Recommended replacement interval for the part category Brake pad set : 30000 km

Important!

This replacement procedure can be used for:
RENAULT MASTER II Box (FD) 2.5 D, RENAULT MASTER II Box (FD) 2.8 dTI, RENAULT MASTER II Box (FD) 2.2 dCI, RENAULT MASTER II Box (FD) 1.9 dTI, RENAULT MASTER II Box (FD) 2.5 dCi, RENAULT MASTER II Box (FD) 1.9 dCi, RENAULT MASTER II Box (FD) 2.5 dCi, RENAULT MASTER II Box (FD) 3.0 dCi, RENAULT MASTER II Box (FD) 2.5 dCi, RENAULT MASTER II Box (FD) 2.5 dCi, RENAULT MASTER II Box (FD) 2.5 dCi … View more

The steps may slightly vary depending on the car design.

How to change the front brake discs and pads on the RENAULT MASTER 2 Van [AUTODOC TUTORIAL]

Alternative products

Brake pad set

Replacement: brake pads – Renault Master 2 van. Tools you'll need:

                      Wire brush
                    
                      Nylon brush
                    
                      WD-40 spray
                    
                      All-purpose cleaning spray
                    
                      Brake cleaner
                    
                      Anti-squeal paste
                    
                      Ceramic grease
                    
                      Torque wrench
                    
                      13 mm socket
                    
                      17 mm socket
                    
                      18 mm socket
                    
                      T40 Torx bit
                    
                      24 mm wheel impact socket
                    
                      Ratchet wrench or power tool for removal/installation of threaded fasteners
                    
                      Ratchet screwdriver
                    
                      Tommy bar
                    
                      Mounting lever
                    
                      Brake caliper wind back tool
                    
                      Car lift or jack with jack stands, and wheel chocks

Buy tools

Replacement: brake pads – Renault Master 2 van. AUTODOC recommends:

Replace the brake discs and pads in axle sets, regardless of their condition. This will ensure even braking.
The procedure for replacing the brake discs and pads is identical for both sides of the same axle.
All the work should be carried out with the ignition switched off.

Replacement: brake pads – Renault Master 2 van. Recommended sequence of steps:

Step 1

Open the bonnet.
Step 2

Loosen the brake fluid reservoir cap.
Step 3

If you are going to use a jack, secure the wheels with chocks.
Step 4

Loosen the wheel fasteners. Use a 24 mm wheel impact socket. Use a tommy bar.
Step 5

Raise the car.

Warning!
If you are using a jack, make sure the car is parked on a hard, flat surface.Make sure to additionally secure the car with jack stands.
Step 6

Unscrew the wheel fasteners.

Replacement: brake pads – Renault Master 2 van. Tip:
To avoid injury, hold up the wheel when unscrewing the fasteners.
Step 7

Remove the wheel.
Step 8

Spread the brake pads apart. Use a mounting lever.
Step 9

Clean the brake caliper fasteners. Use a wire brush. Use WD-40 spray.
Step 10

Unscrew the lower brake caliper fastener. Use an 13 mm socket. Use a ratchet wrench.
Step 11

Unscrew the upper brake caliper fastener. Use an 17 mm socket. Use a ratchet wrench.
Step 12

Remove the fastening bolts.
Step 13

Remove the brake caliper.

Replacement: brake pads – Renault Master 2 van. AUTODOC experts recommend:
Tie the caliper to the suspension or to the body with a wire without disconnecting it from the brake hose to avoid opening the brake line.Make sure that the brake caliper is not hanging from the brake hose.Do not press the brake pedal after the caliper has been removed. This may cause the piston to fall out of the caliper bore resulting in the brake fluid leakage and air entering the system.
Step 14

Remove the brake pads.
Step 15

Remove the brake pad anti-rattle clip from the brake caliper.
Step 16

Clean the brake caliper pistons. Use a nylon brush. Use a brake cleaner.
Step 17

Retract the brake caliper pistons. Use a brake caliper wind back tool.
Step 18

Install a new brake pad anti-rattle clip into the brake caliper.
Step 19

Treat the new brake pads in the areas where they touch their guides on the brake caliper bracket. Use anti-squeal paste.
Step 20

Install new brake pads.
Step 21

Install the brake caliper.
Step 22

Install the fastening bolts.
Step 23

Tighten the upper brake caliper fastener. Use an 17 mm socket. Use a torque wrench. Tightening torque: 80 N·m.
Step 24

Tighten the lower brake caliper fastener. Use an 13 mm socket. Use a torque wrench. Tightening torque: 30 N·m.
Step 25

Clean the wheel rim mounting seat. Use a wire brush. Use an all-purpose cleaning spray.

Step 26

Treat the brake disc surface that contacts the wheel rim. Use ceramic grease.
Step 27

Install the wheel.

Replacement: brake pads – Renault Master 2 van. Tip from AUTODOC experts:
To avoid injury, hold up the wheel when screwing in the fasteners.
Step 28

Screw in the wheel fasteners. Use a 24 mm wheel impact socket. Use a ratchet wrench.
Step 29

Lower the car and tighten the wheel fasteners in a criss-cross pattern. Use a 24 mm wheel impact socket. Use a torque wrench. Tightening torque: 172 N·m.
Step 30

Remove the jack, jack stands, and wheel chocks.
Step 31

Without starting the engine, press the brake pedal several times until you feel significant resistance.
Step 32

Check the brake fluid level in the reservoir and top up if necessary.
Step 33

Tighten the brake fluid reservoir cap.
Step 34

Close the bonnet.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Need New Tyres?

Find out which tyre and wheel sizes are compatible with the RENAULT Master II Van model

Renault Master 2 Van tyre size

How to change hand brake cable on Renault Master 2 van – replacement guide

Free download PDF
1.87 MB
How to change rear brake caliper on Renault Master 2 van – replacement guide

Free download PDF
3.11 MB
How to change rear brake discs on Renault Master 2 van – replacement guide

Free download PDF
2.42 MB
How to change rear brake pads on Renault Master 2 van – replacement guide

Free download PDF
1.67 MB
How to change front ABS sensor on Renault Master 2 van – replacement guide

Free download PDF
1.54 MB
How to change front brake discs on Renault Master 2 van – replacement guide

Free download PDF
2.78 MB

How to change rear brake pads on Renault Master 2 van – replacement guide

Free download PDF
1.67 MB
How to change rear brake pads on RENAULT Master II Platform/Chassis – replacement guide

Free download PDF
1.5 MB
How to change front brake pads on RENAULT Master II Platform/Chassis – replacement guide

Free download PDF
1.79 MB
How to change rear brake pads on RENAULT Master II Minibus – replacement guide

Free download PDF
1.5 MB
How to change front brake pads on RENAULT Master II Minibus – replacement guide

Free download PDF
1.79 MB
How to change brake pads on a car – replacement tutorial

Universal

Free download PDF
2.84 MB

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

Unveiling the secrets: Detecting vacuum leaks with a Smoke Machine | AUTODOC

19K views

Published on: 23/07/2020
Revitalize Your Car Interior: DIY Steering Wheel Cover with AUTODOC Tips

7K views

Published on: 14/03/2024
How to Use Sandblasting Equipment: Step-by-Step Guide | AUTODOC Tips

5K views

Published on: 16/05/2024
Don’t Replace, Just Polish! Headlight Restoration with AUTODOC

9K views

Published on: 13/01/2021