Recommended replacement interval for the part category Oil filter : 12 month / 15000 km

Important!

This replacement procedure can be used for:
VW POLO VIVO Hatchback 1.6 16V … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

Alternative products

Oil filter

Replacement: engine oil and filter – VW POLO VIVO Hatchback. List of the tools you'll need:

                      Wire brush
                    
                      All-purpose cleaning spray
                    
                      Oil filter cup socket 76-14F
                    
                      Drive socket # 19 
                    
                      Ratchet wrench
                    
                      Torque wrench
                    
                      Oil drain pan
                    
                      Funnel
                    
                      Fender cover

Buy tools

Replacement: engine oil and filter – VW POLO VIVO Hatchback. AUTODOC recommends:

Replace the oil filter every time when changing motor oil.
Wear gloves to prevent contact with hot liquid.
All work should be done with the engine stopped.

Replacement: engine oil and filter – VW POLO VIVO Hatchback. Recommended sequence of steps:

Step 1

Open the hood.

Step 2

Use a fender protection cover to prevent damaging paintwork and plastic parts of the car.

Step 3

Unscrew the oil filler plug.
Step 4

Lift the car using a jack or place it over an inspection pit.

Replacement: engine oil and filter – VW POLO VIVO Hatchback. Tip from AUTODOC:
The vehicle must be on even keel, and if it is at an angle, the drain plug must be at the lowest point.All work should be done with the engine stopped.
Step 5

Clean the area of the oil pan drainage hole. Use a wire brush. Use all-purpose cleaning spray.
Step 6

Put a waste oil container with at least 4 l capacity under the drainage hole.
Step 7

Unscrew the drain plug. Use a drive socket #19. Use a ratchet wrench.
Step 8

Drain the used oil.

Replacement: engine oil and filter – VW POLO VIVO Hatchback. AUTODOC experts recommend:
Caution! The oil may be hot.Wait until the oil has completely drained from the drainage hole.
Step 9

Clean the oil filter housing cap. Use all-purpose cleaning spray.
Step 10

Prepare a container for the old oil filter.

Step 11

Unscrew the oil filter. Use the 76-14F socket. Use a ratchet wrench.
Step 12

Put the old oil filter in the container.

Replacement: engine oil and filter – VW POLO VIVO Hatchback. AUTODOC recommends:
Move up the container. The oil starts to drain out of the drainage hole immediately after you have removed the oil filter.
Step 13

Clean the oil filter seat.

Step 14

Lubricate the rubber seal of the new filter with a little amount of fresh oil.
Step 15

Screw the new filter into its place. Use the 76-14F socket. Use a torque wrench. Tighten it to 25 Nm torque.
Step 16

Clean the area of the oil pan drainage hole.
Step 17

Screw in the new drainage plug and tighten it. Use a drive socket #19. Use a torque wrench. Tighten it to 26 Nm torque.
Step 18

Clean the area of the oil pan drainage hole. Use all-purpose cleaning spray.
Step 19

Lower the car.

Step 20

Remove the oil filler cap.
Step 21

Insert the funnel.
Step 22

Pour new oil into the engine in the amount recommended by the car manufacturer.

Replacement: engine oil and filter – VW POLO VIVO Hatchback. Tip:
Use the oil recommended by the manufacturer.
Step 23

Check the oil level using the dipstick. Top up oil if necessary.

Please note!
The oil level should be between the Min and Max marks.
Step 24

Install the oil filler cap.

Step 25

Tighten the oil filler cap.
Step 26

Run the engine for a few minutes. After the oil pressure warning light goes out, stop the engine.

Step 27

Check the oil level 5 minutes after the stop of the engine operation using a dipstick and add oil if necessary.

Please note!
The oil level should be between the Min and Max marks.Make sure that the oil filler cap is properly tightened.Check the threaded plug of the drainage hole and the oil filter seal for tightness. If necessary, carefully tighten them up.
Step 28

Remove the fender protection cover.

Step 29

Close the hood.

Replacement: engine oil and filter – VW POLO VIVO Hatchback. Tip from AUTODOC experts:
Note that oil pressure warning light, which indicates insufficient pressure in the lubrication system, may be on for a longer time than usual. After a few seconds, the oil will fill all the channels, and the light will go out. To protect the environment from pollution, be sure to dispose of the used filters at special collection points.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Need New Tyres?

Find out which tyre and wheel sizes are compatible with the VW Polo Vivo Hatchback model

VW POLO VIVO Hatchback tyre size

How to change air filter on VW POLO VIVO Hatchback – replacement guide

Free download PDF
993.28 KB
How to change pollen filter on VW POLO VIVO Hatchback – replacement guide

Free download PDF
573.44 KB
How to change fuel filter on VW POLO VIVO Hatchback – replacement guide

Free download PDF
870.4 KB
How to change front brake pads on VW POLO VIVO Hatchback – replacement guide

Free download PDF
1.5 MB
How to change front brake discs on VW POLO VIVO Hatchback – replacement guide

Free download PDF
1.99 MB
How to change serpentine belt on VW Polo Vivo Hatchback – replacement guide

Free download PDF
1.43 MB

How to change engine oil and filter on VW Polo Hatchback (6R1, 6C1) – replacement guide

Free download PDF
1.51 MB
How to change engine oil and filter on VW Polo 9N – replacement guide

Free download PDF
2.34 MB
How to change engine oil and filter on VW POLO (6N2) – replacement guide

Free download PDF
1.51 MB
How to change engine oil and filter on VW Polo 6N1 – replacement guide

Free download PDF
2.62 MB
How to change engine oil and filter on VW Polo II Hatchback (86C, 80) – replacement guide

Free download PDF
2.15 MB
How to change engine oil and filter on VW Polo II Coupe (86C, 80) – replacement guide

Free download PDF
2.15 MB

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

Unveiling the secrets: Detecting vacuum leaks with a Smoke Machine | AUTODOC

19K views

Published on: 23/07/2020
How to remove rust | AUTODOC tips

27K views

Published on: 16/09/2021
Petrol or diesel: The engine showdown! | AUTODOC

4K views

Published on: 04/05/2021
Save Money on Fuel with These Easy Tips | AUTODOC

5K views

Published on: 27/09/2022