Recommended replacement interval for the part category Brake pad set : 30000 km

Important!

This replacement procedure can be used for:
RENAULT KANGOO Express (FC0/1_) 1.5 dCi, RENAULT KANGOO Express (FC0/1_) 1.2 (FC01, FC0A, FC0F), RENAULT KANGOO Express (FC0/1_) 1.4 (FC0C, FC0B, FC0H, FC0M), RENAULT KANGOO Express (FC0/1_) D 1.9, RENAULT KANGOO Express (FC0/1_) D 1.9, RENAULT KANGOO Express (FC0/1_) 1.9 dTi (FC0U), RENAULT KANGOO Express (FC0/1_) 1.2 16V (FC05, FC0W, FC1D, FC1P, FC1K, FC0T), RENAULT KANGOO Express (FC0/1_) 1.6 16V, RENAULT KANGOO Express (FC0/1_) 1.5 dCi (FC07, FC1R), RENAULT KANGOO Express (FC0/1_) 1.5 dCi (FC1R), RENAULT KANGOO Express (FC0/1_) 1.5 dCi (FC08, FC09), RENAULT KANGOO Express (FC0/1_) 1.9 dCi (FC0V), RENAULT KANGOO Express (FC0/1_) 1.5 dCi (FC1G), RENAULT KANGOO Express (FC0/1_) 1.5 dCi (FC1E), RENAULT KANGOO Express (FC0/1_) 1.0, RENAULT KANGOO Express (FC0/1_) 1.2 (FC1A), RENAULT KANGOO Express (FC0/1_) 1.9 D (FC0J) … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

Alternative products

Brake pad set

Replacement: brake pads – RENAULT KANGOO Express (FC0/1_). Tools you might need:

                      Wire brush
                    
                      WD-40 spray
                    
                      Brake cleaner 
                    
                      Anti-squeal paste
                    
                      Copper grease 
                    
                      Impact socket №13
                    
                      Combination spanner №13
                    
                      Wheel impact socket #19
                    
                      Torque wrench
                    
                      Brake caliper wind back tool
                    
                      Crow bar
                    
                      Wheel chock

Buy tools

Replacement: brake pads – RENAULT KANGOO Express (FC0/1_). AUTODOC recommends:

Perform the replacement of brake pads in complete set for each axis. This provides effective braking.
The replacement procedure is identical for all brake pads on the same axle.
Please note: all work on the car – RENAULT KANGOO Express (FC0/1_) – should be done with the engine switched off.

Carry out replacement in the following order:

Step 1

Open the bonnet. Unscrew the brake fluid reservoir cap.

Step 2

Secure the wheels with chocks.
Step 3

Loosen the wheel mounting bolts. Use wheel impact socket #19.
Step 4

Raise the front of the car and secure on supports.

Step 5

Unscrew the wheel bolts.

Replacement: brake pads – RENAULT KANGOO Express (FC0/1_). AUTODOC experts recommend:
To avoid injury, hold up the wheel when unscrewing the bolts.
Step 6

Remove the wheel.
Step 7

Spread the brake pads. Use a crowbar.
Step 8

Clean the brake caliper fasteners. Use a wire brush. Use WD-40 spray.
Step 9

Unscrew the brake caliper fastening. Use a combination spanner #13.
Step 10

Detach the brake caliper retaining spring. Use a crowbar.
Step 11

Pull the brake caliper assembly aside.

Replacement: brake pads – RENAULT KANGOO Express (FC0/1_). Tip from AUTODOC:
Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur.
Step 12

Remove the brake pads.

Replacement: brake pads – RENAULT KANGOO Express (FC0/1_). Tip from AUTODOC experts:
Measure the brake disc thickness. Upon reaching the wear limit the part must be replaced.
Step 13

Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.

AUTODOC recommends:
Replacement: brake pads – RENAULT KANGOO Express (FC0/1_). After applying the spray, wait a few minutes.
Step 14

Treat the brake caliper bracket where it contacts the brake pads. Use anti-squeal paste.

Replacement: brake pads – RENAULT KANGOO Express (FC0/1_). Professionals recommend:
Make sure the disc surface is clean before installing the pads.
Step 15

Install new brake pads.

Replacement: brake pads – RENAULT KANGOO Express (FC0/1_). Tip:
Make sure the pads are installed with linings facing the disc.
Step 16

Press in the brake caliper piston. Use brake caliper wind back tool.
Step 17

Return the brake caliper assembly to its initial position. Use a drive socket #13. Use a torque wrench. Tighten it to 35 Nm torque.
Step 18

Install the brake caliper retaining spring.

AUTODOC recommends:
RENAULT KANGOO Express (FC0/1_) – Without starting the engine, press the brake pedal several times until it feels firm.
Step 19

Treat the surface where the brake disc contacts the wheel rim. Use copper grease.
Step 20

Clean the brake disk surface. Use a brake cleaner.

Replacement: brake pads – RENAULT KANGOO Express (FC0/1_). AUTODOC recommends:
After applying the spray, wait a few minutes.
Step 21

Install the wheel.

AUTODOC recommends:
Warning! To avoid injury, hold the wheel while screwing in the fastening bolts on the car. RENAULT KANGOO Express (FC0/1_)
Step 22

Screw in the wheel bolts. Use wheel impact socket #19.
Step 23

Lower the car and working in a cross order, tighten the wheel bolts. Use a torque wrench. Tighten it to 110 nm torque.
Step 24

Remove the jacks and chocks.

AUTODOC recommends:
Important! Replacement: brake pads – RENAULT KANGOO Express (FC0/1_). Check the brake fluid level in the reservoir and top up if necessary.
Step 25

Tighten the brake fluid reservoir cap. Close the hood.

Replacement: brake pads – RENAULT KANGOO Express (FC0/1_). AUTODOC experts recommend:
Slow down smoothly for first 150-200 km after the brake pads replacement. Avoid unneccessary and sharp braking to a stop.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Need New Tyres?

Find out which tyre and wheel sizes are compatible with the RENAULT Kangoo I Express (FC) model

Renault Kangoo Express tyre size

How to change front brake discs on RENAULT Kangoo I Express (FC) – replacement guide

Free download PDF
2.61 MB
How to change rear wheel bearing on RENAULT KANGOO Express (FC0/1_) – replacement guide

Free download PDF
1.24 MB
How to change front wheel bearing on RENAULT Kangoo I Express (FC) – replacement guide

Free download PDF
4.32 MB
How to change serpentine belt on RENAULT Kangoo I Express (FC) – replacement guide

Free download PDF
1.97 MB
How to change spark plugs on RENAULT KANGOO Express (FC0/1_) – replacement guide

Free download PDF
1.1 MB
How to change rear windshield wipers on RENAULT Kangoo I Express (FC) – replacement guide

Free download PDF
1.45 MB

How to change front brake pads on Renault Kangoo KC01 – replacement guide

Free download PDF
2.39 MB
How to change front brake pads on RENAULT Kangoo II / Grand Kangoo (KW) – replacement guide

Free download PDF
1.49 MB
How to change brake pads on a car – replacement tutorial

Universal

Free download PDF
2.84 MB
How to change rear brake pads on Renault Megane 2 – replacement guide

Free download PDF
2.49 MB
How to change front brake pads on Renault Clio 2 – replacement guide

Free download PDF
1.46 MB
How to change front brake pads on Renault Clio 3 – replacement guide

Free download PDF
1.64 MB

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

How to repair a bumper yourself | AUTODOC tips

19K views

Published on: 01/06/2023
How to align the timing marks correctly on an EA888 engine

6K views

Published on: 31/07/2025
Easy Steps to Paint Brake Calipers Without Special Skills or High Costs

10K views

Published on: 08/04/2021
Coolant comparison test | AUTODOC

14K views

Published on: 18/02/2021