Recommended replacement interval for the part category Fuel filter : 12 month / 15000 km

Important!

This replacement procedure can be used for:
TOYOTA Dyna Platform / Chassis (KD_, LY_, _Y2_, _U3_, _U4_) 3.0 D4d (KDY261_, KDY251_, KDY231_, KDY221_), TOYOTA Dyna Platform / Chassis (KD_, LY_, _Y2_, _U3_, _U4_) 3.0 D4d (LY220, LY230), TOYOTA Dyna Platform / Chassis (KD_, LY_, _Y2_, _U3_, _U4_) 2.5 D4d (KDY230, KDY250), TOYOTA Dyna Platform / Chassis (KD_, LY_, _Y2_, _U3_, _U4_) 2.5 D4d (KDY220_, KDY230_), TOYOTA Dyna Platform / Chassis (KD_, LY_, _Y2_, _U3_, _U4_) 3.0 D4d 4WD (KDY271), TOYOTA Dyna Platform / Chassis (KD_, LY_, _Y2_, _U3_, _U4_) 3.0 D4d (KDY221, KDY231, KDY251, KDY261) … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Fuel Filter for Dyna Platform / Chassis (KD_, LY_, _Y2_, _U3_, _U4_) and other TOYOTA models

Fuel filter

        Fuel filter for Dyna Platform / Chassis (U400-U700, Y200-Y300) Diesel (144 hp)
      
        Fuel filter for Dyna Platform / Chassis (U400-U700, Y200-Y300) Diesel (144 hp)
      
        Fuel filter for Dyna Platform / Chassis (U400-U700, Y200-Y300) Diesel (88 hp)
      
        Fuel filter for Dyna Platform / Chassis (U400-U700, Y200-Y300) Diesel (102 hp)
      
        Fuel filter for Dyna Platform / Chassis (U400-U700, Y200-Y300) Diesel (88 hp)
      
        Fuel filter for Dyna Platform / Chassis (U400-U700, Y200-Y300) Diesel (109 hp)

Replacement: fuel filter – TOYOTA DYNA Platform/Chassis (KD_, LY_, TRY2_, KDY2_, XZU4_, XZU3_,. Tools you need:

                        All-purpose cleaning spray
                      
                        Drive socket # 8 
                      
                        Drive socket # 12 
                      
                        Ratchet wrench
                      
                        Torque wrench
                      
                        Vice
                      
                        Round-nose pliers
                      
                        Flat Screwdriver
                      
                        Oil filter wrench
                      
                        Fender cover

Buy tools

Replacement: fuel filter – TOYOTA DYNA Platform/Chassis (KD_, LY_, TRY2_, KDY2_, XZU4_, XZU3_,. AUTODOC experts recommend:

Ensure adequate ventilation of the workplace. Fuel vapors are poisonous.
All work should be done with the engine stopped.

Replacement: fuel filter – TOYOTA DYNA Platform/Chassis (KD_, LY_, TRY2_, KDY2_, XZU4_, XZU3_,. Recommended sequence of steps:

Step 1

Open the bonnet.

Step 2

Use a fender protection cover to prevent damaging paintwork and plastic parts of the car.

Step 3

Detach the connector of the water-in-fuel sensor.
Step 4

Loosen the fastening clamps of the fuel filter pipes. Use round-nose pliers.
Step 5

Detach the tubes from the fuel filter.

Replacement: fuel filter – TOYOTA DYNA Platform/Chassis (KD_, LY_, TRY2_, KDY2_, XZU4_, XZU3_,. Tip:
Be careful! Fuel may leak from the filter housing and hoses.
Step 6

Loosen the fuel filter mounting. Use a drive socket #12. Use a ratchet wrench.
Step 7

Remove the fuel filter. Put the old filter cartridge in the container.
Step 8

Unscrew the bracket of the water-in-fuel sensor. Use a drive socket #8.
Step 9

Remove the rubber strip.
Step 10

Unscrew the water-in-fuel sensor.
Step 11

Wait until the fuel is completely drained from the fuel filter.
Step 12

Unscrew the clamps of the fuel filter protective case. Use a drive socket #8.
Step 13

Remove the protective case of the fuel filter.
Step 14

Grip the fuel filter cover with the old cartridge in a vice.
Step 15

Unscrew the cartridge.
Step 16

Clean the mounting seat of the cartridge.
Step 17

Screw in the new cartridge. Use an oil filter wrench. Use a torque wrench. Tighten it to 14 Nm torque.

AUTODOC recommends:
Take care to only use quality filters.During installation, take care to prevent dust and dirt from getting into the fuel filter housing.
Step 18

Loosen the vice and take out the fuel filter assembly.
Step 19

Install the fuel filter protective case.
Step 20

Tighten the clamps of the fuel filter protective case. Use a drive socket #8.
Step 21

Remove the O-ring of the water-in-fuel sensor. Use a flat screwdriver.
Step 22

Clean the water-in-fuel sensor. Use all-purpose cleaning spray.
Step 23

Install the new O-ring of the water-in-fuel sensor.
Step 24

Screw in the water-in-fuel sensor.
Step 25

Install the rubber strip.
Step 26

Screw in the bracket of the water-in-fuel sensor. Use a drive socket #8. Use a ratchet wrench.
Step 27

Install a new fuel filter.
Step 28

Tighten the fuel filter fasteners. Use a drive socket #12. Use a ratchet wrench.
Step 29

Attach the connector of the water-in-fuel sensor.
Step 30

Attach the tubes to the fuel filter. Use round-nose pliers.
Step 31

Tighten the fastening clamps of the fuel filter pipes. Use round-nose pliers.
Step 32

Press the fuel primer pump several times until it gets hard.

Step 33

Run the engine for a few minutes. This is necessary in order to make sure that the component operates properly.

Step 34

Shut off the engine.

Step 35

Remove the fender protection cover.

Step 36

Close the hood.

Replacement: fuel filter – TOYOTA DYNA Platform/Chassis (KD_, LY_, TRY2_, KDY2_, XZU4_, XZU3_,. Professionals recommend:
To protect the environment from pollution, be sure to dispose of the used filters at special collection points.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Searching for the right tyres?

Find out which tyre and wheel sizes are compatible with the TOYOTA Dyna Platform / Chassis (U400-U700, Y200-Y300) model.

TOYOTA DYNA Platform/Chassis (KD_, LY_, TRY2_, KDY2_, XZU4_, XZU3_, tyre size

How to change engine oil and filter on Toyota Aygo AB1 – replacement guide

Free download PDF
2.32 MB
How to change rear brake shoes on Toyota Yaris P1 – replacement guide

Free download PDF
2.32 MB
How to change serpentine belt on Toyota Aygo AB1 – replacement guide

Free download PDF
2.36 MB
How to change front anti roll bar links on Toyota Yaris P1 – replacement guide

Free download PDF
1.61 MB
How to change front brake pads on Toyota Prado J120 – replacement guide

Free download PDF
2.08 MB
How to change fuel filter on Toyota Prado J120 – replacement guide

Free download PDF
2.67 MB

How to change fuel filter on TOYOTA DYNA 150 Platform/Chassis (LY_) – replacement guide

Free download PDF
2.12 MB
How to change fuel filter on TOYOTA DYNA 100 Platform/Chassis (LY1_, YY1_) – replacement guide

Free download PDF
2.12 MB
How to change fuel filter on TOYOTA Dyna 200 Platform / Chassis – replacement guide

Free download PDF
2.11 MB
How to change fuel filter on TOYOTA Dyna 150 Platform / Chassis (_Y_) – replacement guide

Free download PDF
2.12 MB
How to change fuel filter on TOYOTA DYNA 150 Platform/Chassis – replacement guide

Free download PDF
2.11 MB
How to change fuel filter on TOYOTA Dyna 250 Van – replacement guide

Free download PDF
2.11 MB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

Top 5 mistakes when replacing spark plugs | AUTODOC tips

9K views

Published on: 13/07/2023
How to restore wheel rims | AUTODOC tips

6K views

Published on: 13/05/2021
3 things to know before buying summer tyres | AUTODOC tips

3K views

Published on: 18/05/2023
Checking the starter without removing it | AUTODOC tips

19K views

Published on: 01/12/2020