Recommended replacement interval for the part category Brake disc : 50000 km

Important!

This replacement procedure can be used for:
OPEL Meriva B (S10) 1.4 LPG (75), OPEL Meriva B (S10) 1.4 (75), OPEL Meriva B (S10) 1.4 (75), OPEL Meriva B (S10) 1.7 CDTI (75), OPEL Meriva B (S10) 1.3 CDTI (75), OPEL Meriva B (S10) 1.3 CDTI (75), OPEL Meriva B (S10) 1.7 CDTI (75) … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

Alternative products

Brake disc

Replacement: brake discs – OPEL MERIVA B. List of the tools you'll need:

                      Wire brush
                    
                      WD-40 spray
                    
                      Brake cleaner 
                    
                      Copper grease 
                    
                      Drive socket # 18 
                    
                      HEX bit No.H5.
                    
                      HEX bit No.H7.
                    
                      Wheel impact socket #17
                    
                      Brake caliper wind back tool
                    
                      Ratchet wrench
                    
                      Torque wrench
                    
                      Tap wrench
                    
                      Rubber mallet
                    
                      Crow bar
                    
                      Wheel chock

Buy tools

Replacement: brake discs – OPEL MERIVA B. Tip from AUTODOC experts:

Replace the brake disks on the car OPEL MERIVA B in complete set for each axis. Regardless of the state of components. This will ensure even braking.
The replacement procedure is identical for both brake disks on the same axle.
When changing the brake discs, always replace the brake pads.
All work should be done with the engine stopped.

Replacement: brake discs – OPEL MERIVA B. Take the following steps:

Step 1

Open the bonnet. Unscrew the brake fluid reservoir cap.

Step 2

Secure the wheels with chocks.
Step 3

Loosen the wheel mounting bolts. Use wheel impact socket #17.
Step 4

Raise the front of the car and secure on supports.

Step 5

Unscrew the wheel bolts.

Replacement: brake discs – OPEL MERIVA B. AUTODOC recommends:
To avoid injury, hold up the wheel when unscrewing the bolts.
Step 6

Remove the wheel.
Step 7

Remove the dust boot caps of the brake caliper guide pins. Use a crowbar.
Step 8

Unscrew the brake caliper fastening. Use HEX No.H7. Use a ratchet wrench.
Step 9

Spread the brake pads. Use a crowbar.
Step 10

Pull aside the brake caliper retaining spring. Use a crowbar.
Step 11

Remove the brake caliper.

Replacement: brake discs – OPEL MERIVA B. Professionals recommend:
Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
Step 12

Remove the brake pads.
Step 13

Clean the brake caliper bracket fasteners. Use a wire brush. Use WD-40 spray.
Step 14

Unscrew the caliper bracket fastening. Use a drive socket #18. Use a tap wrench.
Step 15

Remove the caliper bracket.
Step 16

Clean the brake disc fasteners. Use a wire brush. Use WD-40 spray.
Step 17

Unscrew the brake disc fastening. Use HEX No.H5. Use a ratchet wrench.
Step 18

Remove the brake disc.

Replacement: brake discs – OPEL MERIVA B. Tip from AUTODOC:
If necessary, use a rubber mallet.
Step 19

Clean the hub. Use a wire brush. Treat the contacting surface. Use copper grease.
Step 20

Install the brake disc.
Step 21

Tighten the brake disc fastening. Use HEX No.H5. Use a torque wrench. Tighten it to 7 Nm torque.
Step 22

Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.

AUTODOC recommends:
Replacement: brake discs – OPEL MERIVA B. After applying the spray, wait a few minutes.
Step 23

Install the brake caliper bracket.
Step 24

Tighten the brake caliper bracket. Use a drive socket #18. Use a torque wrench. Tighten it to 100 Nm torque.
Step 25

Treat the brake caliper piston. Use a brake cleaner.

Replacement: brake discs – OPEL MERIVA B. AUTODOC experts recommend:
After applying the spray, wait a few minutes.
Step 26

Press in the brake caliper piston. Use brake caliper wind back tool.
Step 27

Install the brake pads.
Step 28

Install the brake caliper and fix it. Use HEX No.H7. Use a torque wrench. Tighten it to 28 Nm torque.

AUTODOC recommends:
OPEL MERIVA B – Without starting the engine, press the brake pedal several times until it feels firm.
Step 29

Install the dust boot caps of the brake caliper guide pins.
Step 30

Snap the brake caliper retaining spring back into place. Use a crowbar.
Step 31

Treat the surface where the brake disc contacts the wheel rim. Use copper grease.
Step 32

Clean the brake disk surface. Use a brake cleaner.

Replacement: brake discs – OPEL MERIVA B. Tip:
After applying the spray, wait a few minutes.
Step 33

Install the wheel.

AUTODOC recommends:
Important! Hold the wheel while screwing in the fastening bolts. OPEL MERIVA B
Step 34

Screw in the wheel bolts. Use wheel impact socket #17.
Step 35

Lower the car and working in a cross order, tighten the wheel bolts. Use a torque wrench. Tighten it to 110 Nm torque.
Step 36

Remove the jacks and chocks.

AUTODOC recommends:
Check the brake fluid level in the expansion tank and refill if necessary.
Step 37

Tighten the brake fluid reservoir cap. Close the hood.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Need New Tyres?

Find out which tyre and wheel sizes are compatible with the OPEL Meriva B (S10) model

Opel Meriva B tyre size

How to change front brake caliper on OPEL Meriva B (S10) – replacement guide

Free download PDF 2.28 MB
How to change rear brake discs on OPEL Meriva B (S10) – replacement guide

Free download PDF 2.4 MB
How to change front brake pads on OPEL Meriva B (S10) – replacement guide

Free download PDF 1.45 MB
How to change rear brake pads on OPEL Meriva B (S10) – replacement guide

Free download PDF 2.34 MB
How to change rear wheel bearing on OPEL Meriva B (S10) – replacement guide

Free download PDF 2.99 MB
How to change spark plugs on OPEL Meriva B (S10) – replacement guide

Free download PDF 1.25 MB

How to change rear brake discs on OPEL Meriva B (S10) – replacement guide

Free download PDF 2.4 MB
How to change front brake discs on Opel Meriva X03 – replacement guide

Free download PDF 2.1 MB
How to change rear brake discs on Opel Meriva X03 – replacement guide

Free download PDF 2.08 MB
How to change brake discs on a car – replacement tutorial

Universal

Free download PDF 2.92 MB
How to change front brake discs on Opel Corsa D – replacement guide

Free download PDF 2.21 MB
How to change front brake discs on Opel Corsa C – replacement guide

Free download PDF 1.9 MB

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

Top 5 Mistakes to Avoid for Safe Engine Bay Repairs | AUTODOC Tips

9K views

Published on: 04/08/2023
How to fix your car with AUTODOC CLUB

17K views

Published on: 30/11/2021
Initial Car Inspection: What to Check Before You Buy

5K views

Published on: 24/10/2020
How to prevent car windows from fogging up | AUTODOC tips

13K views

Published on: 04/02/2021