Recommended replacement interval for the part category Brake pad set : 30000 km

Important!

This replacement procedure can be used for:
SEAT Mii (KF1_) electric, SEAT Mii (KF1_) 1.0 EcoFuel, SEAT Mii (KF1_) 1.0, SEAT Mii (KF1_) 1.0 … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Brake Pads for Mii (KF1_) and other SEAT models

Alternative products

Brake pad set

Replacement: brake pads – SEAT Mii (KF1_). List of the tools you'll need:

                      Wire brush
                    
                      Nylon cleaning brush
                    
                      WD-40 spray
                    
                      Brake cleaner 
                    
                      Anti-squeal paste
                    
                      Copper grease 
                    
                      Torque wrench
                    
                      HEX bit No.H7.
                    
                      Wheel impact socket #17
                    
                      Ratchet wrench
                    
                      Brake caliper wind back tool
                    
                      Crow bar
                    
                      Wheel chock

Buy tools

Replacement: brake pads – SEAT Mii (KF1_). AUTODOC experts recommend:

Perform the replacement of brake pads in complete set for each axis. This provides effective braking.
The replacement procedure is identical for all brake pads on the same axle.
All work should be done with the engine stopped.

Replacement: brake pads – SEAT Mii (KF1_). Recommended sequence of steps:

Step 1

Open the bonnet. Unscrew the brake fluid reservoir cap.

Step 2

Secure the wheels with chocks.
Step 3

Loosen the wheel mounting bolts. Use wheel impact socket #17.
Step 4

Raise the front of the car and secure on supports.

Step 5

Unscrew the wheel bolts.

Replacement: brake pads – SEAT Mii (KF1_). Tip:
To avoid injury, hold up the wheel when unscrewing the bolts.
Step 6

Remove the wheel.
Step 7

Remove the dust boot caps of the brake caliper guide pins. Use a crowbar.
Step 8

Unscrew the brake caliper fastening. Use HEX No.H7. Use a ratchet wrench.
Step 9

Spread the brake pads. Use a crowbar.
Step 10

Remove the brake caliper.

Replacement: brake pads – SEAT Mii (KF1_). AUTODOC experts recommend:
Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
Step 11

Remove the brake pads. Use a crowbar.

AUTODOC recommends:
Measure the brake disc thickness. Upon reaching the wear limit the part must be replaced.
Step 12

Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.

AUTODOC recommends:
Replacement: brake pads – SEAT Mii (KF1_). After applying the spray, wait a few minutes.
Step 13

Treat the brake caliper piston. Use a nylon cleaning brush. Use a brake cleaner.

AUTODOC recommends:
After applying the spray, wait a few minutes.
Step 14

Press in the brake caliper piston. Use brake caliper wind back tool.
Step 15

Treat the brake pads in the area where their surface comes into contact with the brake caliper bracket. Use anti-squeal paste.

Replacement: brake pads – SEAT Mii (KF1_). Professionals recommend:
Make sure the disc surface is clean before installing the pads.
Step 16

Install new brake pads.

AUTODOC recommends:
Make sure the pads are installed with linings facing the disc.
Step 17

Install the brake caliper and fix it. Use HEX No.H7. Use a torque wrench. Tighten it to 28 Nm torque.
Step 18

Install the dust boot caps of the brake caliper guide pins.
Step 19

Treat the surface where the brake disc contacts the wheel rim. Use copper grease.
Step 20

Clean the brake disk surface. Use a brake cleaner.

Replacement: brake pads – SEAT Mii (KF1_). AUTODOC recommends:
After applying the spray, wait a few minutes.
Step 21

Install the wheel.

AUTODOC recommends:
Warning! To avoid injury, hold the wheel while screwing in the fastening bolts on the car. SEAT Mii (KF1_)
Step 22

Screw in the wheel bolts. Use wheel impact socket #17.
Step 23

Lower the car and working in a cross order, tighten the wheel bolts. Use wheel impact socket #17. Use a torque wrench. Tighten it to 120 Nm torque.
Step 24

Remove the jacks and chocks.

AUTODOC recommends:
Check the brake fluid level in the expansion tank and refill if necessary.
Step 25

Tighten the brake fluid reservoir cap.

AUTODOC recommends:
SEAT Mii (KF1_) – Without starting the engine, press the brake pedal several times until it feels firm.
Step 26

Close the hood.

Replacement: brake pads – SEAT Mii (KF1_). Tip from AUTODOC experts:
Slow down smoothly for first 150-200 km after the brake pads replacement. Avoid unneccessary and sharp braking to a stop.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Need New Tyres?

Find out which tyre and wheel sizes are compatible with the SEAT Mii (KF1) model

Seat Mii kf1 tyre size

How to change front brake caliper on SEAT Mii (KF1_) – replacement guide

Free download PDF
2.05 MB
How to change brake drum on SEAT Mii (KF1_) – replacement guide

Free download PDF
1.2 MB
How to change rear brake shoes on SEAT Mii (KF1_) – replacement guide

Free download PDF
1.91 MB
How to change serpentine belt on SEAT Mii (KF1_) – replacement guide

Free download PDF
675.84 KB
How to change front windshield wipers on SEAT Mii (KF1_) – replacement guide

Free download PDF
512 KB
How to change front anti roll bar links on SEAT Mii (KF1_) – replacement guide

Free download PDF
1.24 MB

How to change brake pads on a car – replacement tutorial

Universal

Free download PDF
2.84 MB
How to change front brake pads on Seat Leon 1M1 – replacement guide

Free download PDF
1.59 MB
How to change front brake pads on Seat Ibiza 6L1 – replacement guide

Free download PDF
1.66 MB
How to change rear brake pads on Seat Leon 1P1 – replacement guide

Free download PDF
1.51 MB
How to change front brake pads on Seat Leon 1P1 – replacement guide

Free download PDF
1.76 MB
How to change rear brake pads on Seat Leon 1M1 – replacement guide

Free download PDF
1.64 MB

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

Top 4 Car Cleaning Products to Protect Your Car's Body | AUTODOC Tips

2K views

Published on: 26/08/2021
How to easily repair a punctured tyre | AUTODOC tips

3K views

Published on: 25/02/2021
Easy Steps to Fix Minor Scratches on Your Vehicle | AUTODOC tips

8K views

Published on: 12/05/2022
Top 7 Manual Transmission Mistakes to Avoid | AUTODOC Tips

6K views

Published on: 20/10/2020