
Disclaimer
How to change front brake discs on VW Tiguan Allspace (BW2) – replacement guide
downloads:
13
Views:
207

Recommended replacement interval for the part category Brake disc : 50000 km
Important!
This replacement procedure can be used for:
VW Tiguan Allspace (BW2) 2.0 TDI 4motion … View more
The steps may slightly vary depending on the car design.
VW Tiguan Allspace (BW2) 2.0 TDI 4motion … View more
The steps may slightly vary depending on the car design.
This video shows the replacement procedure of a similar car part on another vehicle
All the parts you need to replace – Brake Discs for Tiguan Allspace (BW2) and other VW models
Brake disc
Alternative products

Wire brush
WD-40 spray
Brake cleaner
Copper grease
Drive socket # 21
HEX bit no.H7.
Torx bit T30
Wheel impact socket #17
Brake caliper wind back tool
Ratchet wrench
Torque wrench
Tap wrench
Impact screwdriver
Crow bar
Wheel chock
Replacement: brake discs – VW TIGUAN ALLSPACE (BW2). Tip:
- Replace the brake disks on the car VW TIGUAN ALLSPACE (BW2) in complete set for each axis. Regardless of the state of components. This will ensure even braking.
- The replacement procedure is identical for both brake disks on the same axle.
- When changing the brake discs, always replace the brake pads.
- All work should be done with the engine stopped.
Replacement: brake discs – VW TIGUAN ALLSPACE (BW2). Recommended sequence of steps:
- Step 1Open the bonnet. Unscrew the brake fluid reservoir cap.Step 2Secure the wheels with chocks.
- Step 3Loosen the wheel mounting bolts. Use wheel impact socket #17.
- Step 4Raise the front of the car and secure on supports.Step 5Unscrew the wheel bolts.Replacement: brake discs – VW TIGUAN ALLSPACE (BW2). AUTODOC recommends:To avoid injury, hold up the wheel when unscrewing the bolts.
- Step 6Remove the wheel.
- Step 7Spread the brake pads. Use a crowbar.
- Step 8Remove the dust boot caps of the brake caliper guide pins. Use a crowbar.
- Step 9Unscrew the brake caliper fastening. Use HEX No.H7. Use a ratchet wrench.
- Step 10Detach the brake caliper retaining spring. Use a crowbar.
- Step 11Remove the brake caliper.Replacement: brake discs – VW TIGUAN ALLSPACE (BW2). Professionals recommend:Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
- Step 12Remove the brake pads.
- Step 13Clean the brake caliper bracket fasteners. Use a wire brush. Use WD-40 spray.
- Step 14Unscrew the caliper bracket fastening. Use a drive socket #21. Use a tap wrench. Use a ratchet wrench.
- Step 15Remove the caliper bracket.
- Step 16Clean the brake disc fasteners. Use a wire brush. Use WD-40 spray.
- Step 17Unscrew the brake disc fastening. Use Torx T30. Use an impact screwdriver.
- Step 18Remove the brake disc.
- Step 19Clean the hub. Use a wire brush. Treat the contacting surface. Use copper grease.
- Step 20Install the brake disc.
- Step 21Tighten the brake disc fastening. Use Torx T30. Use a torque wrench. Tighten it to 4 Nm torque.
- Step 22Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.AUTODOC recommends:Replacement: brake discs – VW TIGUAN ALLSPACE (BW2). After applying the spray, wait a few minutes.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
Users voted – 0
Need New Tyres?
Find out which tyre and wheel sizes are compatible with the VW Tiguan Allspace (BW2) model
Popular maintenance tutorials for VW TIGUAN ALLSPACE (BW2)
Complete guides for changing the Brake rotors on different VW TIGUAN models
Unlock your car maintenance assistant!
Track expenses, manage logs, schedule replacements, and more.
Tips & tricks for your VW Tiguan Allspace (BW2)
View more
- Deep interior cleaning | Car transformation by detailing
- When, why, and how to change engine oil | AUTODOC tips
- 5 Ways You’re Scrubbing Your Car Wrong | AUTODOC Tips
- 7 signs of faulty fuel injectors | AUTODOC tips
Most commonly replaced car parts on VW TIGUAN
Time to replace parts? Get even better deals in our Shop app.

SCAN ME