Disclaimer
How to change front brake pads on Opel Zafira F75 – replacement guide
downloads:
6
Views:
78
Recommended replacement interval for the part category Brake pad set : 30000 km
Important!
This replacement procedure can be used for:
OPEL Zafira A (T98) 2.2 DTI 16V (F75), OPEL Zafira A (T98) 1.6 16V (F75), OPEL Zafira A (T98) 1.8 16V (F75), OPEL Zafira A (T98) 1.8 16V (F75), OPEL Zafira A (T98) 2.2 16V (F75), OPEL Zafira A (T98) 2.0 DTI 16V (F75), OPEL Zafira A (T98) 1.6 CNG (F75), OPEL Zafira A (T98) 2.2 DTI 16V (F75), OPEL Zafira A (T98) 1.6 (F75), OPEL Zafira A (T98) 1.6 LPG (F75), OPEL Zafira A (T98) 1.6 LPG (F75) … View more
The steps may slightly vary depending on the car design.
OPEL Zafira A (T98) 2.2 DTI 16V (F75), OPEL Zafira A (T98) 1.6 16V (F75), OPEL Zafira A (T98) 1.8 16V (F75), OPEL Zafira A (T98) 1.8 16V (F75), OPEL Zafira A (T98) 2.2 16V (F75), OPEL Zafira A (T98) 2.0 DTI 16V (F75), OPEL Zafira A (T98) 1.6 CNG (F75), OPEL Zafira A (T98) 2.2 DTI 16V (F75), OPEL Zafira A (T98) 1.6 (F75), OPEL Zafira A (T98) 1.6 LPG (F75), OPEL Zafira A (T98) 1.6 LPG (F75) … View more
The steps may slightly vary depending on the car design.
How to change front brake pads / front brake pad set on OPEL ZAFIRA-A 1 (T98) [TUTORIAL AUTODOC]
All the parts you need to replace – Brake Pads for Zafira A (T98) and other OPEL models
Brake pad set
Alternative products
Brake pad set
Wire brush
WD-40 spray
Brake cleaner
Anti-squeal paste
Copper grease
HEX bit No.H7.
Wheel impact socket #19
Ratchet wrench
Torque wrench
Brake caliper wind back tool
Crow bar
Wheel chock
Replacement: brake pads – Opel Zafira F75. AUTODOC recommends:
- Perform the replacement of brake pads in complete set for each axis. This provides effective braking.
- The replacement procedure is identical for all brake pads on the same axle.
- Please note: all work on the car – Opel Zafira F75 – should be done with the engine switched off.
Carry out replacement in the following order:
- Step 1
Open the bonnet. Unscrew the brake fluid reservoir cap. - Step 2
Secure the wheels with chocks. - Step 3
Loosen the wheel mounting bolts. Use wheel impact socket #19. - Step 4
Raise the front of the car and secure on supports. - Step 5
Unscrew the wheel bolts.AUTODOC recommends:Warning! To avoid injury, hold the wheel while unscrewing the fastening bolts. Opel Zafira F75 - Step 6
Remove the wheel. - Step 7
Remove the dust boot caps of the brake caliper guide pins. Use a crowbar. - Step 8
Unscrew the brake caliper fastening. Use HEX No.H7. Use a ratchet wrench. - Step 9
Spread the brake pads. Use a crowbar. - Step 10
Detach the brake caliper retaining spring. Use a crowbar. - Step 11
Remove the brake caliper.Replacement: brake pads – Opel Zafira F75. Professionals recommend:Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary. - Step 12
Remove the brake pads.Replacement: brake pads – Opel Zafira F75. AUTODOC experts recommend:Measure the brake disc thickness. Upon reaching the wear limit the part must be replaced. - Step 13
Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.AUTODOC recommends:Replacement: brake pads – Opel Zafira F75. After applying the spray, wait a few minutes. - Step 14
Treat the brake caliper piston. Use a brake cleaner.Replacement: brake pads – Opel Zafira F75. Tip from AUTODOC experts:After applying the spray, wait a few minutes. - Step 15
Press in the brake caliper piston. Use brake caliper wind back tool. - Step 16
Treat the brake pads in the area where their surface comes into contact with the brake caliper bracket. Use anti-squeal paste.Replacement: brake pads – Opel Zafira F75. Tip:Make sure the disc surface is clean before installing the pads.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
Users voted – 0
Searching for the right tyres?
Find out which tyre and wheel sizes are compatible with the OPEL Zafira A (T98) model.
Popular maintenance tutorials for Opel Zafira f75
Free download PDF
1.8 MB
Free download PDF2.3 MB
Free download PDF2.54 MB
Free download PDF2.29 MB
Free download PDF2.4 MB
Free download PDF1.79 MB
Complete guides for changing the Brake pad set on different OPEL ZAFIRA models
Free download PDF1.6 MB
Free download PDF2.14 MB- Free download PDF1.8 MB
Free download PDF2.32 MB
Free download PDF2.84 MB
Free download PDF1.68 MB
Your profile is your personal assistant.
It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents
Install the AUTODOC CLUB app!
Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.
Scan
To download the app:
- - scan the QR code
- - download from App Store
- - download from Google Play
Tips & tricks for your OPEL Zafira A (T98)
View more
How to Make a DIY Foam Sprayer | AUTODOC tips
Save Money on Fuel with These Easy Tips | AUTODOC
3 things to know before buying summer tyres | AUTODOC tips
How to wash your car in winter | AUTODOC tips
