Recommended replacement interval for the part category Brake pad set : 30000 km

Important!

This replacement procedure can be used for:
FIAT Cinquecento Box Body / Hatchback (170) 1.1 iE (170AH), FIAT Cinquecento Box Body / Hatchback (170) 0.9 iE (170CF) … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Brake Pads for Cinquecento Box Body / Hatchback (170) and other FIAT models

Brake pad set

Brake pad set for Cinquecento Box Body / Hatchback (170) Petrol (54 hp)

Simple DIY car repair steps – Replacing Brake pad set on Cinquecento Box Body / Hatchback (170)

Brake pad set for Cinquecento Box Body / Hatchback (170) Petrol (39 hp)

Replacement: brake pads – FIAT Cinquecento Kasten / Schrägheck (170). List of the tools you'll need:

                        Wire brush
                      
                        Nylon cleaning brush
                      
                        WD-40 spray
                      
                        All-purpose cleaning spray
                      
                        Brake cleaner 
                      
                        Anti-squeal paste
                      
                        Copper grease 
                      
                        Torque wrench
                      
                        Wheel impact socket #17
                      
                        Brake caliper wind back tool
                      
                        Crow bar
                      
                        Pin punch
                      
                        Hammer
                      
                        Round-nose pliers
                      
                        Wheel chock

Buy tools

Replacement: brake pads – FIAT Cinquecento Kasten / Schrägheck (170). AUTODOC experts recommend:

Perform the replacement of brake pads in complete set for each axis. This provides effective braking.
The replacement procedure is identical for all brake pads on the same axle.
Please note: all work on the car – FIAT Cinquecento Kasten / Schrägheck (170) – should be done with the engine switched off.

Carry out replacement in the following order:

Step 1

Open the bonnet. Unscrew the brake fluid reservoir cap.

Step 2

Secure the wheels with chocks.
Step 3

Loosen the wheel mounting bolts. Use wheel impact socket #17.
Step 4

Raise the front of the car and secure on supports.

Step 5

Unscrew the wheel bolts.

AUTODOC recommends:
Warning! To avoid injury, hold the wheel while unscrewing the fastening bolts. FIAT Cinquecento Kasten / Schrägheck (170)
Step 6

Remove the wheel.
Step 7

Clean the brake caliper fasteners. Use a wire brush. Use WD-40 spray. Use all-purpose cleaning spray.
Step 8

Spread the brake pads. Use a crowbar.
Step 9

Remove the lock pin retainer clip. Use round-nose pliers.
Step 10

Remove the brake caliper cotter pin. Use a pin punch. Use a hammer.
Step 11

Lift the caliper up.

Replacement: brake pads – FIAT Cinquecento Kasten / Schrägheck (170). Tip from AUTODOC experts:
Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
Step 12

Remove the brake pads.

Replacement: brake pads – FIAT Cinquecento Kasten / Schrägheck (170). Tip from AUTODOC experts:
Measure the brake disc thickness. Upon reaching the wear limit the part must be replaced.
Step 13

Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use all-purpose cleaning spray.
Step 14

Treat the brake caliper piston. Use a nylon cleaning brush. Use a brake cleaner.

AUTODOC recommends:
Replacement: brake pads – FIAT Cinquecento Kasten / Schrägheck (170). After applying the spray, wait a few minutes.
Step 15

Press in the brake caliper piston. Use brake caliper wind back tool.
Step 16

Treat the brake pads in the area where their surface comes into contact with the brake caliper bracket. Use anti-squeal paste.

Replacement: brake pads – FIAT Cinquecento Kasten / Schrägheck (170). Tip:
Make sure the disc surface is clean before installing the pads.
Step 17

Install new brake pads.

Replacement: brake pads – FIAT Cinquecento Kasten / Schrägheck (170). Tip from AUTODOC:
Make sure the pads are installed with linings facing the disc.
Step 18

Install the brake caliper and fix it.
Step 19

Install the brake caliper cotter pin. Use a pin punch. Use a hammer.
Step 20

Install the lock pin retainer clip. Use round-nose pliers.
Step 21

Treat the surface where the brake disc contacts the wheel rim. Use copper grease.
Step 22

Clean the brake disk surface. Use a brake cleaner.

AUTODOC recommends:
Replacement: brake pads – FIAT Cinquecento Kasten / Schrägheck (170). After applying the spray, wait a few minutes.
Step 23

Install the wheel.

AUTODOC recommends:
Important! Hold the wheel while screwing in the fastening bolts. FIAT Cinquecento Kasten / Schrägheck (170)
Step 24

Screw in the wheel bolts. Use wheel impact socket #17.
Step 25

Lower the car and working in a cross order, tighten the wheel bolts. Use wheel impact socket #17. Use a torque wrench. Tighten it to 98 Nm torque.
Step 26

Remove the jacks and chocks.

Replacement: brake pads – FIAT Cinquecento Kasten / Schrägheck (170). AUTODOC experts recommend:
Check the brake fluid level in the expansion tank and refill if necessary.
Step 27

Tighten the brake fluid reservoir cap.

Replacement: brake pads – FIAT Cinquecento Kasten / Schrägheck (170). Professionals recommend:
Without starting the engine, press the brake pedal several times until you feel significant resistance.
Step 28

Close the hood.

Replacement: brake pads – FIAT Cinquecento Kasten / Schrägheck (170). Tip from AUTODOC:
Slow down smoothly for first 150-200 km after the brake pads replacement. Avoid unneccessary and sharp braking to a stop.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Searching for the right tyres?

Find out which tyre and wheel sizes are compatible with the FIAT Cinquecento Box Body / Hatchback (170) model.

Browse tyres

How to change front brake discs on FIAT Cinquecento Box Body / Hatchback (170) – replacement guide

Free download PDF
2.07 MB
How to change rear brake discs on FIAT Cinquecento Box Body / Hatchback (170) – replacement guide

Free download PDF
1.93 MB
How to change spark plugs on FIAT Cinquecento Box Body / Hatchback (170) – replacement guide

Free download PDF
1.46 MB
How to change fuel filter on Fiat Doblo Cargo – replacement guide

Free download PDF
2.14 MB
How to change serpentine belt on Fiat Doblo Cargo – replacement guide

Free download PDF
2.43 MB
How to change engine oil and filter on Fiat Punto 199 – replacement guide

Free download PDF
2.37 MB

How to change front brake pads on FIAT Cinquecento (170) – replacement guide

Free download PDF
2.46 MB
How to change brake pads on a car – replacement tutorial

Universal

Free download PDF
2.84 MB
How to change front brake pads on Fiat Panda 169 – replacement guide

Free download PDF
2.51 MB
How to change rear brake pads on Fiat 500 312 – replacement guide

Free download PDF
1.86 MB
How to change front brake pads on Fiat Punto 188 – replacement guide

Free download PDF
1.61 MB
How to change front brake pads on Fiat Punto 199 – replacement guide

Free download PDF
1.7 MB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

Petrol or diesel? What's the difference between these engines? | AUTODOC

4K views

Published on: 04/05/2021
How do EGR valves work? | AUTODOC

18K views

Published on: 18/07/2020
How to Make a DIY Foam Sprayer | AUTODOC tips

206K views

Published on: 23/06/2022
Car checks you need to carry out on your car after the winter | AUTODOC tips

3K views

Published on: 23/03/2023