How to carry out replacement: Fuel Filter 1.9 TDI Audi A4 B5 Avant
Disclaimer
Change Audi A4 B5 Avant 1.9 TDI Fuel Filter yourself – manuals and video tutorials

How to change fuel filter on AUDI A4 B5 Avant (8D5) – replacement guide

downloads: 3
Views: 156
Download your free tutorial and fix AUDI A4 Avant (8D5, B5) 1.6 problems yourself Download for free 2.13 MB Fuel Filter for Audi A4 B5 Avant Shop now
Leave a comment Open in a new tab
When to replace the Fuel Filter on your AUDI A4
Recommended replacement interval for the part category Fuel Filter : 60000 km
Important!
This replacement procedure can be used for:
AUDI A4 Avant (8D5, B5) 1.9 TDI quattro, AUDI A4 Avant (8D5, B5) 1.9 TDI … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Fuel Filter for A4 Avant (8D5, B5) and other AUDI models
Alternative products
Tools
Replacement: fuel filter – AUDI A4 Avant (8D5, B5). Tools you'll need:
All-purpose cleaning spray
Drive socket # 10
Hose clamp pliers
Phillips screwdriver
Flat Screwdriver
Fender cover
Buy tools
Replacement: fuel filter – AUDI A4 Avant (8D5, B5). Tip from AUTODOC:
  • Ensure adequate ventilation of the workplace. Fuel vapors are poisonous.
  • Please note: all work on the car – AUDI A4 Avant (8D5, B5) – should be done with the engine switched off.
Carry out replacement in the following order:
  1. Step 1
    Open the bonnet.
    Step 2
    Use a fender protection cover to prevent damaging paintwork and plastic parts of the car.
    Step 3
    Remove the engine cover caps. Use a flat screwdriver.
    Step 4
    How to change Fuel Filter on Audi A4 B5 Avant 1994 - free PDF and video manuals
    Unscrew the engine cover fastener. Use a drive socket #10.
  2. Step 5
    How to replace AUDI A4 Avant (8D5, B5) 1.9 TDI 1995 Fuel Filter - step-by-step manuals and video guides
    Remove the engine cover.
    Replacement: fuel filter – AUDI A4 Avant (8D5, B5). AUTODOC experts recommend:
    Raise the engine cover, holding it on two sides simultaneously.
  3. Step 6
    Audi A4 B5 Avant 1.8 1996 Fuel Filter replacement: free workshop manuals
    Clean the fuel filter. Use all-purpose cleaning spray.
  4. Step 7
    Changing Fuel Filter on AUDI A4 Avant (8D5, B5) 1.8 T 1997 by yourself
    Loosen the fastening clamps of the fuel filter pipes. Use hose clamp pliers with retainer.
  5. Step 8
    How to remove AUDI A4 1.8 T quattro 1998 Fuel Filter - online easy-to-follow instructions
    Detach the tubes from the fuel filter.
    Replacement: fuel filter – AUDI A4 Avant (8D5, B5). Tip from AUTODOC experts:
    Be careful! Fuel may leak from the filter housing and hoses.
  6. Step 9
    How to replace Fuel Filter on AUDI A4 Avant (8D5, B5) 1999: download PDF manuals and video instructions
    Loosen the fuel filter mounting. Use a Phillips screwdriver.
  7. Step 10
    How hard is it to do yourself: Fuel Filter replacement on Audi A4 B5 Avant 2.5 TDI 2000 - download illustrated guide
    Remove the fuel filter pipe retainer.
  8. Step 11
    Need to know how to renew Fuel Filter on AUDI A4 2001? This free workshop manual will help you to do it yourself
    Disconnect the pipe from the fuel filter.
  9. Step 12
    Changing of Fuel Filter on Audi A4 B5 Avant 1994 won't be an issue if you follow this illustrated step-by-step guide
    Remove the fuel filter. Put the old filter cartridge in the container.
  10. Step 13
    AUDI A4 1.9 TDI Fuel Filter replacement: online guides and video tutorials
    Install a new fuel filter.
    Replacement: fuel filter – AUDI A4 Avant (8D5, B5). Tip from AUTODOC:
    Make sure that the fuel filter is positioned correctly. Consider the fuel flow direction mark.During installation, take care to prevent dust and dirt from getting into the fuel filter housing.AUDI A4 Avant (8D5, B5) – It's important to only use high-quality filters.
  11. Step 14
    Replacing Fuel Filter on Audi A4 B5 Avant 1996 1.9 TDI by yourself
    Tighten the fuel filter fasteners. Use a Phillips screwdriver.
  12. Step 15
    A4 Avant (8D5, B5) 1.8 T quattro 1997 Fuel Filter DIY replacement workshop manual
    Remove the o-rings. Use a flat screwdriver.
  13. Step 16
    How to change Fuel Filter on AUDI A4 Avant (8D5, B5) 1998 - tips and tricks
    Install new o-rings.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
Users voted – 0
Need New Tyres?

Find out which tyre and wheel sizes are compatible with the AUDI A4 B5 Avant (8D5) model

Audi A4 B5 Avant tyre size

Popular maintenance tutorials for Audi A4 B5 Avant

More manuals for Audi A4 B5 Avant

Complete guides for changing the Fuel filters on different AUDI A4 models

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

DIY AUDI A4 Avant (8D5, B5) Fuel Filter replacement - online guide
Tips & tricks for your AUDI A4 Avant (8D5, B5)
View more
  • How to change Fuel filters on AUDI A4 Avant (8D5, B5) S4 2.7 quattro - replacement tricks
    5 more brake repair mistakes | Stop making these brake repair mistakes
    9K views
    Published on: 22/01/2025
  • Changing Inline fuel filter Audi A4 B5 Avant 1.9 TDI - Replacement Tips
    Prevent Engine Damage: How to Identify Rocker Cover Gasket Issues and Proper Replacement | AUTODOC
    6K views
    Published on: 03/12/2020
  • Maintenance Hacks - AUDI A4 Avant (8D5, B5) 1.8 Fuel filters replacement guide
    Easy Steps to Paint Brake Calipers Without Special Skills or High Costs
    10K views
    Published on: 08/04/2021
  • Replace Inline fuel filter on Audi A4 B5 Avant - free video tips
    5 most common causes of oil leaks | AUTODOC tips
    69K views
    Published on: 30/03/2023

Most commonly replaced car parts on AUDI A4

Professional manuals for the most common AUDI models

ОЕ number
Autodoc CLUB App icon
Time to replace parts? Get even better deals in our Shop app.
AUDI A4 Avant (8D5, B5) Fuel Filter replace by yourself - Scan QR-code and download AUTODOC CLUB app
SCAN ME