Recommended replacement interval for the part category Fuel filter : 60000 km

Important!

This replacement procedure can be used for:
VW Polo Hatchback (6N1) 55 1.3, VW Polo Hatchback (6N1) 75 1.6, VW Polo Hatchback (6N1) 45 1.0, VW Polo Hatchback (6N1) 64 1.9 D, VW Polo Hatchback (6N1) 55 1.4, VW Polo Hatchback (6N1) 60 1.4, VW Polo Hatchback (6N1) 100 1.4 16V, VW Polo Hatchback (6N1) 50 1.0, VW Polo Hatchback (6N1) 60 1.7 SDI, VW Polo Hatchback (6N1) 120 1.6 16V GTI, VW Polo Hatchback (6N1) 64 1.9 SDI, VW Polo Hatchback (6N1) 1.7 SDI … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Fuel Filter for Polo Hatchback (6N1) and other VW models

Fuel filter

        Fuel filter for Polo III Hatchback (6N1) Petrol (55 hp)
      
        Fuel filter for Polo III Hatchback (6N1) Petrol (75 hp)
      
        Fuel filter for Polo III Hatchback (6N1) Petrol (45 hp)
      
        Fuel filter for Polo III Hatchback (6N1) Diesel (64 hp)
      
        Fuel filter for Polo III Hatchback (6N1) Petrol (55 hp)
      
        Fuel filter for Polo III Hatchback (6N1) Petrol (60 hp)
      
        Fuel filter for Polo III Hatchback (6N1) Petrol (100 hp)
      
        Fuel filter for Polo III Hatchback (6N1) Petrol (50 hp)
      
        Fuel filter for Polo III Hatchback (6N1) Diesel (60 hp)

Replacement: fuel filter – VW POLO (6N1). Tools you'll need:

                        Wire brush
                      
                        All-purpose cleaning spray
                      
                        Phillips screwdriver
                      
                        Flat Screwdriver
                      
                        Fluid container

Buy tools

Replacement: fuel filter – VW POLO (6N1). AUTODOC recommends:

Ensure adequate ventilation of the workplace. Fuel vapors are poisonous.
All work should be done with the engine stopped.

Replacement: fuel filter – VW POLO (6N1). Recommended sequence of steps:

Step 1

Open the fuel door.
Step 2

Unscrew the fuel filler cap.
Step 3

Lift the car using a jack or place it over an inspection pit.

Step 4

Prepare a container for fluids.
Step 5

Clean the fuel filter. Use a wire brush. Use all-purpose cleaning spray.
Step 6

Squeeze the clips and detach the fuel supply lines from the fuel filter housing. Use a flat screwdriver.

Replacement: fuel filter – VW POLO (6N1). Professionals recommend:
Be careful! Fuel may leak from the filter housing and hoses.
Step 7

Loosen the fuel filter mounting. Use a Phillips screwdriver.
Step 8

Remove the fuel filter.
Step 9

Put the old filter cartridge in the container.

Step 10

Install a new fuel filter.

Replacement: fuel filter – VW POLO (6N1). AUTODOC recommends:
Remember, it is important not to mix up the input and output of the filter. Arrows on the filter indicate the direction of fuel flow.During installation, take care to prevent dust and dirt from getting into the fuel filter housing.Attention! Use quality filters – VW POLO (6N1).
Step 11

Connect the fuel lines to the fuel filter and lock the fastening clips.
Step 12

Tighten the fuel filter fasteners. Use a Phillips screwdriver.
Step 13

Take the fluid container away from under the fuel filter.
Step 14

Lower the car.
Step 15

Tighten the fuel filler cap.

Step 16

Close the fuel door.

Replacement: fuel filter – VW POLO (6N1). AUTODOC experts recommend:
Before starting off, switch the ignition on and off several times. This should be done to activate the fuel pump to make it pump fuel through the fuel system.
Step 17

Run the engine for a few minutes. This is necessary in order to make sure that the component operates properly.

Step 18

Shut off the engine.

Replacement: fuel filter – VW POLO (6N1). Professionals recommend:
To protect the environment from pollution, be sure to dispose of the used filters at special collection points.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Searching for the right tyres?

Find out which tyre and wheel sizes are compatible with the VW Polo III Hatchback (6N1) model.

Browse tyres

How to change pollen filter on VW Polo 6N1 – replacement guide

Free download PDF
1.9 MB
How to change air filter on VW Polo 6N1 – replacement guide

Free download PDF
1.81 MB
How to change engine oil and filter on VW Polo 6N1 – replacement guide

Free download PDF
2.62 MB
How to change front brake pads on VW Polo 6N1 – replacement guide

Free download PDF
2.19 MB
How to change rear brake pads on VW Polo Hatchback (6N1) – replacement guide

Free download PDF
1.53 MB
How to change front brake discs on VW Polo 6N1 – replacement guide

Free download PDF
2.34 MB

How to change fuel filter on VW Polo V Hatchback (6R1, 6C1) – replacement guide

Free download PDF
1.74 MB
How to change fuel filter on VW Polo 9N – replacement guide

Free download PDF
1.75 MB
How to change fuel filter on VW Polo III Hatchback (6N2) – replacement guide

Free download PDF
1.75 MB
How to change fuel filter on VW Polo Hatchback (86C, 80) diesel – replacement guide

Free download PDF
1.19 MB
How to change fuel filter on VW Polo Coupe (86C, 80) diesel – replacement guide

Free download PDF
1.19 MB
How to change fuel filter on VW POLO VIVO Hatchback – replacement guide

Free download PDF
870.4 KB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

How to remove rust | AUTODOC tips

25K views

Published on: 16/09/2021
How to wash your car in winter | AUTODOC tips

3K views

Published on: 31/01/2024
TOP 8 mistakes car owners make | AUTODOC tips

14K views

Published on: 09/12/2021
How to restore a damaged thread | AUTODOC tips

5K views

Published on: 04/05/2023