Recommended replacement interval for the part category Oil filter : 2 year / 30000 km

Important!

This replacement procedure can be used for:
PEUGEOT 307 SW (3H) 1.6 16V, PEUGEOT 307 SW (3H) 1.4 16V, PEUGEOT 307 SW (3H) 2.0 16V, PEUGEOT 307 SW (3H) 1.6 BioFlex … View more

The steps may slightly vary depending on the car design.

How to change oil filter and engine oil on PEUGEOT 307 (3H) [TUTORIAL AUTODOC]

All the parts you need to replace – Oil Filter for 307 SW (3H) and other PEUGEOT models

Oil filter

        Oil filter for PEUGEOT 307 SW (3H) 1.6 16V Petrol (109 hp)
      
        Oil filter for PEUGEOT 307 SW (3H) 1.4 16V Petrol (88 hp)
      
        Oil filter for PEUGEOT 307 SW (3H) 2.0 16V Petrol (140 hp)
      
        Oil filter for PEUGEOT 307 SW (3H) 1.6 BioFlex Petrol/Ethanol (109 hp)

Replacement: engine oil and filter – Peugeot 307 SW. List of the tools you'll need:

                        Wire brush
                      
                        All-purpose cleaning spray
                      
                        Torque wrench
                      
                        Drive socket # 27 
                      
                        Torx bit T45
                      
                        Ratchet wrench
                      
                        Oil drain pan
                      
                        Funnel
                      
                        Flat Screwdriver
                      
                        Fender cover

Buy tools

Replacement: engine oil and filter – Peugeot 307 SW. Tip from AUTODOC:

Replace the oil filter every time when changing motor oil.
Wear gloves to prevent contact with hot liquid.
Please note: all work on the car – Peugeot 307 SW – should be done with the engine switched off.

Carry out replacement in the following order:

Step 1

Open the hood.
Step 2

Use a fender protection cover to prevent damaging paintwork and plastic parts of the car.

Step 3

Unscrew the oil filler plug.
Step 4

Lift the car using a jack or place it over an inspection pit.

Replacement: engine oil and filter – Peugeot 307 SW. Tip:
The vehicle must be on even keel, and if it is at an angle, the drain plug must be at the lowest point.
Step 5

Put a waste oil container with at least 5 l capacity under the drainage hole.
Step 6

Clean the area of the oil pan drainage hole. Use a wire brush. Use all-purpose cleaning spray.
Step 7

Unscrew the drain plug. Use Torx T45. Use a ratchet wrench.
Step 8

Drain the used oil.

Replacement: engine oil and filter – Peugeot 307 SW. Tip from AUTODOC:
Caution! The oil may be hot.Wait until the oil has completely drained from the drainage hole.
Step 9

Remove the engine cover.

AUTODOC recommends:
Replacement: engine oil and filter – Peugeot 307 SW. Do not use excessive force when removing the part as this may damage it.
Step 10

Clean the oil filter housing cap. Use all-purpose cleaning spray.
Step 11

Unscrew the filter housing cap together with the old filter element. Use a drive socket #27. Use a ratchet wrench.
Step 12

Prepare a container for the old oil filter. Put the old oil filter in the container.

Replacement: engine oil and filter – Peugeot 307 SW. Professionals recommend:
Move up the container. The oil starts to drain out of the drainage hole immediately after you have removed the oil filter.
Step 13

Remove the oil filter cover O-ring. Use a flat screwdriver.
Step 14

Detach the oil filter from the filter cover.
Step 15

Clean the oil filter housing cap. Use all-purpose cleaning spray.
Step 16

Install a new O-ring to its mounting seat on the filter cover.
Step 17

Install the new oil filter to the mounting seat on the filter cover.

Please note!
Make sure to install the filter correctly. Don't mix up the sides of the part.
Step 18

Lubricate the rubber seal of the new filter with a little amount of fresh oil.
Step 19

Install a new oil filter housing cover and tighten it. Use a drive socket #27. Use a torque wrench. Tighten it to 25 Nm torque.
Step 20

Clean the area of the oil pan drainage hole.
Step 21

Screw in the new drainage plug and tighten it. Use Torx T45. Use a torque wrench. Tighten it to 30 Nm torque.
Step 22

Clean the area of the oil pan drainage hole. Use all-purpose cleaning spray.
Step 23

Lower the car.
Step 24

Remove the oil filler cap.
Step 25

Insert the funnel.
Step 26

Pour oil into the engine through the filler. Required amount of oil: 4.5 L.

Replacement: engine oil and filter – Peugeot 307 SW. Tip:
Use the oil recommended by the manufacturer.
Step 27

Check the oil level using the dipstick. Top up oil if necessary.

Please note!
The oil level should be between the Min and Max marks.
Step 28

Install the engine cover and secure it.

AUTODOC recommends:
Make sure the engine cover is properly seated. It should not be displaced with respect to the guiding fasteners.Replacement: engine oil and filter – Peugeot 307 SW. Do not use excessive force during installation. This may damage the fasteners.
Step 29

Install the oil filler cap.

Step 30

Tighten the oil filler cap.

Step 31

Run the engine for a few minutes. After the oil pressure warning light goes out, stop the engine.
Step 32

Check the oil level 5 minutes after the stop of the engine operation using a dipstick and add oil if necessary.

Please note!
The oil level should be between the Min and Max marks.Make sure that the oil filler cap is properly tightened.Check the threaded plug of the drainage hole and the oil filter seal for tightness. If necessary, carefully tighten them up.
Step 33

Remove the fender protection cover.
Step 34

Close the hood.

Replacement: engine oil and filter – Peugeot 307 SW. AUTODOC experts recommend:
Note that oil pressure warning light, which indicates insufficient pressure in the lubrication system, may be on for a longer time than usual. After a few seconds, the oil will fill all the channels, and the light will go out. To protect the environment from pollution, be sure to dispose of the used filters at special collection points.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

How to change fuel filter on Peugeot 307 SW – replacement guide

Free download PDF
1.72 MB
How to change air filter on Peugeot 307 SW – replacement guide

Free download PDF
1.05 MB
How to change pollen filter on Peugeot 307 SW – replacement guide

Free download PDF
901.12 KB
How to change front brake pads on Peugeot 307 SW – replacement guide

Free download PDF
1.68 MB
How to change rear brake pads on Peugeot 307 SW – replacement guide

Free download PDF
1.59 MB
How to change rear brake discs on Peugeot 307 SW – replacement guide

Free download PDF
2.44 MB

How to change engine oil and filter on PEUGEOT 307 CC (3B) – replacement guide

Free download PDF
3.1 MB
How to change engine oil and filter on PEUGEOT 307 Hatchback (3A/C) – replacement guide

Free download PDF
3.11 MB
How to change engine oil and filter on PEUGEOT 307 Estate (3E) – replacement guide

Free download PDF
3.11 MB
How to change engine oil and filter on PEUGEOT 307 SW Box Body / Estate (3E_, 3H_) – replacement guide

Free download PDF
1.16 MB
How to change engine oil and filter on PEUGEOT 307 Saloon – replacement guide

Free download PDF
1.52 MB
How to change engine oil and filter on a car – replacement tutorial

Universal

Free download PDF
2.82 MB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

Top 5 mistakes when buying car parts

3K views

Published on: 10/03/2022
How to shine your tyres | AUTODOC tips

3K views

Published on: 07/04/2022
How to start a car after a long idle period | AUTODOC tips

6K views

Published on: 20/05/2021
How to restore a damaged thread | AUTODOC tips

5K views

Published on: 04/05/2023