Recommended replacement interval for the part category Fuel filter : 12 month / 15000 km

Important!

This replacement procedure can be used for:
VW POLO VIVO Hatchback 1.6 16V, VW POLO VIVO Hatchback 1.4, VW POLO VIVO Hatchback 1.4 … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Fuel Filter for POLO VIVO Hatchback and other VW models

Fuel filter

        Fuel filter for Polo Vivo Hatchback Petrol (105 hp)
      
        Fuel filter for Polo Vivo Hatchback Petrol (86 hp)
      
        Fuel filter for Polo Vivo Hatchback Petrol (75 hp)

Replacement: fuel filter – VW POLO VIVO Hatchback. List of the tools you'll need:

                        Nylon cleaning brush 
                      
                        All-purpose cleaning spray
                      
                        Fluid container
                      
                        Phillips screwdriver
                      
                        Crow bar

Buy tools

Replacement: fuel filter – VW POLO VIVO Hatchback. Professionals recommend:

Ensure adequate ventilation of the workplace. Fuel vapors are poisonous.
All work should be done with the engine stopped.

Replacement: fuel filter – VW POLO VIVO Hatchback. Recommended sequence of steps:

Step 1

Open the fuel door.

Step 2

Unscrew the fuel filler cap.

Step 3

Lift the car using a jack or place it over an inspection pit.

Step 4

Prepare a container for fluids.
Step 5

Clean the fasteners of the fuel supply lines. Use a nylon cleaning brush. Use all-purpose cleaning spray.
Step 6

Disconnect the fuel supply lines from the fuel filter. Use a crowbar.

Replacement: fuel filter – VW POLO VIVO Hatchback. AUTODOC experts recommend:
Be careful! Fuel may leak from the filter housing and hoses.
Step 7

Loosen the fuel filter mounting. Use a Phillips screwdriver.
Step 8

Remove the fuel filter.
Step 9

Disconnect the fuel supply lines from the fuel filter.
Step 10

Put the old filter cartridge in the container.

Step 11

Connect the fuel supply lines to the fuel filter.
Step 12

Install a new fuel filter.

Replacement: fuel filter – VW POLO VIVO Hatchback. AUTODOC recommends:
Make sure that the fuel filter is positioned correctly. Consider the fuel flow direction mark.During installation, take care to prevent dust and dirt from getting into the fuel filter housing.Attention! Use quality filters – VW POLO VIVO Hatchback.
Step 13

Screw in the fuel filter mounting bracket. Use a Phillips screwdriver.
Step 14

Connect the fuel supply lines to the fuel filter.
Step 15

Take the fluid container away from under the fuel filter.

Step 16

Lower the car.

Step 17

Tighten the fuel filler cap.

Step 18

Close the fuel door.

Replacement: fuel filter – VW POLO VIVO Hatchback. Tip from AUTODOC:
Before starting off, switch the ignition on and off several times. This should be done to activate the fuel pump to make it pump fuel through the fuel system.
Step 19

Run the engine for a few minutes. This is necessary in order to make sure that the component operates properly.

Step 20

Shut off the engine.

Replacement: fuel filter – VW POLO VIVO Hatchback. Professionals recommend:
To protect the environment from pollution, be sure to dispose of the used filters at special collection points.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Searching for the right tyres?

Find out which tyre and wheel sizes are compatible with the VW Polo Vivo Hatchback model.

Browse tyres

How to change air filter on VW POLO VIVO Hatchback – replacement guide

Free download PDF
993.28 KB
How to change engine oil and filter on VW POLO VIVO Hatchback – replacement guide

Free download PDF
1.28 MB
How to change pollen filter on VW POLO VIVO Hatchback – replacement guide

Free download PDF
573.44 KB
How to change front brake pads on VW POLO VIVO Hatchback – replacement guide

Free download PDF
1.5 MB
How to change front brake discs on VW POLO VIVO Hatchback – replacement guide

Free download PDF
1.99 MB
How to change serpentine belt on VW Polo Vivo Hatchback – replacement guide

Free download PDF
1.43 MB

How to change fuel filter on VW Polo V Hatchback (6R1, 6C1) – replacement guide

Free download PDF
1.74 MB
How to change fuel filter on VW Polo 9N – replacement guide

Free download PDF
1.75 MB
How to change fuel filter on VW Polo III Hatchback (6N2) – replacement guide

Free download PDF
1.75 MB
How to change fuel filter on VW Polo III Hatchback (6N1) – replacement guide

Free download PDF
1.77 MB
How to change fuel filter on VW Polo Hatchback (86C, 80) diesel – replacement guide

Free download PDF
1.19 MB
How to change fuel filter on VW Polo Coupe (86C, 80) diesel – replacement guide

Free download PDF
1.19 MB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

Top 5 mistakes when replacing spark plugs | AUTODOC tips

9K views

Published on: 13/07/2023
Important differences between car tools | AUTODOC tips

7K views

Published on: 16/12/2021
5 common car washing mistakes | AUTODOC tips

5K views

Published on: 23/09/2021
How to detect vacuum leaks using a smoke machine | AUTODOC

19K views

Published on: 23/07/2020