatible with the PEUGEOT 107 Hatchback (PM, PN) model

Peugeot 107 PN tyre size

How to change pollen filter on Peugeot 107 PM PN – replacement guide

Free download PDF
552.96 KB
How to change air filter on Peugeot 107 PM PN – replacement guide

Free download PDF
1.95 MB
How to change front brake pads on Peugeot 107 PM PN – replacement guide

Free download PDF
1.62 MB
How to change front brake discs on Peugeot 107 PM PN – replacement guide

Free download PDF
2.12 MB
How to change rear wheel bearing on PEUGEOT 107 Hatchback (PM, PN) – replacement guide

Free download PDF
1.67 MB
How to change spark plugs on Peugeot 107 PM PN – replacement guide

Free download PDF
1.79 MB

How to change engine oil and filter on a car – replacement tutorial

Universal

Free download PDF
2.82 MB
How to change engine oil and filter on Peugeot 308 I – replacement guide

Free download PDF
3.3 MB
How to change engine oil and filter on Peugeot 207 hatchback – replacement guide

Free download PDF
1.96 MB
How to change engine oil and filter on Peugeot 206 CC 2D – replacement guide

Free download PDF
1.87 MB
How to change engine oil and filter on Peugeot 406 saloon – replacement guide

Free download PDF
1.78 MB
How to change engine oil and filter on Peugeot 307 SW – replacement guide

Free download PDF
1.87 MB

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

Easy Steps to Fix Minor Scratches on Your Vehicle | AUTODOC tips

8K views

Published on: 12/05/2022
5 possible reasons why your car heater isn't working

6K views

Published on: 21/11/2024
How to inspect and troubleshoot your car heater when it’s not working

5K views

Published on: 11/02/2021
How to choose the right engine oil for your car | AUTODOC

12K views

Published on: 01/07/2020